Table of Contents
Advertisement
For Model numbers:
WARNING: If the information in this manual is
not followed exactly, a fire or explosion may
result causing property damage, personal injury
or loss of life.
WHAT TO DO IF YOU SMELL GAS:
high efficiency wall boiler
C100, C140, C200
H100, H140, H200
Installation
Service and maintenance
Start up
Parts
Switch off the appliance.
Shut off the gas supply.
Open the windows.
Do not try to light any appliance.
Do not touch any electric switch.
Do not use any phone in your building.
Leave the house.
Immediately call your gas supplier from a
neighbour's phone. Follow the gas
supplier's instructions.
If you cannot reach your gas supplier,
call the fire department.
WHAT TO DO IF YOU SMELL FLUE
GASSES:
Switch off the appliance.
Open the windows.
Shut off the gas supply.
Leave the house.
Contact a registered installer or
a registered service center.
EcoKing Supreme
Installation Manual
2015
Advertisement
Table of Contents
Troubleshooting
Related Manuals for EcoKing H140
Summarization of Contents
Part 1 - Introduction
Hazard Definitions
Defines terms used to highlight hazards of various risk levels or important product information.
User Responsibilities
Outlines the user's role in maintaining and servicing the boiler and understanding its operation.
Boiler Operation and Manufacturer Conditions
Details boiler operation guidelines and manufacturer responsibilities regarding installation and service.
Installer Responsibilities
Defines the installer's duties for safe and compliant installation and user notification.
Main Boiler Parts
Identifies and describes the primary components of the EcoKing boiler.
Functionality of Main Parts
Explains the operational roles and functions of the boiler's key components.
Part 3 - Appliance Location and Mounting
Location Checks and Requirements
Details checks for wall strength, proximity to utilities, and environmental conditions for installation.
Ventilation Air Openings
Specifies minimum ventilation area requirements for appliance installation areas.
Installation Types: Closet, Alcove, Garage
Provides specific installation guidelines for closet, alcove, and garage locations.
Wall Mounting Procedures
Covers prior-to-wall mounting care, cold weather handling, and the wall mounting process.
Part 4 - General Venting System
Combustion Air Intake Contamination
Warns against locating air intake near contaminants and lists products/sources to avoid.
Concentric Vent System Installation
Provides general instructions for installing concentric vent and air systems.
Wall Terminal Installation
Details instructions for installing vent systems with wall terminals.
Roof Terminal Installation
Provides instructions for installing vent systems with roof terminals.
Venting Rules and Pipe Lengths
Outlines venting rules, guidelines, and pipe length determination for various configurations.
Part 5 - Vent/Air Intake Termination Clearances
Termination Clearance Quick Reference
Provides a table of quick reference clearances for air-inlet and exhaust vent terminations.
Common Venting System Removal
Details procedures for removing an existing boiler from a common venting system.
Part 5.5 - Further Venting Options
Canadian Venting Requirements and Materials
Specifies Canadian requirements for single pipe venting and approved materials.
Part 6 - Condensate Drain
Condensate Drain Cleaning and Disposal
Covers cleaning procedures for the condensate drain and notes on disposal.
Part 7 - Central Heating and DHW Circuit
Air Relief Valve Installation
Instructions for mounting the automatic air relief valve.
System Water Requirements and Protection
Details frost protection, corrosion prevention, and system venting requirements.
Control Module and Backflow Preventer
Explains the control module functions and the need for a backflow preventer.
Connecting CH and DHW Systems
Guides on connecting the central heating and domestic hot water circuits.
Expansion Tanks and Pump Head
Covers external expansion tanks and internal pump head characteristics.
Installation Examples
Provides schematic diagrams for various boiler system configurations.
Part 8 - Gas Piping Installation
Connecting the Gas Line
Details gas piping requirements, sizing, and connection procedures.
Part 9 - Electrical Connections
Accessing and Connecting Components
Guides on opening the boiler cover, power connection, and thermostat connection.
Part 10 - Lighting and First Start-up
Critical Start-up Warnings
Highlights essential safety warnings and precautions before initial operation.
CH System Fill and Refill
Instructions for filling and refilling the central heating system with water.
Control Panel Operation and Parameters
Explains the use of the control panel and setting of appliance parameters.
Weather Dependent and Comfort Control
Details on setting up weather dependent control and hot water comfort levels.
System Venting and Diagnosis
Covers system venting procedures and accessing the diagnosis menu.
Calibration Procedures
Provides steps for manual and automatic calibration of the appliance.
Part 11 - Installation Checklist
Installation and Pre-Start Checks
A checklist for verifying installation steps and pre-start operational checks.
Contractor Handover and Owner Responsibilities
Guidance for installers on handover and informing owners of responsibilities.
Part 12 - Annual Maintenance and Inspection
Annual Inspection Checklist
A checklist for performing annual maintenance and inspection of the appliance.
Refractory Ceramic Fibers (RFC) Handling
Safety and handling instructions for Refractory Ceramic Fibers and potential carcinogens.
Part 14 - Troubleshooting Guide
Servicing, Faults, and Fault History
Guidelines for servicing, displaying faults, and viewing fault history.
Fault Codes and Resetting
Information on fault codes displayed and procedures for resetting faults.
Comfort Complaints and Solutions
Lists common comfort complaints and their potential causes and solutions.
Part 15 - Start Up Checklist
Light Up Activities Checklist
A checklist detailing activities required for initial boiler start-up.
Part 16 - Maintenance Checklist
Periodic Maintenance Inspection Activities
Lists inspection activities for periodic maintenance of the appliance.
Need help?
Do you have a question about the H140 and is the answer not in the manual?
Questions and answers