Installation Information - Bosch CLIMATE 5000 VRF RDCI Series Installation & User Manual

2 | PRECAUTIONS
1. PRECAUTIONS
• Ensure before installing this equipment, you conform to national
regulations.
• Read "PRECAUTIONS" carefully before installation.
• The following precautions include important safety items. Take the time to
observe them to avoid injury.
• After installation, store this manual and the owners manual in a safe place,
for future reference.
• The model names in the manual are using acronyms, for example, SBOX02
is short for SBOX02-1.
• The A-weighted sound pressure level is below 70 dB.
The safety precautions listed here are divided into two categories. Ensure you
read all safety device to prevent injury or damage.
WARNING
Failure to observe can result in serious injury or damage.
CAUTION
Failure to observe a caution may result in injury or damage to the
equipment.
After completing the installation, make sure that the unit operates properly
during the start-up operation. Please instruct the customer on how to operate
the unit and keep it maintained.Also, inform customers that they should store
this installation manual along with the owner's manual for future reference.
WARNING
• Ensure only qualified personnel carry out works on this equipment.
• Only install manufactured products by Bosch. Do not use other products
unless suggested by Bosch.
• When installing in a small room, take steps to ensure if a leak happens, the
room is well ventilated. Check the safety limits required for the room your
are installing in.
• Contact the distributor for specific measures.
• Ensure a qualified electrician is used to install all electrical equipment. Make
sure you comply with national wiring regulations.
• Failure to repair the equipment properly, may result in injury or damage to
the property.
• If the supply cable is damaged, contact a qualified electrician to get this
replaced. Make sure you turn the power off until this has been fixed.
6720862460 (16/04)
•
INSTALLATION MANUAL
For All DC Inverter Heat Recovery A/C
• Do not install the SBOX near strong electromagnetic interference. This may
• When installing the SBOX, choose a suitable location. The SBOX can
• You must install drain pipe for condensate waste.
• Improper drain piping may result in water leakage.
• Be sure to install an earth leakage breaker. Failure to install an earth leakage
• Do not install the SBOX at any place where flammable gas may leak out.
• Make sure you install in a good string location. If there is no solid
• Ensure electrical cabling has been connected correctly in the correct
• Install in a dry location. Exposure to water may result in damage.
• After installation work is complete, pressure test to ensure no leaks are on
2.
2.1.
1. Ensure when installing the SBOX, that sufficient access is available for
maintenance and fault finding.
2. Make sure the SBOX is installed level.
3. Make sure there is sufficient space to connect pipe work, drains and cabling.
4. Ensure the SBOX is installed within the pipe limitations.
• Location in the following places may cause malfunction of the machine.
• This series air-conditioner is comfort type air-conditioner, do not use for
CAUTION
cause communication errors and noise problems.
produce noise from the valves. We recommend installing away from rooms
which require quiet.
breaker may result in electric shocks.
foundation, consult a structural engineer for advice.
terminals. If wire connections are wrong, this will cause damage and
serious injury.
the system. For pressure testing, see outdoor installation manual.

INSTALLATION INFORMATION

SBOX installation location
CAUTION
1. A place where is full of mineral oil like cutting oil etc.
2. A place where salty air surrounding such as near the coast etc.
3. A place where is full of caustic gas such as the sulfide.
4. A place with serious mains voltage fluctuation.
5. A place where high-frequency electromagnetic waves are generated.
6. A place with flammable gas or material.
7. A place with acidic or alkaline gas.
the machine room, precise machine, food, plants, animals, art-work etc.
rooms.
CLIMATE 5000 VRF