Table of Contents
Advertisement
Quick Links
Dell™ Latitude™ D610 Service Manual
Before You Begin
System Components
Internal Card With Bluetooth® Wireless Technology
Hard Drive
Center Control Cover
Keyboard
Memory Module, Modem, and Devices
Coin-Cell Battery
Mini PCI Card
Display Assembly and Display Latch
Notes, Notices, and Cautions
NOTE:
A NOTE indicates important information that helps you make better use of your computer.
NOTICE:
A NOTICE indicates either potential damage to hardware or loss of data and tells you how to avoid the problem.
CAUTION:
A CAUTION indicates a potential for property damage, personal injury, or death.
____________________
Information in this document is subject to change without notice.
© 2004–2005 Dell Inc. All rights reserved.
Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden.
Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Intel is a registered trademark of Intel Corporation; Bluetooth is a registered trademark
owned by Bluetooth SIG, Inc. and is used by Dell Inc. under license.
Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any
proprietary interest in trademarks and trade names other than its own.
Model PP11L
November 2005 Rev. A01
Palm Rest
Fan
Microprocessor Thermal-Cooling Assembly
Microprocessor Module
Speaker Assembly
Base Latch
System Board
Flashing the BIOS
Pin Assignments for I/O Connectors
Advertisement
Table of Contents
Related Manuals for Dell 610D
Summary of Contents for Dell 610D
- Page 1 Bluetooth SIG, Inc. and is used by Dell Inc. under license. Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any proprietary interest in trademarks and trade names other than its own.
-
Page 2: Before You Begin
CAUTION: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. Read and follow applicable instructions in the safety instructions in the Product Information Guide that came with the computer. -
Page 3: Recommended Tools
11. Remove any installed memory modules, Mini PCI cards, and devices, including a second battery if one is installed. 12. Remove the hard drive (see "Removing the Hard Drive"). Recommended Tools The procedures in this manual require the following tools: #1 Phillips screwdriver ¼-inch flat-blade screwdriver Small plastic scribe... - Page 4 Display Assembly: Display Bezel: Display Panel: (4 each) (6 each) (4 each) Display Latch: Palm Rest: Fan: (1 each) (2 each at top) (2 each) (13 each at bottom) Speakers: Modem: System Board: (2 each—1 on each side) (1 each) (5 each) ...
-
Page 5: Flashing The Bios
Back to Contents Page Flashing the BIOS Dell™ Latitude™ D610 Service Manual 1. Ensure that the AC adapter is plugged in and that the main battery is installed properly. NOTE: If you use a BIOS update program CD to flash the BIOS, set up the computer to boot from a CD before inserting the CD. -
Page 6: Internal Card With Bluetooth® Wireless Technology
Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ Latitude™ D610 Service Manual Removing the Internal Card With Bluetooth® Wireless Technology Installing the Internal Card With Bluetooth® Wireless Technology CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide. - Page 7 2. Connect the card to the card cable connector, slide the door with the card into the card compartment, and gently press the door into position. 3. Replace the battery. Back to Contents Page ...
-
Page 8: Removing The Coin-Cell Battery
Back to Contents Page Coin-Cell Battery Dell™ Latitude™ D610 Service Manual Removing the Coin-Cell Battery Installing the Coin-Cell Battery CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. CAUTION: To prevent static damage to components inside your computer, discharge static electricity from your body before you touch any of your computer's electronic components. -
Page 9: Installing The Coin-Cell Battery
3 coin-cell battery cable connector 4 securing sleeve Installing the Coin-Cell Battery 1. Connect the coin-cell battery cable connector to the battery connector on the system board. 2. Slide the battery into the securing sleeve. 3. Replace the modem cover. Back to Contents Page ... -
Page 10: Microprocessor Module
Back to Contents Page Microprocessor Module Dell™ Latitude™ D610 Service Manual Removing the Microprocessor Module Installing the Microprocessor Module Removing the Microprocessor Module CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. - Page 11 Installing the Microprocessor Module NOTICE: Ensure that the cam lock is in the fully open position before seating the microprocessor module. Seating the microprocessor module properly in the ZIF socket does not require force. NOTICE: A microprocessor module that is not properly seated can result in an intermittent connection or permanent damage to the microprocessor and ZIF socket.
-
Page 12: Display Assembly
Back to Contents Page Display Assembly and Display Latch Dell™ Latitude™ D610 Service Manual Display Assembly Display Bezel Display Panel Display Latch Display Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. -
Page 13: Display Bezel
8. Lift the display assembly up and out of the computer base. Installing the Display Assembly 1. Align the display assembly over the screw holes in the base of the computer. 2. Tighten the four M2.5 x 5-mm screws. ... -
Page 14: Display Panel
NOTICE: Carefully separate the bezel from the top cover to avoid damage to the bezel. 7. Starting at the bottom of the display panel (by the Dell™ logo), use your fingers to separate the bezel from the top cover by lifting the inside edge of the bezel and rotating away from the top cover. NOTE: Follow the same procedure on all four sides of the display bezel until it snaps completely off. -
Page 15: Removing The Display Panel
Removing the Display Panel 1. Follow the instructions in "Preparing to Work Inside the Computer." 2. Remove the center control cover (see "Removing the Center Control Cover"). 3. Remove the keyboard (see "Removing the Keyboard"). 4. -
Page 16: Installing The Display Panel
display panel top cover M2 x 3-mm screws (4) 8. Remove the display panel from the top cover. 9. Use the pull-tab to disconnect the bottom flex-cable connector from the inverter connector. top flex-cable connector top display-cable connector pull-tab on bottom flex-cable connector ... - Page 17 7. Remove the display latch (see "Removing the Display Latch"). M2.5 x 5-mm screw display latch guide pins (2) top cover Installing the Display Latch 1. Align the latch on the guide pins located on the top cover. ...
-
Page 18: Removing The Fan
Back to Contents Page Fan Dell™ Latitude™ D610 Service Manual Removing the Fan Installing the Fan CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. - Page 19 Back to Contents Page ...
-
Page 20: Removing The Hard Drive
NOTICE: Hard drives are extremely fragile; even a slight bump can damage the drive. NOTE: Dell does not guarantee compatibility or provide support for hard drives from sources other than Dell. Removing the Hard Drive 1. Follow the instructions in "Preparing to Work Inside the... - Page 21 5. Press the hard drive cover down until it is fully seated in the bay, and tighten the screws. 6. Install the operating system for your computer. 7. Install the drivers and utilities for your computer. Back to Contents Page ...
- Page 22 Back to Contents Page Center Control Cover Dell™ Latitude™ D610 Service Manual Removing the Center Control Cover Installing the Center Control Cover CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide.
-
Page 23: Removing The Keyboard
Back to Contents Page Keyboard Dell™ Latitude™ D610 Service Manual Removing the Keyboard Installing the Keyboard CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. - Page 24 2. Slide the keyboard tabs at the bottom of the keyboard into the base of the computer. NOTE: You may need to slightly push the keyboard tabs into the base of the computer. 3. Tighten the two M2.5 x 5-mm screws across the top of the keyboard. ...
-
Page 25: Base Latch
Back to Contents Page Base Latch Dell™ Latitude™ D610 Service Manual Removing the Base Latch Installing the Base Latch CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. -
Page 26: Mini Pci Card
Back to Contents Page Mini PCI Card Dell™ Latitude™ D610 Service Manual Removing the Mini PCI Card Installing the Mini PCI Card CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. -
Page 27: Installing The Mini Pci Card
1 Mini PCI card 2 metal securing tabs (2) Installing the Mini PCI Card NOTICE: To avoid damaging the antenna cables or the Mini PCI card, never place the cables under the card. NOTICE: The connectors are keyed to ensure correct insertion. If you feel resistance, check the connectors and realign the card. ... - Page 28 Mini PCI card antenna wires (2) 3. Replace the keyboard (see "Installing the Keyboard"). 4. Replace the center control cover (see "Installing the Center Control Cover"). Back to Contents Page ...
-
Page 29: Removing The Palm Rest
Back to Contents Page Palm Rest Dell™ Latitude™ D610 Service Manual Removing the Palm Rest Installing the Palm Rest CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. -
Page 30: Installing The Palm Rest
M2.5 x 8-mm screws (13) NOTICE: Carefully separate the palm rest from the computer base to avoid damage to the palm rest. 8. Starting at the back center of the palm rest, use your fingers to separate the palm rest from the computer base by lifting the inside of the palm rest while pushing in on the outside. -
Page 31: Usb Connector
Back to Contents Page Pin Assignments for I/O Connectors Dell™ Latitude™ D610 Service Manual USB Connector Video Connector Parallel Connector USB Connector Signal USB5V+ USBP– USBP+ Video Connector Signal Signal CRT_R 9 CRT_G 10 CRT_B 11 MONITOR_DETECT–... - Page 32 Signal Signal STROBE– 10 ACK– BUSY SLCT AFD/3M– ERROR– INIT– SLIN– 18-25 GND Back to Contents Page ...
-
Page 33: Removing The Speaker Assembly
Back to Contents Page Speaker Assembly Dell™ Latitude™ D610 Service Manual Removing the Speaker Assembly Installing the Speaker Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. - Page 34 ...
-
Page 35: Removing The System Board
Back to Contents Page System Board Dell™ Latitude™ D610 Service Manual Removing the System Board Installing the System Board Removing the System Board CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. -
Page 36: Installing The System Board
M2.5 x 4-mm screws (4) PCMCIA card cage 12. Turn the computer over and remove the five M2 x 3-mm screws labeled "B" that secure the system board assembly to the computer base. M2 x 3-mm screws (5) 13. - Page 37 ...
-
Page 38: System Components
System Components Dell™ Latitude™ D610 Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this document assumes that a part can be replaced by performing the removal procedure in reverse order. - Page 39 Back to Contents Page Microprocessor Thermal-Cooling Assembly Dell™ Latitude™ D610 Service Manual Removing the Microprocessor Thermal-Cooling Assembly Installing the Microprocessor Thermal-Cooling Assembly Removing the Microprocessor Thermal-Cooling Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide.
- Page 40 Back to Contents Page ...
- Page 41 Bluetooth SIG, Inc. and is used by Dell Inc. under license. Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any proprietary interest in trademarks and trade names other than its own.
-
Page 42: Memory Module
You can only use DDR2 memory modules in your computer. NOTE: Memory modules purchased from Dell are covered under your computer warranty. Your computer has two user-accessible SODIMM sockets, one accessed from beneath the keyboard (DIMM A), and the other accessed from the bottom of the computer (DIMM B). -
Page 43: Installing The Memory Module
NOTICE: If you need to install memory modules in two connectors, install a memory module in the connector labeled "DIMM B" before you install a module in the connector labeled "DIMM A." Removing the Memory Module From DIMM B ... -
Page 44: Removing The Modem
1. Ground yourself and install the new memory module: a. Align the notch in the module with the slot in the center of the connector. b. Slide the edge of the module firmly into the connector, and rotate the module down until you feel a click. If you do not feel the click, remove the module and reinstall it. - Page 45 captive screw 4. Remove the M2 x 3-mm screw that attaches the modem. 5. Pull up on the pull-tab to disconnect the modem from the connector on the system board. 1 M2 x 3-mm screw 2 modem NOTICE: Do not disconnect the modem cable from the system board.
- Page 46 4. Replace the modem cover. Devices Your computer ships with an optical drive installed in the module bay. However, the device security screw is not installed in the optical drive but packaged separately. When you install your device in the module bay, you can install the device security screw. NOTICE: Insert devices into the module bay before you dock and turn on the computer.
-
Page 47: Installing The Device
M2 x 3-mm screw 4. Press the device latch release so that the latch release pops out. 5. Pull the device by the latch release to remove the device from the module bay. Installing the Device 1.