Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Tomcat Rival 20 Disk
Summary of Contents for Tomcat Rival 20 Disk
- Page 1 Operator Manual (EN) Models: 20'' Disk Read the Operators Manual before using the machine. Read the Safety Messages before servicing machine. www.tomcatequip.com 1711 South Street Racine, WI 53404 (USA) (800) 450-9824 | (+001) 262-681-6470 V25.027 © 2025 RPS Corporation TC-STAND-UP-RIVALL-OP-EN...
-
Page 2: Introduction
Intended use The Tomcat Rival Stand On Floor Scrubber is intended for commercial applications with hard floor surfaces such as concrete, VCT, tile and grout, stone, ect. This machine is not designed to clean carpets or sand wooden surfaces. Use only OEM pads/ brushes and commercially available floor cleaning detergents. -
Page 3: Table Of Contents
� � � � � � � � 23 Utility Bracket (Optional) � � � � � � � � � 24 Charge Batteries � � � � � � � � � � � � � � 25 TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 4: Safety
An open flame or spark can cause this gas to not use flammable materials in Tank or pick up. explode. Serious personal injury or property damage could occur. Only charge the Batteries in this machine in a well ventilated area. TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 5: Safety Labels
Do not operate this machine if any parts have been dam- aged or removed. CAUTION To avoid damage to the electronic control components of this machine, Do not store this machine outdoors. Do not pressure wash this machine. TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 6: Operation
18. Charger 19. Solution Sight Tube 20. Recovery Drain Hose 21. Scrub Deck 22. Disinfectant fill port 23. Operator Presence Plate 24. Hip Pad 25. Headlights 26. Charger AC Cord Wrap TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 7: Central Command Overview
22. Key Switch On (I) / Off (O) 23. E-stop 24. Headlights on / off 25. Disinfectant Spray Toggle 26. Z 27. Dual USB 28. Negative Busbar CB 29. Positive Busbar CB 30. Spray Gun Toggle CB TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 8: Membrane Icons
Max set- Armed (White) Armed (White) Middle set- BRUSH BRUSH (I/O) Max set- Idle (grayed out) ACTIVE Active (Animation, 2-3) Active (Animation, 2-3) 1-2 CY- Active (White) NEUTRAL Armed (Animation, 2-5 cycle) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 9: Parking Brake
Do not operate this machine outdoors or on uneven surfaces. WARNING Understand the dynamic braking system before you operate the machine on ramps. Machine may coast. ttery dead TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 10: Steering Controls
OPERATION Steering Controls EMERGENCY STOP TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 11: Battery Setup
If battery acid gets on your face or in your eyes, flush Torque Settings: the area immediately with cold water and seek medical 8-12 ft/lbs (10.8 - 16.3 Newton-meters) attention. TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 12: Charging
OPERATION Charging TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 13: Squeegee Installation
OPERATION Squeegee Installation TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 14: Squeegee Adjustment
OPERATION Squeegee Adjustment TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 15: Forward Drive
OPERATION Forward Drive Wait 5 sec 0 - 3.3mph (0 - 5.3 kph) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 16: Reverse Drive
OPERATION Reverse Drive Wait 5 sec 0 - 3.3mph (0 - 5.3 kph) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 17: Fill Solution Tank
TO AVOID DAMAGE TO THIS MACHINE: • USE APPROVED DETERGENTS ONLY • WATER TEMPERATURE MUST NOT EXCEED 130˚F/ 54˚C • DO NOT USE HIGH-PERCENTAGE BLEACH MIXTURE REFER TO MANUAL OR CALL +011-262-681-3583 TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 18: Scrubbing & Drying
OPERATION Scrubbing & Drying Wait 5 sec 0 - 3.3mph (0 - 5.3 kph) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 19: Drain & Flushing Recovery - Drain Saver
OPERATION Drain & Flushing Recovery - Drain Saver NOTICE Drain “clean” Solution & “dirty” Recovery solution into APPROVED drains TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 20: Headlights (Optional)
OPERATION Headlights (Optional) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 21: Spray Jet Controls (Optional)
OPERATION Spray Jet Controls (Optional) Dedicated Disinfectant Tank 100 PSI 1.5 GPM 45 PSI 3 GPM 10 GAL 38 LITERS TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 22: Filling Disinfectant Tank (Optional)
TO AVOID DAMAGE TO THIS MACHINE: • USE APPROVED DETERGENTS ONLY • WATER TEMPERATURE MUST NOT EXCEED 130˚F/ 54˚C • DO NOT USE HIGH-PERCENTAGE BLEACH MIXTURE REFER TO MANUAL OR CALL +011-262-681-3583 TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 23: Z Er O3 Controls (Optional)
OPERATION O3 Controls (Optional) Wait 5 sec 0 - 3.3mph (0 - 5.3 kph) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 24: Utility Bracket (Optional)
OPERATION Utility Bracket (Optional) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 25: Daily Maintenance
DAILY MAINTENANCE Charge Batteries TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 26: Weekly Maintenance (Or 25 Hrs)
WEEKLY MAINTENANCE (OR 25 HRS) Clean White Filter/Screen TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 27: Check Brush
WEEKLY MAINTENANCE (OR 25 HRS) Check Brush 1/4'' (0.5 cm) TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 28: Check Pad
WEEKLY MAINTENANCE (OR 25 HRS) Check Pad TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 29: Rotate Squeegee Blade
WEEKLY MAINTENANCE (OR 25 HRS) Rotate Squeegee Blade USED X1 USED X4 ROUGH SURFACES 180° SMOOTH SURFACES TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 30: Check Z Er O3 Air Dryer(Optional)
WEEKLY MAINTENANCE (OR 25 HRS) Check Z O3 Air Dryer(Optional) Blue TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 31: Clean Solution Filter
WEEKLY MAINTENANCE (OR 25 HRS) Clean Solution Filter TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 32: Clean Spray Pump Filter
WEEKLY MAINTENANCE (OR 25 HRS) Clean Spray Pump Filter TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 33: Drain Solution Tank
WEEKLY MAINTENANCE (OR 25 HRS) Drain Solution Tank NOTICE Drain “clean” Solution & “dirty” Recovery solution into APPROVED drains TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 34: Monthly Maintenance (Or 100 Hrs)
MONTHLY MAINTENANCE (OR 100 HRS) Adjusting Deck Curtains 5/8” TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 35: Battery Water Level
MONTHLY MAINTENANCE (OR 100 HRS) Battery Water Level 24 Vdc PROBLEM PAIR PROBLEM ___________________________________________________ TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 36: Other Pm Sheet
OTHER PM Sheet Tomcat Rival – PM Sheet CUSTOMER & MACHINE INFORMATION Customer: Email: Address: Phone: City: State: Zip: Contact: Serial #: Model #: Work Order #: Hour Meters Key Switch: Transportation: Scrub Brush: Vacuum: NOTE: Start with Machine filled at least with ½ Tank of water. Turn ON Machine and Test Functionality of Machine CHECK OPERATION &... - Page 37 OTHER PM Sheet Tomcat Rival – PM Sheet CLEAN & INSPECT - OPTIONS IN SPEC REPAIR PROBLEM Battery Terminals Battery Cables Torque Battery Nuts 11ft/lbs OPERATE & CONFIRM IN SPEC REPAIR PROBLEM Fill Solution Tank – ¾ Full Scrub & Dry Fine Tune Squeegee Adjustments NOTE: ENSURE TO CHECK YOUR WET LEAD ACID BATTERIES, LITHIUM/AGM BATTERIES ONLY REQUIRE THE CHECKS ABOVE.
-
Page 38: Battery Chargers
Standard Onboard / AGM / International Chargers: AC Power: 80-270VAC / 50-60Hz DC Power OUT: 24VDC / 27A + 37A Please refer to OEM Charger Operating Instructions for more information. TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts... -
Page 39: Error Codes
The traction maximum current was too high for as well as the I2T parameters if Blocking too much time and the functionalities were everything is correct and restart halted the machine TOMCAT RIVAL V25.027 Pag. Questions? Call 262-681-6470 Use OEM Parts... -
Page 40: Membrane
The battery reached its minimum value of charge Non blocking Recharge the battery and the vacuum was halted to prevent wearing TOMCAT RIVAL V25.027 Questions? Call 262-681-6470 Use OEM Parts Pag. - Page 41 BLANK THIS PAGE WAS INTENTIONALLY LEFT BLANK...
- Page 42 V25.027 TC-RIVAL-OP-EN...
Need help?
Do you have a question about the Rival 20 Disk and is the answer not in the manual?
Questions and answers