Trouble Shooting Engine - Carabela MOTOMATIC Owner's Manual

CHART OF DEFECTS
AND THEIR POSS IBLE SOLUTION
ORIGIN
ELECTRICAL CURRENT
IT IS NOTED THAT ... THE DEFECT MAY BE . .
CAUSED BY . .
SOLUTION
THE DEFECT MAY BE ... CAUSED BY . .. SOLUTION
AN OBSTRUCTE D VALVE WASH
CINDER BETWEEN
CLOSED VALVE
OPEN
THE ELECTRODES CLEAN AND CALIBRATE
(SPARK PLUG)
LACK OF FUEL
LOW FUEL LEVEL IN
TANK
FILL
SPARK PLUG
EMPTY TANK
FILL
DEFECTS
-
OBSTRUCTED CARB URETOR FILTER WASH
ENGINE FAILURE AT
HIGH RPM'S
CHANGE
POOR CARBURETION CARBURETOR
CLOSE PASSAGE VALVE, TAKE
OUT THE SPARK PLUG. AND FALSE CONTACT IN THE
THE ENGINE DOES NOT
LEAVING THE PASSAGE VALVE OPEN
WHILE r>ULLING AWAY THE
SPARK PLUG CAP
START. IT STOPS, IT
EXCESS OF FUE L
CABLE. 1 .10VE THE PEDALS AND
COUGHS. TliERE ARE
THE CLUTCH LEVER A FEW
COIL IN POOR
CHANGE
EXPLOSIONS, OR IT
SEC::>NDS. PLACE THE PARTS IN
INTERP.UPTIONS
CONDITION
(FLOODED ENG INE)
DISCHARGES LARGE
WHEN ENGINE IS NOT WORKING
THEIR ORIGINAL POSITION AND TRY
IN THE CURRENT
AMOUNTS OF SMOKE
STARTING THE ENGINE AGAIN. OR TOTAL LACK LOOSE CABLES CHECK AND TIGHTEN
THROUGH THE EXHAUST
OF CURRENT
PIPE.
DISCONNECTED CABLES CHECK AND CONNECT
CABLES IN SHORT
CIRCUIT
CHECK AND ISOLATE
IMPROPER MIXING OF FUEL
CHANGE THE MIXTURE
DIRTY POINTS
CLEAN AND CALIBRATE
EXCESS OFF OIL IN
PUTIING MORE OIL IN THE MIXTURE
CHANGE THE MIXTURE
THAN CALLED FOR
CONTAMINATED FUEL
GASOLINE WITH WATER OR IMPURITIES
WASH THE TANK WITH GASOLINE ~
AND CHANGE. THE MIXTURE.