Page 1
RX-5030VBK SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER 22025 2003 RX-5030VBK Area suffix ----------------- U.S.A. C ----------------- Canada MASTER VOL UME AUDIO/VIDEO CONTROL RECEIVER STANDBY SURROUND DIMMER TA/NEWS/INFO STANDBY/ON INPUT DIGITAL DISPLAY MODE DIGITAL AUTO SPK ONE TO UCH OPE RATIONBASS BOOST...
RX-5030VBK SECTION 1 Important Safety Precautions 1.1 Safety Precautions (1) This design of this product contains special hardware and exposed metal part and a known good earth ground. many circuits and components specially for safety purposes. Measure the AC voltage across the resistor with the AC For continued protection, no changes should be made to the voltmeter.
RX-5030VBK SECTION 2 Disassembly method 2.1 Removing the top cover (See Fig.1) (1) From the right and left sides of the main body, remove the four screws A attaching the top cover. (2) From the back side of the main body, remove the three Top cover screws B attaching the top cover.
Page 5
RX-5030VBK 2.3 Removing the rear panel (See Fig.4) • Prior to performing the following procedure, remove the top cover. Strain relief (1) From the back side of the main body, remove the strain re- lief from the rear panel in the direction of the arrow.
Page 6
RX-5030VBK 2.5 Removing the tuner board (See Fig.6) • Prior to performing the following procedure, remove the top Tie band cover and rear panel. Parallel wires (1) Remove the tie band fixing the parallel wires. (2) Disconnect the tuner board from the connector CN411 on the audio board.
Page 7
RX-5030VBK 2.7 Removing the speaker terminal board (See Fig.8) • Prior to performing the following procedure, remove the top Parallel wires cover and rear panel. (1) From the top side of the main body, remove the solders from the soldered sections a on the speaker terminal board.
Page 8
RX-5030VBK 2.9 Removing the heat sink (See Figs.10 and 11) • Prior to performing the following procedure, remove the top cover and main board. Heat sink (1) Remove the ten screws L attaching the heat sink. (See Fig.10) (2) From the reverse side of the main board, remove the two screws M attaching the heat sink.
Page 9
RX-5030VBK 2.11 Removing the power transformer (See Fig.13) • Prior to performing the following procedure, remove the top Tie band Power transformer cover. board 1 CN251 (1) From the top side of the main body, remove the tie bands fixing the wires.
Page 10
RX-5030VBK 2.14 Removing the headphone jack board (See Figs.14 and 15) • Prior to performing the following procedure, remove the top Headphone jack board cover and front panel assembly. (1) From the top side of the main body, disconnect the parallel...
Page 11
RX-5030VBK SECTION 3 Adjustment 3.1 Tuner section 3.1.1 Tuner range 87.5MHz~108.0MHz AM (MW): 530kHz~1710kHZ 3.2 Power amplifier section 3.2.1 Adjustment of idling current Measurement location: TP301 (Lch), TP302 (Rch) Adjustment part: VR301 (Lch), VR302 (Rch) Attention: This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
RX-5030VBK SECTION 4 Description of major ICs 4.1 AK4527BVQP (IC601): A/D, D/A converter • Pin layout Top View • Pin function Symbol Function SDOS SDTO Source Select Pin (Note 1) "L" : Internal ADC output, "H" : DAUX input OSKS Control Mode Select Pin "L"...
Page 13
RX-5030VBK Symbol Function ICKS Connect to GND No internal bonding. ADIF Analog Input Format Select Pin, Digital Power Supply H : Full-differential input "L" : Single-ended input CAD1 Chip Address 1 Pin, Connect to GND CAD0 Chip Address 0 Pin, Connect to GND...
Page 18
RX-5030VBK 4.10 LA1838 (IC102): FM AM IF Amp. & Detector, FM MPX decoder • Block Diagram DECODER RF.AMP ANIT-BIRDIE MUTE BUFF STEREO P-DET AM IF PILOT 384KHz COMP S-METER AM/FM S-CLRVE S-METER IF-BUFF TUNING STEREO DRIVE DRIVE FM IF • Pin Function Pin No.
Page 23
RX-5030VBK • Pin function Pin No. Symbol Function OUT4 PORT output 4 OUT3 PORT output 3 OUT2 PORT output 2 OUT1 PORT output 1 AVDD Analog positive power supply terminal SWin Volume input GNDS Ground terminal SRin Volume input SLin...
RX-5030VBK 4.16 TC74HCU04AF-W(IC621): Inverter • Pin layout • Truth table 4.17 TC7SET32FU-X (IC672) : Z-input or gate • Pin layout & Block diagram IN B IN A OUT Y 4.18 TC9164AN (IC402) : Analog switch • Pin layout & Block Diagram...
Page 25
RX-5030VBK 4.19 TC9446F-025 (IC631): Digital signal processor for dolby digital (AC-3) / DTS audio decode • Pin Function Pin No. Symbol Function Reset signal input terminal (L:reset H: normal operation) MIMD Microcomputer interface mode selection input terminal (L:serial H:IC bus)
Page 26
RX-5030VBK 4.20 UPD784215AGC167 (IC671): Digital signal controller • Pin layout • Pin function Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock Connect to GND...
Page 27
RX-5030VBK Pin No. Symbol Function MIDIO IN Interface I/O terminal with microcomputer MIDIO OUT Interface I/O terminal with microcomputer MICK Interface I/O terminal with microcomputer of clock signal MICS Interface I/O terminal with microcomputer of chip select MILP Interface I/O terminal with microcomputer...
Page 28
RX-5030VBK VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.22025) Printed in Japan 200303WPC...
RX-5030VBK SCHEMATIC DIAGRAMS AUDIO/VIDEO CONTROL RECEIVER RX-5030VBK CD-ROM No.SML200303 Area suffix J ----------------------------- U.S.A. C -------------------------- Canada MAS TE R VOLUME R X–6030V AUDIO/VIDE O C ONTR OL R E C E IVE R STANDB Y SUR R OUND DIMME R...
Page 30
RX-5030VBK In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " "...
RX-5030VBK Block diagram Tuner board DVD board Video board MONITOR OUT SUB WOOFER DVD IN TUNER SELECTOR RF101 IC121 IC501 DVD IN L/R VCR REC AM/FM DET MW RF&OSC VCR PLAY IC102 T111 AV COMPU LINK CN451 PLL CLK, PLL DATA, PLL CE,...
Page 38
RX-5030VBK RX-5030VBK Tuner section Tuner signal Parts are safety assurance parts. When replacing those parts make sure to use the specified one. CN411 To SHEET 4/7 B-5 SHEET 7/7...
Page 44
RX-5030VBK VICTOR COMP ANY OF J AP AN, LIMITED AV & MULTIMEDIA COMPANY 10-1,1Chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.22025SCH) 2003/03...
RX-5030VBK PARTS LIST [ RX-5030VBK ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix J ----------------------------- U.S.A. C -------------------------- Canada - Contents - 3- 3 Exploded view of general assembly and parts list (Block No.M1) 3- 5 Electrical parts list (Block No.01~05)
RX-5030VBK Exploded view of general assembly and parts list Block No. Power transformer Speaker terminal board board Power transformer board Power/Fuse board Relay board Main board Power supply board Front board Headphone jack board Power switch board Wire protection board...
Page 48
RX-5030VBK RX-5030VBK Parts list (General assembly) Parts list (General assembly) Block No. M1MM Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10756-001A FRONT PANEL 1 RX-5030VBKJ,C QYSBSGY3008M SPECIAL SCREW...
Page 49
RX-5030VBK Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 419 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V D1356 MTZJ5.1C-T2 ZENER DIODE C 420 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V...
Page 50
RX-5030VBK Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area R1310 QRE141J-103Y C RESISTOR 10K 5% 1/4W R1311 QRE141J-104Y C RESISTOR 100K 5% 1/4W R1312 QRE141J-104Y C RESISTOR 100K 5% 1/4W R1313 QRZ9005-100X F RESISTOR...
Page 51
RX-5030VBK Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area BK701 LV42093-001A FL HOLDER(L) C1435 QCB31HK-822Z C CAPACITOR 8200PF 10% 50V BK702 LV42092-001A FL HOLDER(R) C1436 NCB31CK-223X...
Page 52
RX-5030VBK Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area Q1408 KTA1271/OY/-T TRANSISTOR R 733 NRSA63J-222X MG RESISTOR Q1413 2SC3576-JVC-T TRANSISTOR R 734 NRSA63J-272X MG RESISTOR Q1414...
Page 53
RX-5030VBK Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R1411 QRJ146J-182X UNF C RESISTOR 1.8K 5% 1/4W S 737 QSW0683-001Z PUSH SWITCH TAPE/CDR(5030) R1412 QRZ9005-100X F RESISTOR...
Page 54
RX-5030VBK Electrical parts list (Power amp. board) Block No. 03 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 816 QCS32HJ-330Z C CAPACITOR 33PF 5% 500V...
Page 55
RX-5030VBK Electrical parts list (Power amp. board) Block No. 03 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area D 308 1SS133-T2 SI DIODE Q 319 KTA1268/GL/-T TRANSISTOR D 309 1SS133-T2 SI DIODE Q 320...
Page 56
RX-5030VBK Electrical parts list (Power amp. board) Block No. 03 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 325 QRE141J-361Y C RESISTOR 360 5% 1/4W R 822 QRJ146J-100X UNF C RESISTOR 10 5% 1/4W...
Page 57
RX-5030VBK Electrical parts list (Power amp. board) Block No. 03 Item Parts number Parts name Remarks Area 33 5% 1/2W R 951 QRJ125J-330 UNF.C.RES. R 953 QRL027J-100 UNF.OMF.RES. 10 5% 1/2W R 955 QRE141J-332Y C RESISTOR 3.3K 5% 1/4W 3.3K 5% 1/4W...
Page 58
RX-5030VBK Electrical parts list (DSP board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 601 NCB31HK-102X C CAPACITOR C2514 NCB31HK-122X C CAPACITOR C 602 NCB31HK-102X C CAPACITOR C2515 NCS31HJ-121X C CAPACITOR...
Page 59
RX-5030VBK Electrical parts list (DSP board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area IC683 MM1613DN-X R 689 NRSA63J-0R0X MG RESISTOR IC690 BA15218F-XE R 691 NRSA63J-221X MG RESISTOR IC691 BA15218F-XE R 692...
Page 60
RX-5030VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Parts number Parts name Area R2583 NRSA63J-123X MG RESISTOR R2584 NRSA63J-223X MG RESISTOR R2585 NRSA63J-302X MG RESISTOR R2586 NRSA63J-332X MG RESISTOR R2587 NRSA63J-103X MG RESISTOR R2588 NRSA63J-103X MG RESISTOR...
Page 61
RX-5030VBK Electrical parts list (Tuner board) Block No. 05 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area AT101 QNB0014-001 ANT TERMINAL R 124 NRSA02J-222X MG RESISTOR C/M B BK 1 LV31618-001A SHIELD BKT R 126...
Parts number Parts name Q'ty Area LVT0984-002A INST BOOK 1 ENG LVT0984-001B INST BOOK 1 ENG -------------------- BATTERY EWP503-001C ANT.WIRE QAL0204-001 AM LOOP ANT SAFETY INST. YU20333 BT-52006-2 WARRANTY CARD BT-20071B JVC CENTER LIST BT-51028-2 REGISTER CARD RM-SRX5030J REMOCON 3-19...
Need help?
Do you have a question about the RX-5030VBK and is the answer not in the manual?
Questions and answers