Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Outdoor Order AXIS ODO-AXIS-LP
Summary of Contents for Outdoor Order AXIS ODO-AXIS-LP
- Page 2 ™ OUTDOOR COLLAPSIBLE HEATER DANGER If you smell gas: 1. Shut o ff gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. WARNING Do not store or use gasoline or other flammable vapors and liquids...
-
Page 3: Warnings And Cautions
WARNINGS AND CAUTIONS DANGER CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent or home. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. - Page 4 WARNINGS AND CAUTIONS PLEASE READ THE FOLLOWING SAFETY RULES WARNING: The installation must conform with local codes Installation and repair should be done by or, in the absence of local codes, with the a qualified service person. The heater National Fuel Gas Code, ANSI Z223.1/NFPA 54, should be inspected before use and at NFPA58 Natural Gas and Propane Installation least annually by a qualified service...
- Page 5 WARNINGS AND CAUTIONS PLEASE READ THE FOLLOWING SAFETY RULES WARNING: Within a partial enclosure which includes an The pressure regulator and hose assembly sup- overhead cover and three side walls, as long plied with the appliance must be used, replace- as 30 percent or more of the horizontal ment pressure regulators and hose assemblies periphery of the enclosure is permanently...
- Page 6 WARNINGS AND CAUTIONS PLEASE READ THE FOLLOWING SAFETY RULES Perform a leak test with a soapy solution: 1. T o check gas connections. 2. After connecting a new cylinder. 3. Upon re-assembly after disassembly. This heater is designed to operate with a standard 20 Ib propane cylinder with approved cylinder connection.
-
Page 7: Parts Contents
PARTS CONTENTS PLEASE CHECK THE CONTENTS OF THE PACKAGING FOR MISSING PARTS! Chimney cover Weather resistant heat reflector prevents water from entering the combustion zone and reflects heat down. Safety guard protects the full height of the heat exchanger tube. Heat exchange tube has a large heat-radiating surface. - Page 8 ASSEMBLY INSTRUCTIONS Step 1 Warning:This appliance require s installatio n by a competent person. Proper assembly is the responsibility of the installe r. Step1: To assemble unit open propane tank chamber door. Carefully vertically lift the upper heater unit until entire heat exchange tube is exposed.
- Page 9 ASSEMBLY INSTRUCTIONS Warning:This appliance require s installation by a competent person. Proper assembly is the responsibility of the installer. Step 3: Insert M6x35 thumb screw into hole A, and M6 x12 Step 3 thumb screw into hole B. Lock the screws. CAUTION! Both thumbscrews prevent the upper heater body from unexpectedly collapsing and must be fully inserted.
- Page 10 ASSEMBLY INSTRUCTIONS Warning:This appliance require s installation by a competent person. Proper assembly is the responsibility of the installer. Step 5 Step 5: Place battery in compartment below control panel. Step 6 Step 6: Place the gas cylinder (not included) into the base assembly, and attach the fixing chain.
-
Page 11: Safety Check
SAFETY CHECK WARNING: ONLY AN AUTHORIZED GAS TECHNICIAN SHOULD INSTALL THIS PRODUCT. Check for leaks All connections on the patio heater have been checked for leakage at the factory. In transportation and handling some connections may have loosened. Follow these steps to check the gas hose/regulator/cylinder connections: 1) Make leakage solution by mixing 1 part liquid dish soap and 3 parts wate r. -
Page 12: Operation
OPERATION WARNING: DO NOT ATTEMPT TO OPERATE HEATER UNTIL YOU HAVE READ AND UNDERSTAND ALL PRECAUTIONS. FAILURE TO DO SO CAN RESULT IN SERIOUS PERSONAL INJURY, DEATH, OR PROPERTY DAMAGE. Before turning gas supply ON Your heater was designed and approved for OUTDOOR WARNING FOR YOUR SAFETY: USE ONLY. - Page 13 OPERATION 5. When the pilot is lit keep knob depressed for up to 20 seconds to heat the thermocouple flame sensor, then release it and turn knob to align on the control know with ● on panel. 6. If the pilot does not stay lit, repeat steps 3 and 4. (first ignition generally takes more time, because the gas circuit is full of air).
- Page 14 OPERATION CAUTION: AVOID INHALING FUMES EMITTED FROM THE HE ATER'S FIRST USE. SMOKE AND ODOR FROM THE BURNING OF OILS USED IN MANUFACTURING WILL APPEAR. BOTH SMOKE AND ODOR WILL DISSIPATE AFTER APPROXIMATELY 30 MINUTES. THE HE ATER SHOULD NOT PRODUCE THICK BLACK SMOKE. NOTE: The burner may be noisy when initially turned on.
-
Page 15: Locating Heater For Use
LOCATING HEATER FOR USE CAUTION: WHEN CERTAIN MATERIALS OR ITEMS ARE LEFT, ABOVE, BESIDE OR UNDER THIS HEATER WHILE IN USE, THEY WIL L BE SUBJEC TO RADIANT HEAT AND COULD BE SERIOUSLY DAMAGED. This heater is primarily used for the heating of outdoor patios, decks, spas, pools and open working areas. -
Page 16: Maintenance & Storage
MAINTENANCE/STORAGE CLEANING AND MAINTENANCE : To enjoy years of outstanding performance from your WARNING heater make sure you perform the following maintenance FOR YOUR SAFETY activities on a regular basis: DO NOT touch or move heater for at least 45 minutes after use. Allow Keep exterior surfaces clean. - Page 17 MAINTENANCE/STORAGE Spiders and insects can nest in burner or orifices. This dangerous condition can damage heater and render it unsafe for use. Clean burner holes by using a heavy-duty pipe cleaner. Compressed air may help clear away smaller particles. Carbon deposits may create a fire hazard. Clean heat reflector and heat exchange tube with warm soapy water if any carbon deposits develop.
-
Page 18: Troubleshooting
TROUBLESHOOTING PROBLEM PROBABLE CAUSE SOLUTION Igniter won’t click Dead Battery Replace Batteries Gas valve may be off Turn the gas valve ON Fuel tank empty Refill propane tank Pilot will not light Air in supply system Purge air from lines Loose connection Check all fittings Debris around pilot... -
Page 19: One-Year Limited Warranty
Outdoor Order™ LLC warrants that powder coat finishes will be free from corrosion for a period of two years, and metallic finishes for a period of one year. Small cosmetic blemishes inherent to the casting process and which do not affect the performance of the heater are not covered. - Page 20 THIS PAGE INTENTIONALLY LEFT BLANK...
Need help?
Do you have a question about the AXIS ODO-AXIS-LP and is the answer not in the manual?
Questions and answers