Table of Contents
Advertisement
Quick Links
Imported From Wisconsin - USA
www.kodiakequip.com
1711 South Street
Racine, WI 53404 (USA)
262-833-4025 | (855) 965-0011
© 2020 RPS Corporation
®
Operator Manual (EN)
20'' & 24'' Orbital
Read the Operators Manual
before using the machine.
Read the Safety Messages
before servicing machine.
Models:
17'' & 20'' Disk
24'' Grout
V20.345
K-K12-OP-EN
Advertisement
Table of Contents
Related Manuals for Kodiak K12
Summary of Contents for Kodiak K12
- Page 1 KODIAK SK-11 ® Imported From Wisconsin - USA Operator Manual (EN) Models: 17’’ & 20’’ Disk 24’’ Grout 20’’ & 24’’ Orbital Read the Operators Manual before using the machine. Read the Safety Messages before servicing machine. www.kodiakequip.com 1711 South Street...
-
Page 2: Introduction
Intended use The Kodiak K12 walk-behind scrubber is intended for commercial applications with hard floor surfaces such as concrete, VCT, tile and grout, stone, ect. This machine is not designed to clean carpets or sand wooden surfaces. Use only OEM pads/brushes and commercially available floor cleaning detergents. -
Page 3: Table Of Contents
Clean Solution Filter ..28 Squeegee Blade Replacement ..29 Drain Solution Tank ..30 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 4: Safety
An open flame or spark can cause this gas not use flammable materials in Tank or pick up. to explode. Serious personal injury or property damage could occur. Only charge the Batteries in this machine in a well ventilated area. KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 5: Safety Labels
Do not operate this machine if any parts have been controller. damaged or removed. CAUTION To avoid damage to the electronic control components of this machine, Do not store this machine outdoors. Do not pressure wash this machine. KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 6: Operation Machine Overview
9. Recovery Tank Clean Out 10. Foam Float Ball & White Filter 11. Solution Fill 12. Tank Latch 13. Charging Port 14. Recovery Drain Hose 15. Solution Sight Tube & Drain Hose 16. Squeegee Lever KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 7: Central Command Overview
19. Deck Switch Up (I) / Down (O) 9. Negative BUSS Circuit Breaker 20. Down Pressure Toggle Switch (Optional) 10. Vac Circuit Breaker 21. Drive Switch 11. Speed Control Knob 22. Reverse Switch 13 14 15 16 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 8: Squeegee Installation
OPERATION Squeegee Installation KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 9: Squeegee Adjustment
OPERATION Squeegee Adjustment (RH) (LH) KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 10: Battery Setup
OPERATION Battery Setup Approved Drains Only Approved Drains Only Machine On Level Ground Machine On Level Ground 12VDC 12VDC Battery 2 Battery 1 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 11: Battery Charger Use
OPERATION Battery Charger Use 10-20 AMP KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 12: Forward Drive
OPERATION Forward Drive + / - 3° MAX KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 13: Reverse Drive
OPERATION Reverse Drive + / - 3° MAX KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 14: Fill Solution Tank
OPERATION Fill Solution Tank KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 15: Scrubbing
OPERATION Scrubbing KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 16: Drying
OPERATION Drying KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 17: Drain Recovery Tank
OPERATION Drain Recovery Tank Approved Drains Only Approved Drains Only KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 18: Flushing Recovery Tank
OPERATION Flushing Recovery Tank Approved Drains Only Approved Drains Only Approved Drains Only Approved Drains Only KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 19: Options Vac Wand
OPTIONS Vac Wand KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 20: Onboard Charger
OPTIONS Onboard Charger KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 21: Brush Pressure
OPTIONS Brush Pressure +/- KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 22: Vac Clog Light
OPTIONS Vac Clog Light KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 23: Charge Batteries
DAILY MAINTENANCE Charge Batteries 10-20 AMP KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 24: Weekly Maintenance (<25 Hrs)
WEEKLY MAINTENANCE (<25 HRS) Clean White Filter/Screen KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 25: Remove Disk Brushes
WEEKLY MAINTENANCE (<25 HRS) Remove Disk Brushes KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 26: Rotate Grout Brush
WEEKLY MAINTENANCE (<25 HRS) Rotate Grout Brush 1/2'' WRENCH < 25-HOURS KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 27: Replace Orbital Pads
WEEKLY MAINTENANCE (<25 HRS) Replace Orbital Pads KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 28: Clean Solution Filter
WEEKLY MAINTENANCE (<25 HRS) Clean Solution Filter KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 29: Squeegee Blade Replacement
WEEKLY MAINTENANCE (<25 HRS) Squeegee Blade Replacement USED X1 USED X4 ROUGH SURFACES 180° SMOOTH SURFACES KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 30: Drain Solution Tank
WEEKLY MAINTENANCE (<25 HRS) Drain Solution Tank Approved Drains Only Approved Drains Only KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 31: Monthly Maintenance (<100 Hrs)
MONTHLY MAINTENANCE (<100 HRS) Deck Shroud Curtain Replacement 7/16'' KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... - Page 32 MONTHLY MAINTENANCE (<100 HRS) Grout Side Wiper Replacement 1/2'' WRENCH 7/16'' KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts...
-
Page 33: Deck Leveling
MONTHLY MAINTENANCE (<100 HRS) Deck Leveling 1/4'' 1/2'' 3/4'' 1/2'' 3/4'' KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 34: Other
1500 Grit HD Non Woven Polishing Pad 3000 Grit HD Non Woven Polishing Pad 6000 Grit Diamond Poly Pad Tile/Grout Renovator Pad EDGE-4069 Dominator HD Strip Pad EDGE-4006 Maroon ECO Prep Pad EDGE-4007 EDGE-2407 Microfiber Pad EDGE-4036 EDGE-2436 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 35: Common Wear Par Ts
Blue #40-433 Retainer ##-422R Moderate Pad Driver #40-423 White ##-422W Light White Spring Clip CYLINDRICAL BRUSHES: BRUSHES MODEL 26'' LEVEL CYLINDRICAL Midi Grit 75-246C Medium Light Grit 75-246PS Moderate Nylon 75-246N Light KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 36: Squeegee Blade Kits
Squeegee blade kits include (1) Rear Blade, (1) Front Squeegee Assemblies (complete) listed above all come Blade, and (2) Caster Wheels with hardware. with Nanorade blades. NOTICE Size is denoted by label on top squeegee. KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 37: Pm Sheet
OTHER PM Sheet K16 Series Scrubber PM Sheet K12 PM SHEET CUSTOMER & MACHINE INFORMATION Customer: Email: Address: Phone: City: State: Zip: Contact: Serial #: Model #: Work Order #: NOTE: Start with Machine filled at least with ½ Tank of water. Turn ON Machine and Test Functionality of Machine CHECK OPERATION &... - Page 38 OTHER PM Sheet K12 PM SHEET K16 Series Scrubber PM Sheet BATTERY HYDROMETER WATER CLARITY WATER LEVEL READING (Circle One) (Circle One) Cell A Clear Dark Overfilled OK Low Cell B Clear Dark Overfilled OK Low Cell C Clear Dark...
-
Page 39: Battery Chargers
Please refer to OEM Charger Operating Instructions for more information. Onboard / AGM / International Chargers: AC Power: 80-270VAC / 50-60Hz DC Power OUT: 24VDC / 25A Please refer to OEM Charger Operating Instructions for more information. KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 40: Schematics
OTHER Schematics BLACK 233 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 41: Schematics Adjusted Down Pressure
OTHER Schematics Adjusted Down Pressure BLACK 233 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... -
Page 42: Decals
OTHER Decals P# 260-7200 P# 260-1523 P# 260-2012 P# 260-020D P# 260-026C P# 260-020O 12VDC P# 260-024O 12VDC P# 260-2021 KODIAK K12 Questions? Call 855-965-0011 Use OEM Parts... - Page 43 BLANK THIS PAGE WAS INTENTIONALLY LEFT BLANK...
- Page 44 ® Imported From Wisconsin - USA www.kodiakequip.com 1711 South Street Racine, WI 53404 (USA) 262-833-4025 | (855) 965-0011 V20.345 © 2020 RPS Corporation K-K12-OP-EN...
Need help?
Do you have a question about the K12 and is the answer not in the manual?
Questions and answers