KUSSMAUL 091-32-S Instruction Manual

Start-up and shut down load sequencer and automatic load shedding system for systems where relay coils are wired to ground

LOAD MANAGER-S

A START-UP AND SHUT DOWN LOAD SE-

QUENCER AND AUTOMATIC LOAD SHEDDING

SYSTEM FOR SYSTEMS WHERE RELAY COILS

ARE WIRED TO GROUND

KUSSMAUL ELECTRONICS CO., INC

170 CHERRY AVE., WEST SAYVILLE, N.Y. 11796

TEL: in NY 631-567-0314

631-567-0314

INSTRUCTION MANUAL

MODEL #091-32-S

3 YEAR WARRANTY

TOLL FREE: 800-346-0857

800-346-0857

FAX: 631-567-5826

800-346-0857

BOOK# 091-32-S

rev.A, 12-16-2004

631-567-5826

Table of Contents

Need help?

Do you have a question about the 091-32-S and is the answer not in the manual?

Page 1 A START-UP AND SHUT DOWN LOAD SE- QUENCER AND AUTOMATIC LOAD SHEDDING SYSTEM FOR SYSTEMS WHERE RELAY COILS ARE WIRED TO GROUND MODEL #091-32-S 3 YEAR WARRANTY KUSSMAUL ELECTRONICS CO., INC 170 CHERRY AVE., WEST SAYVILLE, N.Y. 11796 TEL: in NY 631-567-0314 631-567-0314 631-567-0314 631-567-0314...
Page 2 INTRODUCTION The LOAD MANAGER is a device which: 1. Sequentially energizes and deenergizes relays at approximately 1/2 second intervals in order to reduce transients in a vehicle’s electrical system. 2. Detects when the vehicle’s electrical load is greater than the output of the alternator.
Page 3 CAUTION There are 5 switches, each with 5 levers. Only one lever on each switch may be in the “ON” position. Each switch controls the operation of a relay. The actuation sequence of a particular relay is controlled by the individual levers of each switch. Lever #5 is the lowest priority, while lever #1 is the highest.
Page 4 Figure 2, Basic Switch Settings...
Page 5 Figure 3, Outline, load Manager...
Page 6 LOAD MANAGER 091-32-S...
Page 7 Vehicle Identification Vehicle Owner WARRANTY All products of Kussmaul Electronics Company Inc. are warranted to be free of defects of material or workmanship. Liability is limited to repairing or replacing at our factory, without charge, any material or defects which become apparent in normal use within 3 years from the date the equipment was shipped.