RainSoft TC-FLT H Series Owner's Manual

Water filtration system

Hide thumbs

Table Of Contents

Quick Links

Download this manual

TC-FLT H SERIES

WATER FILTRATION SYSTEM

Owner's Manual

(Generation 6 of Controls)

TC-FLT 75 H, TC -FLT 100 H & TC-FLT 150

H models are tested and certified by NSF

International against NSF/ANSI Standard 42

and CSA B483.1 for the reduction of the claims

Part No. 50031

specified on the Performance Data Sheet.

Rev B 09/24

RAINSOFT TC-FLT H SERIES OWNER'S MANUAL

RAINSOFT.COM

Table of Contents

Need help?

Do you have a question about the TC-FLT H Series and is the answer not in the manual?

Questions and answers

Summary of Contents for RainSoft TC-FLT H Series

Page 1 CSA B483.1 for the reduction of the claims and CSA B483.1 for the reduction of the claims Part No. 50031 specified on the Performance Data Sheet. specified on the Performance Data Sheet. Rev B 09/24 RAINSOFT TC-FLT H SERIES OWNER’S MANUAL RAINSOFT.COM...
Page 2: Table Of Contents
Exploded Views and Parts Lists ....12-14 Warranty Information ......15 2 • RAINSOFT TC-FLT H SERIES OWNER’S MANUAL...
Page 3: Operational Specifications
Questions? If you have any questions regarding the installation, operation, or servicing of this system, please contact your local RainSoft Dealer. Your local RainSoft Dealer is familiar with your particular water conditions, and is able to address your concerns promptly and efficiently.
Page 4: Installation Instructions
Important Note: Do not over-tighten the • Remove the cap plug from the tank. valve to the tank. • Lubricate the riser pipe O-ring and tank O-ring with the Dow 111 silicone-based lubricant or equivalent. 4 • RAINSOFT TC-FLT H SERIES OWNER’S MANUAL...
Page 5 (see figure 3). There is an arrow molded into the bypass valve indicating plumbing connections will cause a leak. the direction of flow. • Support all plumbing connected to the yoke. RAINSOFT TC-FLT H SERIES OWNER’S MANUAL • 5...
Page 6 1 /2" DRAI N LI NE Figure 5 • The air gap should be installed between the end of the drain line and the drain to prevent possible back siphoning (see figure 6). 6 • RAINSOFT TC-FLT H SERIES OWNER’S MANUAL...
Page 7: System Start Up
100 gallons has passed through the appliance. Figure 7 4. Flush the Hot Water Heater • Run hot water in the bathtub until the water tests soft. RAINSOFT TC-FLT H SERIES OWNER’S MANUAL • 7...
Page 8: Maintenance Requirements
The filter media will eventually become exhausted or consumed and will need to be replaced. RainSoft replacement filter media (part number 19026) is available through your local RainSoft Dealer. If you are unable to order replacement parts from your local RainSoft Dealer, please contact RainSoft at 1-800-860-7638 for assistance.
Page 9: Tc Display
• The display will return to the home screen. Display will scroll between, the Current Time of Day, Regen at: (Time set). Note this regen later time is set to regen at the normally schedule regen. RAINSOFT TC-FLT H SERIES OWNER’S MANUAL • 9...
Page 10: Installer Mode
Your system is equipped to alert you for alarm situations: When Alarm is active, your TC will display the Error Message and on the Display. Contact your RainSoft Dealer if an Error Message is present. SYSTEM TESTING To test the functions of your TC Product, example the key pad, the flow meter or motor.
Page 11: Troubleshooting Guide
2. Install a pressure regulator. If the troubleshooting guide did not resolve the symptom, please contact your local RainSoft Dealer for service. If you cannot locate your local RainSoft Dealer, please contact RainSoft Customer Service at 1-800-860-7638 or logon to www.rainsoft.com for the name and location of your nearest authorized Dealer.
Page 12: Valve Exploded View
VALVE EXPLODED VIEW 12 • RAINSOFT TC-FLT H SERIES OWNER’S MANUAL...
Page 13: Valve Parts List
3/4² Coupling Adapter Assembly 17994,18267, 18268, 3.0, 5.0, 8.0 Drain Line Flow Control Assembly 18445 Distributor Tube Retainer O-ring 51111, 51113, 51114, 51115 Flow Control Assembly Not Shown 18985 WHITE UPPER DISTRIBUTER BSKT COMP VLV RAINSOFT TC-FLT H SERIES OWNER’S MANUAL • 13...
Page 14 TC HYBRID FRONT HOUSING PCB ASSY 51912 WIRE HARNESS 1 POWER 24 VDC 52462 GEN6 DOOR TC 52491 GEN6 REAR HOUSING WITH INSERTS 51907 SPRING FRONT HOUSING DOOR 12280 7/8 SLEEVE CAP 14 • RAINSOFT TC-FLT H SERIES OWNER’S MANUAL...
Page 15: Limited Lifetime Warranty
RainSoft part(s) furnished, for a nominal charge to cover labor, handling, packing and the increase, if any, in the retail price of the part(s) since the date of purchase. Genuine RainSoft parts must be used. Failure to use genuine RainSoft parts will void the warranty and certifications.
Page 16 Rainsoft, A Division of Aquion | 101 S. Gary Avenue | Roselle, Illinois 60172 | Main: 847.437.9400 | Customer Service : 800.860.7638 | rainsoft.com All indicated Pentair trademarks and logos are property of Pentair. Third party registered and unregistered trademarks and logos are the property of their respective owners.

This manual is also suitable for:

Tc-flt 75 h Tc-flt 100 h Tc-flt 150 h