BRP ski-doo MXZ 200 2024 Operator's Manual
  1. Manuals
  2. Brands
  3. BRP Manuals
  4. Snowmobiles
  5. ski-doo MXZ 200 2024
  6. Operator's manual
BRP ski-doo MXZ 200 2024 Operator's Manual

BRP ski-doo MXZ 200 2024 Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
MXZ 200
OPERATOR'S
GUIDE
Includes Safety,
Maintenance and
Use Information
Minimum recommended operators age under adult supervision:
– 13 years old
Read this operator's guide thoroughly. It contains important safety information.
Adult supervision is required for the proper understanding of the risks involved
with the usage of these vehicles.
Review and explain the content of this operator's guide with the young operator
and make sure that the young operator understands the proper safe operation
of the vehicle.
Keep this operator's guide handy for reference at all times.
520003082
WARNING
Original
Instructions

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the ski-doo MXZ 200 2024 and is the answer not in the manual?

Questions and answers

Related Manuals for BRP ski-doo MXZ 200 2024

Summary of Contents for BRP ski-doo MXZ 200 2024

  • Page 1 MXZ 200 OPERATOR’S GUIDE Includes Safety, Maintenance and Use Information WARNING Minimum recommended operators age under adult supervision: – 13 years old Read this operator’s guide thoroughly. It contains important safety information. Adult supervision is required for the proper understanding of the risks involved with the usage of these vehicles.

  • Page 2: California Proposition 65 Warning

    In Canada, products are distributed and serviced by Bombardier Recreational Products Inc. (BRP). In the USA, products are distributed and serviced by BRP US Inc. In the European Economic Area (which is comprised of the member states of the European Union plus the United Kingdom, Norway,...

  • Page 3: Personal Injury

    Keep this Operator’s Guide with this vehicle at all times. If you lose your guide, an electronic printable version is available on www.operatorsguides.brp.com or visit your authorized dealer for a hard copy replacement. The safety labels should be considered permanent parts of the vehicle.

  • Page 4: Table Of Contents

    Table of Contents Foreword............. 3 Maintenance ........22-32 Engine Oil...........22 Snowmobile Safety Rules ......4 Battery (Electric Start) ........23 Hangtags..........5-7 Carburetor ..........24 Warning Labels & Information ....8-9 Checking/Adjusting Throttle Lever Declaration of Conformity (EU) ....10 (Tension) ..........25 Declaration of Conformity (UK) ....11 In-Line Fuel Filter ........25 Emissions Regulation 2016/1628 (EU) ...

  • Page 5: Foreword

    This vehicle is not factory equipped to ride on public trails. Additional equipment may be necessary to meet local regulations. Refer to your authorized BRP dealer for more information. However, make sure to comply with the local regulations in regards to other requirements like the minimum age for the operator and license.

  • Page 6: Snowmobile Safety Rules

    Snowmobile Safety Rules...

  • Page 7: Hangtags

    Hangtags This snowmobile comes with hangtags containing important safety information. Anyone who rides the snowmobile should read and understand this information before riding.
  • Page 8 Hangtags This snowmobile comes with hangtags containing important safety information. Anyone who rides the snowmobile should read and understand this information before riding.
  • Page 9 Hangtags This snowmobile comes with hangtags containing important safety information. Anyone who rides the snowmobile should read and understand this information before riding.

  • Page 10: Warning Labels & Information

    Warning Labels & Information This snowmobile comes with labels containing important safety information. Anyone who rides the snowmobile should read and understand this information before riding. The labels should be considered as permanent parts of the snowmobile. If a label comes off or becomes hard to read, contact your authorized dealer for a replacement.
  • Page 11 Warning Labels & Information This snowmobile comes with labels containing important safety information. Anyone who rides the snowmobile should read and understand this information before riding. The labels should be considered as permanent parts of the snowmobile. If a label comes off or becomes hard to read, contact your authorized dealer for a replacement.

  • Page 12: Declaration Of Conformity (Eu)

    Declaration of Conformity (EU)

  • Page 13: Declaration Of Conformity (Uk)

    Declaration of Conformity (UK)

  • Page 14: Emissions Regulation 2016/1628 (Eu)

    Emissions Regulation 2016/1628 (EU) Equipment complies with Emissions Regulation 2016/1628 as shown by a Non-Road Mobile Machinery (NRMM) identification decal on the engine cylinder head cover. ONS-311...

  • Page 15: Reporting Safety Defects

    Reporting Safety Defects In Canada, if you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform Transport Canada in addition to notifying Bombardier Recreational Products Inc. If Transport Canada receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and rem- edy campaign.

  • Page 16: Getting Ready To Safely Operate The Mxz 200

    Getting Ready to Safely Operate the MXZ 200  Second, you must check several things NOTE: This section and Operating every time before the engine is started. the MXZ 200 section must be read and explained to the operator by the A.

  • Page 17: Operating The Mxz 200

    Operating the MXZ 200 You must be a responsible, careful, and C. Never drive the snowmobile faster considerate snowmobile operator at all than a safe speed. Do not drive too times. Your safety is our concern and close to roads, buildings, trees, other must always be yours.

  • Page 18: General Information

    Snowmobile These numbers are required by the dealer Identification to complete warranty claims properly. No warranty will be allowed by BRP if either This snowmobile has two identification the ESN or VIN is removed or mutilated numbers: The Vehicle Identification in any way.

  • Page 19: Recommended Fuel

    U.S. EPA Regulations. engine break-in. After the 10 hour break- Recommended Oil in period, the snowmobile may be taken to an authorized BRP Snowmobile dealer  NOTE: This snowmobile comes for a checkup and oil change. This ser- from the factory with SAE 0W-40 vice is at the discretion and expense of Synthetic oil installed.

  • Page 20: Muffler

    Protect skin and cloth- An optional Heavy Duty Spring Kit is ing when handling a battery. When ser- available from any BRP snowmobile vicing a battery in an enclosed space, dealer. This kit includes stiffer ski shock keep the area well-ventilated.
  • Page 21 7. Stand well away from the dead bat- tery and start the vehicle with the good battery. Allow the vehicle to run for several minutes applying some charge to the dead battery. 8. Start the snowmobile with the dead battery and allow it to run for several minutes before disconnecting the jumper cables.

  • Page 22: Operating Instructions

    Operating Instructions Starting and Stopping 5. Using the recoil starter to manually start the snowmobile, pull the recoil Engine starter handle slowly until resistance ! WARNING is felt; then give a short, quick pull. The engine should start; however, if Never allow anyone to stand in front the engine does not start, repeat this of the snowmobile at any time, espe-...

  • Page 23: Periodic Maintenance/Tune-Up Chart

    Periodic Maintenance/Tune-Up Chart 1st 10 Every 20 Every 50 Every 100 Every 300 Daily Hours Hours Hours Hours Hours (2 Weeks) (1 Month) (3 Months) (6 Months) (12 Months) Valve Clearance Engine Compression Spark Plug Fuel Supply Hose Replace every 3 years Carburetor Float Chamber...

  • Page 24: Maintenance

    Maintenance Engine Oil 4. If step 1-3 was followed and the oil level is not within the operating  NOTE: After the engine break-in range, add the recommended engine period, the engine oil should be oil through the oil stick tube. Install changed every 100 operating hours the oil level stick and close and latch (6 months) and before prolonged...

  • Page 25: Battery (Electric Start)

    If the owner does not feel qualified, take the snowmo- bile to an authorized BRP Snowmo- bile dealer for this service. This ZR-306 service is at the discretion and ! WARNING expense of the snowmobile owner.

  • Page 26: Carburetor

    BRP recommends that any charger connected. After 10-15 min- changes in internal carburetor calibration utes, disconnect the booster battery be made by an authorized BRP Snowmo- leaving the charger connected and bile dealer; however, three external the charger should continue to adjustments can be made on the carbure- charge.

  • Page 27: Throttle Stop Screw

    Rotate the BRP recommends that the in-line fuel filter screw clockwise to increase engine idle be checked once a month. The filter is speed and counterclockwise to decrease located in the fuel hose between the gas engine idle speed.

  • Page 28: Spark Plug

    ! WARNING to clean the area around the spark plug. If you do not, dirt could enter engine when Use only BRP approved DOT 4 brake removing or installing the spark plug. fluid. Never substitute or mix differ- ent types or grades of brake fluid.

  • Page 29: Checking Brake Lever Travel

    The lever should not meet the track drive sprockets. BRP recommends handlebar. that the track tension be checked once a month and adjusted accordingly.

  • Page 30: Track Alignment

    Excessive wear to the idler wheels, drive lugs, and track will occur if the track is improperly aligned. BRP recommends 0753-329 that the track alignment be checked once ...

  • Page 31: Adjusting Shock Springs

     3. After proper track alignment is NOTE: Allow the track to coast to obtained, tighten the idler wheel bolt a stop. DO NOT apply the brake securely. because it could produce an inaccu- rate alignment condition. ! WARNING 3. When the track stops rotating, check the relationship of the idler wheels Always make sure the adjusting and the edge of the track.

  • Page 32: Adjusting Rear Spring Tension

    ! WARNING operated. BRP recommends that the ski alignment be checked once a week. Neglecting to lock the tie rod by tight- ening the jam nuts against the adjust-...

  • Page 33: Ski Wear Bar

    To maintain positive steering characteris- tics, BRP recommends that the ski wear bars be checked once a week and replaced if worn to 1/2 of original diameter. Ski wear bars are available from an authorized 0744-923 BRP Snowmobile dealer.
  • Page 34  NOTE: There should be an “aver- age” operating load on the snowmo- bile when adjusting headlight aim. 2. Measure the distance from the floor to midpoint of the headlight. 3. Using the measurement obtained in step 2, make a horizontal mark on the aiming surface.

  • Page 35: Maintenance Records

    Maintenance Records Send photocopy of maintenance record to BRP if needed. Pre-Delivery Signature/Print: Serial Number: Mileage/km: Hours: Date: Dealer no: Notes: Refer to vehicle Pre-Delivery Bulletin for detailed installation procedures First Inspection Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide.
  • Page 36 Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km:...
  • Page 37 Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km:...
  • Page 38 Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km:...
  • Page 39 Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide. Service Signature/Print: Mileage/km: Hours: Date: Dealer no: Notes: For maintenance schedule refer to Maintenance Information section of this operator’s guide.

  • Page 40: Preparation For Storage

    BRP recommends the the battery posts and cables. Charge following procedure to prepare the snow- the battery.

  • Page 41: Preparation After Storage

    BRP recom- alignment, brake pads, and ski wear mends the following procedure to bars; adjust or replace as necessary.

  • Page 42: Specifications

    Specifications ENGINE AND DRIVE Type Forced Air Cooled/4-Cycle Bore x Stroke 70 x 50 mm (2.76 x 1.97 in.) Valve Arrangement Overhead Displacement 192 cc (11.7 cu in.) Lighting Coil Output 96W @ 3000 RPM Lubrication Forced Splash Cooling System Forced Air Drive Clutch RPM sensing...

  • Page 43: Warranty

    SCOPE OF THE LIMITED WARRANTY Bombardier Recreational Products Inc. (“BRP”) warrants its 2024 Ski-Doo snowmo- biles sold by authorized BRP dealers (as defined below) in the United States of Amer- ica (“USA”) and in Canada from defects in material or workmanship for the period and under the conditions described below.
  • Page 44 BRP will not honor this limited warranty to any private use owner or commercial use owner if one of the preceding conditions has not been met. Such limitations are nec- essary in order to allow BRP to preserve both the safety of its products, and also that of its consumers and the general public.
  • Page 45 If the matter still remains unresolved, contact BRP by filling out the customer contact form at www.brp.com or contact BRP by mail at one of the addresses listed under the CONTACT US section of this guide.
  • Page 46 2. Engine/equipment repair work that an operator performed to correct an unsafe, emergency condition attributable to BRP as long as the operator tries to restore the engine/equipment to its proper configuration as soon as possible. 3. Any action or inaction by the operator unrelated to the warranty claim.
  • Page 47 BRP dealer, you should contact BRP by filling out the customer contact form at www.brp.com or contact BRP by mail at one of the addresses listed under the CONTACT US section of this guide, or...
  • Page 48 BRP. BRP reserves the right to modify this warranty at any time, being understood that such modification will not alter the warranty conditions applicable to the products sold while this warranty is in effect.
  • Page 49 BRP snowmobile dis- tributor/ dealer; • Damage caused by abuse, abnormal use, neglect, racing or operation of the product on surfaces other than snow, or operation of the product in a manner inconsistent with the recommended operation described in the Operator’s Guide;...
  • Page 50 BRP will not honor this limited warranty to any private use owner or commercial use owner if one of the preceding conditions has not been met. Such limitations are nec- essary in order to allow BRP to preserve both the safety of its products, and also that of its consumers and the general public.
  • Page 51 BRP. BRP reserves the right to modify this warranty at any time, being understood that such modification will not alter the warranty conditions applicable to the products sold while this warranty is in effect.
  • Page 52 BRP which in its reasonable judgment are either incompatible with the product or adversely affect its operation, performance and durability, or resulting from repairs done by a person that is not an authorized servicing BRP snowmobile dis- tributor/ dealer; • Damage caused by abuse, abnormal use, neglect, racing or operation of the product on surfaces other than snow, or operation of the product in a manner inconsistent with the recommended operation described in the Operator’s Guide;...
  • Page 53 BRP will not honor this limited warranty to any private use owner or commercial use owner if one of the preceding conditions has not been met. Such limitations are nec- essary in order to allow BRP to preserve both the safety of its products, and also that of its consumers and the general public.
  • Page 54 ADDITIONAL TERMS AND CONDITIONS FOR FRANCE ONLY The following terms and conditions are applicable to products sold in France only: The seller shall deliver goods that are complying with the contract and shall be responsible for defects existing upon delivery. The seller shall also be responsible for defects resulting from packaging, assembling instructions or the installation when it is its responsibility per the contract or if accomplished under its responsibility.

  • Page 55: Customer Information

    Please be assured that we have appropriate security measures in place to ensure that your personal information is protected against loss and unauthorized access. Your personal information that may be collected by BRP, directly from you or from authorized dealers or authorized third parties, includes: •...
  • Page 56 We may receive information about you from diverse sources, including third parties, such as BRP’s authorized dealerships and partners, with whom we offer services or engage in joint-marketing activities. We may also receive information about you from social media platforms such as Facebook and Twitter, when you interact with us on those platforms.

  • Page 57: Contact Us

    Contact Us www.brp.com Europe North America Finland Canada Isoaavantie 7 3200A, rue King Ouest, PL 8040 Suite 300 96101 Rovaniemi Sherbrooke, Québec J1L 1C9 Norway Ingvald Ystgaardsvei 15 United States of America N-7484 Trondheim 10101 Science Drive Salg, marketing, ettermarked...

  • Page 58: Change Of Address/Ownership

    In case of change of ownership, please join a proof that the former owner agreed to the transfer. Notifying BRP, even after the expiration of the limited warranty, is very important as it enables BRP to reach the snowmobile owner if necessary, like when safety recalls are initiated.
  • Page 59 This page is intentionally blank...
  • Page 61 This page is intentionally blank...
  • Page 62 NOTES...
  • Page 63 NOTES...
  • Page 66 ®TM AND THE BRP LOGO ARE TRADEMARKS OF BOMBARDIER RECREATIONAL PRODUCTS INC. OR ITS AFFILIATES. ©2023 BOMBARDIER RECREATIONAL PRODUCTS INC. ALL RIGHTS RESERVED www.brp.com...

Table of Contents