Table of Contents
Advertisement
www.tomcatequip.com
1711 South Street
Racine, WI 53404 (USA)
(800) 450-9824 | (+001) 262-681-6470
© 2016 RPS Corporation
Operating Instructions (EN)
Scan With Phone for more Information
MODELS:
34'' DIisk
29'' Cylindrical
33'' Cylindrical
28'' EDGE
32'' EDGE
Read these Instructions before
using the machine.
Read these Safety Messages
before using the machine.
VERSION 16.224
TC-HERO-OP-EN
30'' Disk
Advertisement
Table of Contents
Related Manuals for Tomcat Hero 30'' DISK
Summary of Contents for Tomcat Hero 30'' DISK
- Page 1 Operating Instructions (EN) MODELS: 30'' Disk 34'' DIisk 29'' Cylindrical 33'' Cylindrical 28'' EDGE 32'' EDGE Read these Instructions before using the machine. Read these Safety Messages before using the machine. Scan With Phone for more Information www.tomcatequip.com 1711 South Street Racine, WI 53404 (USA) (800) 450-9824 | (+001) 262-681-6470 VERSION 16.224...
-
Page 2: Introduction
INTRODUCTION This manual is furnished with each new machine. This manual will allow the Operator to get the best performance out of your RPS manufactured Scrubber-Drier, Sweeper, Burnisher, or Orbital Scrubber. Read this manual thoroughly before operating or servicing the machine. This machine will provide excellent performance, but the best results will be obtained at the most minimum costs if: •... -
Page 3: Table Of Contents
TABLE OF CONTENTS Introduction Locate Serial Number Table Of Contents Safety Messages Safety Labels DANGER LCD Screen Operation Controls Battery Setup Remove Squeegee Adjust Squeegee Remove From Battery Charger Transportation - Forward Transportation - Reverse Fill Solution Tank Operation - Scrubbing WASTE WATER DRAINS ONLY! Draining Recovery Tank WASTE WATER DRAINS ONLY! -
Page 4: Safety Messages
SAFETY MESSAGES You will see four kinds of safety reminders in this manual: DANGER WARNING DANGER indicates a hazardous situation which, if not WARNING indicates a potentially hazardous situation avoided, will result in death or serious injury. which, if not avoided, could result in death or serious injury. NOTICE CAUTION NOTICE indicates information considered important, but... - Page 5 WARNING WARNING The Batteries in this machine produce hazardous Dress safely. Do not wear rings or metal wrist watches voltage which can cause electrical shock, burns and/ when servicing this machine, as they can cause an or electrocution. Always disconnect Batteries before electrical short circuit which can cause serious burns.
-
Page 6: Safety Labels
DANGER SAFETY LABELS Read and obey all Safety Labels on your HERO Floor Scrubber. If you have questions about these labels, ask your super- visor. These images indicate where on the HERO Safety Labels are located. If ever the labels become illegible, worn off, or torn, promptly report it to your supervisor and replace it. -
Page 7: Lcd Screen
LCD SCREEN SCREEN #1 (OPERATOR) SCREEN #2 (MAINTENANCE) SCREEN #3 (WITH ERROR CODE) ** USE GREEN MENU SELECTION BUTTON ON CONTROL PANEL TO CHANGE SCREENS ** 1. BATTERY LEVEL INDICATOR - Indicates the energy level remaining in the Batteries (Shown on all menu displays) 2. -
Page 8: Operation Controls
OPERATION CONTROLS - 8 - TC-HERO-OP-EN... -
Page 9: Battery Setup
BATTERY SETUP NOTICE Batteries are a possible environmental hazard. Consult your Battery supplier for safe disposal methods. NOTICE Orientation of Batteries is critical for cables to reach. Ensure proper torque values when installing batteries. (Between 8 - 12 ft/lbs) 24 VOLTS TC-HERO-OP-EN - 9 -... -
Page 10: Remove Squeegee
REMOVE SQUEEGEE - 10 - TC-HERO-OP-EN... -
Page 11: Adjust Squeegee
ADJUST SQUEEGEE TC-HERO-OP-EN - 11 -... -
Page 12: Remove From Battery Charger
REMOVE FROM BATTERY CHARGER Please refer to OEM Charger Operating Instructions for more information. - 12 - TC-HERO-OP-EN... -
Page 13: Transportation - Forward
TRANSPORTATION - FORWARD ½ SPEED TC-HERO-OP-EN - 13 -... -
Page 14: Transportation - Reverse
TRANSPORTATION - REVERSE - 14 - TC-HERO-OP-EN... -
Page 15: Fill Solution Tank
FILL SOLUTION TANK < 30 Gal. ( 113.6 l ) < 30 Gal. ( 113.6 l ) < 130°F / 54°C < 130°F / 54°C DANGER CAUTION EXPLOSION RISK! Flammable materials can cause an TO AVOID DAMAGE TO THIS MACHINE: •... -
Page 16: Operation - Scrubbing
OPERATION - SCRUBBING ½ SPEED - 16 - TC-HERO-OP-EN... -
Page 17: Draining Recovery Tank
WASTE WATER DRAINS ONLY! DRAINING RECOVERY TANK WASTE WATER DRAINS ONLY! TC-HERO-OP-EN - 17 -... -
Page 18: Draining Solution Tank
WASTE WATER DRAINS ONLY! DRAINING SOLUTION TANK WASTE WATER DRAINS ONLY! - 18 - TC-HERO-OP-EN... -
Page 19: Flushing Recovery Tank
FLUSHING RECOVERY TANK TC-HERO-OP-EN - 19 -... -
Page 20: Clean Drain Saver
CLEAN DRAIN SAVER - 20 - TC-HERO-OP-EN... -
Page 21: Clean Cylindrical Hopper
CLEAN CYLINDRICAL HOPPER TC-HERO-OP-EN - 21 -... -
Page 22: Clean Vac Box System
CLEAN VAC BOX SYSTEM - 22 - TC-HERO-OP-EN... -
Page 23: Remove Disk Brushes
REMOVE DISK BRUSHES Rotate after 25 hrs TC-HERO-OP-EN - 23 -... -
Page 24: Remove Cylindrical Brushes
REMOVE CYLINDRICAL BRUSHES Rotate after 25 hrs - 24 - TC-HERO-OP-EN... -
Page 25: Remove Edge Pads
REMOVE EDGE PADS Grip Face Spacer Prep Pad Never place Prep Pad directly on Grip Face! TC-HERO-OP-EN - 25 -... -
Page 26: Charge Batteries
CHARGE BATTERIES Please refer to OEM Charger Operating Instructions for more information. - 26 - TC-HERO-OP-EN... -
Page 27: Battery Chargers
BATTERY CHARGERS Console / WET / Domestic Chargers: AC Power IN: 120VAC / 60Hz DC Power OUT: 24VDC / 30A Please refer to OEM Charger Operating Instructions for more information. Onboard / AGM / International Chargers: AC Power: 80-270VAC / 50-60Hz DC Power OUT: 24VDC / 27A Please refer to OEM Charger Operating Instructions for more information. -
Page 28: Common Wear Parts
COMMON WEAR PARTS ROUND DISK BRUSHES: ROUND DISK PADS: NOTICE NOTICE The ## in Disk Column Denotes Desk Pad Size: 15'' or The ## in Disk Column Denotes Desk Pad Size: 15'' or 17'' 17'' DISK PADS DISK LEVEL COLOR BRUSHES DISK LEVEL... -
Page 29: Edge Grip Face
EDGE GRIP FACE: DESCRIPTION PART# 28'' Velcro Grip Face 300-1039 28'' Mighty Lok Grip Face 300-01037Z 32'' Mighty Lok Grip Face 300-01037Z SQUEEGEE BLADE KITS & COMPLETE SQUEEGEE ASSEMBLIES: SQUEEGEE 30'' DISK 34'' DISK 29'' CYL. 33'' CYL. 28'' EDGE 32'' EDGE SIZE DECKS... - Page 30 BLANK THIS PAGE WAS INTENTIONALLY LEFT BLANK...
- Page 31 BLANK THIS PAGE WAS INTENTIONALLY LEFT BLANK...
- Page 32 1711 South Street Racine, WI 53404 www.tomcatequip.com Tel. US: 800-450-9824 Tel. Int: (+001) 262-681-6470 © RPS Corporation 2016...
Need help?
Do you have a question about the Hero 30'' DISK and is the answer not in the manual?
Questions and answers