PLEASE READ CAREFULLY: For a complete list of the pre-delivery service checks performed by your dealer, refer to PRE-DELIVERY SERVICE on the upper portion of page 57 and 59 . The copy on page 57 is your record of the service performed, and the copy on page 59 which is to be removed from the manual, is your dealer's.
INTERNATIONAL SYMBOLS As a guide to the operation of your tractor, various international symbols have been utilized on the instruments and controls. The symbols are shown below with an indication of their meaning. � Engine speed Alternator charge Hou rs recorded Power take-off (on) �...
Use an approved R ollbar and Seat Belt for safe operation. 3. D o not by pass the safety start switch. Consu It your Ford Overturning a tractor with out a rollbar can result in death...
Page 7
7. Always tigl,ten the fuel tan k cap securely. roads to provide two wheel braking. I f the original fuel tank cap is lost replace it with a Ford Keep the tractor in the same gear when going downhill as approved cap.
CON TROL S AND INSTR UMEN TS P R OO F-M E T E R F U E L S H UTO F F VALVE The P roof- Meter i s l ocated o n the l eft s i d e of the The fuel shutoff va l ve is shown in F i g u re 6.
CONTROLS AND INSTRUMENTS To a p p l y the Pa r k i ng brake : • Lock the brake ped a l s together w ith the b ra ke pedal l o c k . • Depress b o t h b r a k e peda l s . •...
CONTROLS AND INSTRUMENTS MECHANICAL TRANSMISSION F O U R -W H E E L DR I V E (OPT I ON A L ) AND PTO CONTROLS The sh ift l ever for the fou r-wheel d rive i s l o cated on the top left-hand fro n t of the rear-a x l e center TRANSM I SS I ON G E ARSH I FT L EV E RS housi ng, Figu re 9 .
F O L D B L OC K " o n page 19. BREAK-IN PROCEDURES Your Ford Tractor wi l l p rovide l o ng a n d d ependa ble service if given proper care d u ri n g the 50-h o u r b rea k-in peri od .
gear rati o fo r a part i cu lar o perati o n . O perating the tractor in l ow gear w ith a l ig h t l oad and h i gh eng i ne speed wi l l waste f ue l . 3.
OPERATION other to the a u x i l iary battery positive term i na l . Connect one end of the other ca b l e fi rst t o t h e a u x i l iary battery ( - ) negative ter m i na l , a nd the other end to the tracto r starter ground ter m i na l .
1. Depress the cl u tch ped a l com p l ete l y . When opera t i n g the ra nge se l ecto r l ever, p lace the H ST foot ped a l in N e utral p os i tion or dep ress 2.
Page 18
POW E R TA K E -O F F The power ta ke-off ( P .TO. ) i n your tractor trans fers eng i ne power d i rectly to mou nted or pu l l-type • Pull only lrom drawbar. Pullinf lrom any olher point can cause rear overturn . •...
Check the P . T. O. -d ri ve n e q u i p ment for p ro per of the other. The l oc k shou ld be u sed to obta i n operation by grad ua l l y re l easi n g the cl utch ad d it i o n a l traction fro m t h e op posite whee l...
WA R N I N G: Always l ower the hy Y o u r Ford Tra cto r ca n b e e q u i p ped w i th a s i n g l e drau i c l ift and a l l hydra u l i c eq u i p...
OP E R ATI N G H YDRAU L I C M AN I F O LD N ever a p p l y t h e d ifferential l ock w h e n turn • BLOCK ing . The hydra u l ic M a n i f o l d B l oc k is p rovided to •...
R E AR WH E E L T R E A D SETT I N GS The rear whee l s on the Ford 1 2 1 0 a re adj usta b l e from 3 5 . 4 t o 4 1 .3 i n . (90- 1 0 5 c m ) o n the sta ndard no nadj usta b l e rear whee l s by sw itch i ng the rea r whee l s fro m side to side.
N ever exceed the tota l reco m mended weight for N U T the tractor. Because speci a l eq u i p ment is req u i red to fi l l the ti res, we reco m mend that you consu l t y o u r F o r d Tractor-Equ ipment Tires sh o u l d Dealer.
Page 25
When checking t i re p ressu re, i n spect the tire After seating t h e b eads, adj ust i nflation p ressu re • • for da maged side wa l ls a n d tread cuts. N eg l ect to reco m mend o pe ra t i n g p ressu re .
LU BRICATION AND MAINTENANCE LUBRICATION AND MAINTENANCE CHART - FORD 1 2 1 0 FOUR-WHEEL DRIVE H O U R S H O U RS S E ASON A L SEASONAL 1 00 HOURS HOURS 1 00 1 00 S E A S O N A L S E ASON A L ::.:...
LUBRICATION AND MAINTENANCE FUEL AND LUBRICANTS o r b lends t o red u ce costs and conse rve energy . Today ' s new fuels or b l en ds a re freq uently m o re DI ESE L F U E L volati Ie and there is a need to hand Ie them Type of fuel to use : carefu l l y.
DRAIN PLUG I n sta l l yo u r storage c o n ta i n er a bove t h e g ro u n d 5 0 g a l l o n d r u m s m a k e s u i ta b l e a n d t i l t t h e t a n k so t h e d i s c h a rge o u t l et i s o n t h e c o n t a i n e rs f o r d i e s e l fu e l , p ro...
LUBRIC ATION AND MAIN TENAN CE FUEL AND LUBRICANT SERVICE C ha nge the engine o i l Changing O i l and F i lter: PROCEDURES every 1 00 h o u rs a n d the e n g i n e o i l fi l ter every 200 h o u rs.
Page 33
LUBRICATION AND MAINTENANCE AI R C L EAN E R Replace e l e m e n t if a n y lea ks are fou n d . Check the d i rt l eve l i n the Check i n g D i rt Leve l : 8 .
LU BRICATION AN D MAINTENANCE 4. The tra nsm i ss i o n is f i l led to the correct l eve l when the o i l level is between the mark a n d the l ower end of the d i pst i c k . Do not fi l l bey o n d t h e m a r k o n t h e stick, a s t h e tra nsm is�i o n w i I I be overfi l i ed .
H .S.T. SYSTE M O I L F I LTE RS extrem e l y d i rty con d i t ions, l u b r i cation sh o u ld be m ore often . R efe r to page 28 fo r the type of The H .
Page 36
3. Cl ose the two d ra i n va l ves and s l ow l y refi l l the ( Ford ) antifreeze, or eq u iva l ent, and clear water. system with a 50/50 so l ut i o n of permanent antifreeze and c l ea r water.
Page 37
(spr i ng en d ) wi l l be in the cy l i n der head tractor e n g i n e a n d have them serv i ced by your of the engine. Ford Tractor- E q u i p ment Dea ler.
LU BRIC ATIO N AND MAI NTE NAN C E E N G I N E SPE E D ADJUSTM E N T To rem ove the i njectors : The adj ustments for i d le a n d max i m u m n o-l oad 1 .
Figure 5 0 Alternator Ford Tractor E q u i p ment Dea l er .
Page 43
LUBRICA TION AND MAINTE NANCE F R ON T WH E E L B E A R I N GS 3. Thoro u g h l y clean a l l pa rts in a su ita b l e so lvent (TWO-WH E E L D R I V E ) and a l low to d ry natura l l y .
Page 44
LUBRICATION AND MAINTE NANCE 1 . Ma ke su re that a l l l i n k b o l ts a re tightened p rop 2. Measure and record the d ista n ce between the erly. I f severe wea r i s a pparent, i nsta l l new front of the whee l s at the m a r ks, then push the parts .
LU BRIC ATI ON AN D MA INT ENA NC E B R A K E A DJ USTM E N T Whenever the b ra ke pedal t ravel beco m es exces- s ive, or if the trave l of o ne ped a l is u nequal to t hat of the other, adjustment of each peda l sh o u l d b e made i n t h e fo l l ow i n g man ner : B R A K E PE D A L F R E E -T R A V E L...
LU BRICA TION AND MAIN TENA NC E Chan g i n g O i l : Dra i n the fro n t axle d i fferential case every 300 h o u rs by remov i n g the d ra i n p l ug, F i g u re 63.
LU BRICATION AND MAINTENANCE ( Revised 2-74) G E N E RA L TORQU E SPEC I F I CAT I ON TAB L E USE T H E F O L LOW I N G T O R Q U E S W H E N SPEC I A L T O R Q U E S A R E NOT G I V E N N O T E : These va l ues apply t o fasteners a s received from s u p p l i e r , d ry , o r w h e n l u bricated with normal engine o i l .
SPECIFICA TIONS The s pe c i f i ca t i o n s o n t h e f o l l o w i n g pages are p ro v i d ed f o r y o u r i n f o r m at i o n . F o r ad d i t i o n a l i n f o r m at i o n , see y o u r F o rd Tract o r- E q u i p m e n t D e a l e r .
C OO L I N G SYSTEM - Cont'd. E N G I N E Th u m b F o rce is A p p l ied Type Diese l M idway Between P u l leys. N u m ber of Cy l i nders ..... . 3 Fan Dia meter .
C A N P R O D U C E EXPLOSIVE G A S E S AND C A U S E S E V E R E B U R N S FORD TRACTOR OPERATIONS.TROY.MICH.48084 Sulfuric a c i d electrolyte. Avoid contact with s k i n .
Page 55
SAFET y AND I N STRUC TION DECA LS Hydra u l ic Lift Control Lever P A R T N O . - S BA-390370280. LOCA T I O N - Center of R. H . fender. Flow Control Valve P A R T N O .
Page 56
SAFETY AND INSTRUCTION DECALS D I E SE l E N G I N E O I L I N FO R M A T i O N Service G rade C D S A E 1 0W30, 1 0W40 for year arou nd use SAE l OW i n severe cold below 32"...
PRE-DE LIVE R Y SERVICE C H E C K A N D A DJ U ST AS R E Q U I R E D I N O PE RATIVE S E R V I C E CH ECKS O P E RATIVE S E RV I C E C H E C K S : Tire pressure .
Page 61
PRE-DELIVERY SERVICE C H E C K A N D ADJUST AS R E Q U I R E D INOPERATIVE S E RV I C E C H ECKS OPE RATIVE S E R V I C E CHECKS ·...
Need help?
Do you have a question about the 1210 and is the answer not in the manual?
Questions and answers