Page 1 High Definition Multimedia Interface out (Digital AV output) © Samsung Electronics Co., Ltd. FEB. 2007 This Service Manual is a property of Samsung Electronics Co.,Ltd. Printed in Korea Any unauthorized use of Manual can be punished under applicable international and/or domestic law.
Page 2: Table Of Contents
5. Trouble Shooting 5-1 ~ 5-10 6. Exploded View and Parts List 6-1 ~ 6-8 6-1 Cabinet Assembly (DVD-R150) (6-2) 6-2 Cabinet Assembly (DVD-R155) (6-4) 6-3 Cabinet Assembly (DVD-R156) (6-6) 7. Electrical Parts List 7-1 ~ 7-16 8. Block Diagrams...
Page 3 11-12 ARAPI FLASH MEMORY (Main PCB) (11-14) 11-13 Connector (Main PCB) (11-15) 11-14 SAA7138_AV Decoder (Main PCB) (11-16) 11-15 Function-KEY (Function PCB) (11-17) 11-16 HDMI Trammitter (HDMI PCB (DVD-R155, DVD-R156)) (11-18) 11-17 HDMI CEC (HDMI PCB (DVD-R155, DVD-R156)) (11-19) 12. Operating Instructions 12-1 ~ 12-10...
Page 4 CONTENTS 13. Circuit Operating Descriptions 13-1 ~ 13-26 13-1 Power (13-1) 13-2 DVD Processor (13-4) 13-3 SERVO (DVP Multi Drive) (13-20) 13-4 Tuner (13-25) 13-5 IF (13-26) 14. Reference Information 14-1 ~ 14-12 14-1 Introduction to DVD (14-1) 14-2 DVD-Video Format (14-3) 14-3 About IEEE1394 (14-9)
Page 5: Precautions 1-1
Metal Part an electrical return path to the chassis. Any current measured must not exceed 0.5mA. Reverse the instrument power cord plug in the out- ohmmeter let and repeat the test. See Fig. 1-1. Fig. 1-2 Insulation Resistance Test Samsung Electronics...
Page 6 (5) antenna wiring. Always inspect in all areas tinuously and new instructions are issued whenev- for pinched, out-of-place, or frayed wiring, Do not er appropriate. change spacing between a component and the printed-circuit board. Check the AC power cord for damage. Samsung Electronics...
Page 7: Servicing Precautions
Components identi- fied by shading, by( ) or by ( ) in the circuit dia- gram are important for safety or for the characteris- tics of the unit. Always replace them with the exact replacement components. Samsung Electronics...
Page 8: Esd Precautions
(6) Do not remove a replacement ESD device from its protective package until immediately before your are ready to install it.(Most replacement ESD devices are packaged with leads electrically short- ed together by conductive foam, aluminum foil or comparable conductive materials). Samsung Electronics...
Page 9: Handling The Optical Pick-Up
◆ Be sure to put on a wrist strap grounded to the sheet. ◆ Be sure to lay a conductive sheet made of copper etc. Which is grounded to the table. Samsung Electronics...
Page 10 Precautions MEMO Samsung Electronics...
Page 11: Product Specification 2-1
Audio compression format Dolby digital 2ch/256kbps, MPEG-II XP (about 8 Mbps), SP (about 4 Mbps), LP (about 2 Mbps), Recording Recording Quality EP (about 1,2 Mbps or about 0,8 Mbps) Audio frequency characteristics 20 Hz ~ 20 KHz Samsung Electronics...
Page 12: Chassis Product Specification
Product Specification 2-2 Chassis Product Specification General Model Name DVD-R135 DVD-R155 DVD-R150 CHASSIS INPUT SELECT(DV/AV1/AV2/AV3/PR) DV/AV1/AV2/AV3/PR DV/AV1/AV2/AV3/PR DV/AV1/AV2/AV3/PR Scart Jack-1 A/V Input/Output Rear Scart Jack-2 A/V with RGB Input Rear CVBS Output - RCA Jack Rear Audio Output -RCA Jack...
Page 13: Option Product Specification
Product Specification 2-3 Option Product Specification Description Fig Description Parts No Remark Remote Model Standard of AK59-00061A Control DVD-R155/XEU Model Standard of Batteries for 4301-001035 DVD-R155/XEU Remote Control S.N.A Model Standard of User’s Manual AK68-01273A DVD-R155/XEU Model Standard of AK68-01277A...
Page 14 Product Specification MEMO Samsung Electronics...
Page 15: Software Update 3-1
• Write the downloaded file onto a blank CD-R or CD-RW disc, using the following settings : 1) Download the software update file from the samsung internet site. (www.samsung.com) 2) Write the file to disc using the CD-RW of your computer.
Page 16 Fig. 3-4 Fig. 3-5 6) After removing the update disc, turn off the unit with power button. And there after turn on the unit with power button and then the will be closed. The drive firmware is now completed. Samsung Electronics...
Page 17: Disassembly And Reassembly 4-1
1) Remove 5 Screws Œ, ´, ˇ. 2) Lift up the Top Cabinet in direction of arrow. Œ 3 SCREWS ´ 1 SCREW (3 x 10 B) (3 x 10 B) CABINET ˇ 1 SCREW (3 x 10 B) Fig. 4-1 Top Cabinet Removal Samsung Electronics...
Page 18 Disassembly and Reaasembly 4-1-2 Ass’y Front-Cabinet Removal 1) Release 6 Hooks Œ, ´, ˇ, ¨ and Ass’y Front-Cabinet ˆ. Œ 1 HOOK ¨ 2 HOOKS ¨ 2 HOOKS ´ 1 HOOK ˆ ASS’Y FRONT-CABINET Fig. 4-2 Ass’y Front-Cabinet Removal Samsung Electronics...
Page 19 4-1-3 Ass’y Deck Removal 1) Remove 4 Screws Œ, ´ from the Ass’y Deck ˇ and lift it up. Œ 2 SCREWS ´ 2 SCREWS (3 x 8 W) (3 x 10 Y) ˇ ASS’Y DECK Fig. 4-3 Ass’y Deck Removal Samsung Electronics...
Page 20 1) Remove 2 Screws Œ, from the HDMI PCB and Main PCB ´,ˇ and lift it up. Œ 2 SCREWS (3 x 10 W) ´ HDMI PCB ˇ MAIN PCB Fig. 4-4 HDMI PCB and Main PCB Removal Samsung Electronics...
Page 21 1) Remove 7 Screws Œ, ´, ˇ ,¨from the Jack PCB ˆ and lift it up. ˇ 4 SCREWS ¨ 1 SCREW (3 x 6 W) (3 x 6 W) ˆ JACK PCB ´ 1 SCREW (3 x 8 W) Œ 1 SCREW (3 x 6 W) Fig. 4-5 Jack PCB Removal Samsung Electronics...
Page 22: Pcb Location
Disassembly and Reaasembly 4-2 PCB Location HDMI PCB MAIN PCB JACK PCB Fig. 4-6 PCB Location Samsung Electronics...
Page 23: Trouble Shooting 5-1
PVDL1,PSDZ1, Change short circuited or PVZL1 SHORT and OPEN opened parts Are normal? Is there voltage at PQIZ1[Pin 5]? Change PQIZ1 IC (Over 10V) Operation of PQIZ1 is Replace PQIZ1 Normal? Check feed back PQIZ1[PIN 3] Is 5.8V Samsung Electronics...
Page 24 Receiver can Decode Current Bitstream in customer Audio Setting is PCM. Bit-Steam menu. ChecK Digital Audio data at pin 2 of CON3 Replace Main PCB (MAIN PCB) Replace AVJ5 Check 5V SJACK5 AUDIO DATA (SJACK5) Check the Cable Samsung Electronics...
Page 25 Has about p-p 1V level? Pin 8,10,12 in IC216 and Pin-Jack. Pin 35 In IC216 Check Pin 35 in IC216 Has about p-p 1V signal? of input power(5V). VIC1 of Main PCB Clock (Pin72) VIC1 of Main PCB DATA (Pin75~84) Samsung Electronics...
Page 26 # IF Recorder is under PSO (progressive scan output) MODE, it does not output the CVBS& S-Video signal. Video signal of Check the connection between About P-P1V appears at VIC1 and output jack. Output Jack? CVBS(Color-bar) (Pin17 of IC216) Check the RCA Cable Samsung Electronics...
Page 27 Video signal of Check the connection between About P-P1V appears at IC216 and output jack. Output Jack? # Nomal level of IC216 : Pin21 is 1Vpk-pk pin19 is 0.28V on color burst Check the RCA cable C(Color-bar) (Pin19) Y(Color-bar) (Pin21) Samsung Electronics...
Page 28 Check the connection between About 1V pk-pk appears at IC216 and output jack. Output Jack? # Nomal level : pin25 is 1Vpk-pk pin 23,24 is + 0.35V Check the RCA cable Pr(Color-bar) (IC216 pin24) Pb(Color-bar) (IC216 pin23) Y(Color-bar) (IC216 pin25) Samsung Electronics...
Page 29 (Jack PCB) Check the audio signal pin106 pin110 of VIC1 Replace Main PCB (MAIN PCB) Check digital clock Replace MAIN PCB and data pin102,103,104,105 of VIC1 (MAIN PCB) AUDIO DATA (VIC1 pin105) Check the passive parts arond Jack pin. Samsung Electronics...
Page 30 OK? (5v, 12v) Is the 40pin FFC cable Reinsert FFC cable correctly (between DVD loader & Main Assy) inserted correctly? Is the wavefrom Change the Main board of DIC3 pin26 normal? (MAIN PCB) DIC3-Pin26 Change the deck Samsung Electronics...
Page 31 Check its power line or around elements (Pin 33 : about 9V) Is ther signals Replace Main Assy in pin16 & pin18 of MCN2? Tuner Audio (pin28 & pin29 of MCN2 of Jack Assy) If VIC1 is normal, refer to audio line in abnomal Samsung Electronics...
Page 32 Trouble Shooting MEMO 5-10 Samsung Electronics...
Page 33: Exploded View And Parts List 6-1
6-2 Cabinet Assembly (DVD-R151) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 6-3 Cabinet Assembly (DVD-R155) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
Page 34: Cabinet Assembly (Dvd-R150)
Exploded Views and Parts List 6-1 Cabinet Assembly (DVD-R149 / DVD-R150) W200 W009 W275 P001 FL261 H001 W275 W275 W001 P022 W001 C015 W004 W268 W001 ASSY FRAME (S.N.A) P025 A001 W009 C001 P007 C022 C002 C011 Samsung Electronics...
Page 35 3809-001804 FFC CABLE-FLAT;30V,80C,55mm,13 H001 AK97-01883B ASSY-LOADER;-,DVD-R150,RAM Mul P001 AK92-01244A ASSY PCB-MAIN;DVD-R150,XEU, DV SA DVD-R150/XEN AK92-01246A ASSY PCB-MAIN;DVD-R150,XEO,XEH SA DVD-R150/XEO P007 AK92-01239A ASSY PCB-FUNCTION KEY;DVD-R155 P022 AK92-01248A ASSY PCB-JACK;DVD-R155,XEU, PA P025 AC39-10019A CBF-POWER CORD;KKP-419C,H03VVH W001 6003-000275 SCREW-TAPTITE;BH,+,-,B,M3,L10, W004 6003-000283 SCREW-TAPTITE;BH,+,-,B,M3,L8,Z W009 6003-000276 SCREW-TAPTITE;BH,+,-,B,M3,L10,...
Page 36: Cabinet Assembly (Dvd-R151)
Exploded Views and Parts List 6-2 Cabinet Assembly (DVD-R151) W200 W009 W275 P001 FL261 H001 W275 W275 W001 P022 W001 C015 W004 W268 W001 ASSY FRAME (S.N.A) P025 A001 W009 C001 P007 C022 C002 C011 Samsung Electronics...
Page 37 C022 AK64-02061A DOOR-FRONT;DVD-R160/XEU,ABS 94HB,T2 FL261 3809-001906 FFC CABLE-FLAT;30V,80,65mm,40P,0.5m H001 AK97-01883B ASSY-LOADER;-,DVD-R150,RAM Multi P001 AK92-01244A ASSY PCB-MAIN;DVD-R150,XEU, DV IN, P007 AK92-01239A ASSY PCB-FUNCTION KEY;DVD-R155,FUNC P022 AK92-01248A ASSY PCB-JACK;DVD-R155,XEU, PAL P025 AC39-10019A CBF-POWER CORD;KKP-419C,H03VVH2-F,V W001 6003-000275 SCREW-TAPTITE;BH,+,-,B,M3,L10,ZPC(B W002 6002-000398 SCREW-TAPPING;BH,+,-,2,M3,L6,ZPC(WH W004 6003-000283 SCREW-TAPTITE;BH,+,-,B,M3,L8,ZPC(WH...
Page 38: Cabinet Assembly (Dvd-R155)
Exploded Views and Parts List 6-3 Cabinet Assembly (DVD-R155) W200 W009 W275 P141 P001 FL261 H001 W275 W275 W001 P022 W001 C015 W004 W002 W001 ASSY FRAME (S.N.A) P025 A001 W009 C001 P007 C022 C002 C011 Samsung Electronics...
Page 39 C015 AK64-01957A CABINET-TOP;DVD-R155/XEF,PCM,T0.5 C022 AK64-01938B DOOR-FRONT;DVD-R155,ABS 94HB,T2.5 FL261 3809-001804 FFC CABLE-FLAT;30V,80C,55mm,13P,1 H001 AK97-01883C ASSY-LOADER;-,DVD-R157,Full Multi P001 AK92-01241A ASSY PCB-MAIN;DVD-R155,XEU, DV IN P007 AK92-01239A ASSY PCB-FUNCTION KEY;DVD-R155,FU P022 AK92-01248A ASSY PCB-JACK;DVD-R155,XEU, PAL P025 AC39-10019A CBF-POWER CORD;KKP-419C,H03VVH2-F P141 AK92-01238A ASSY PCB-HDMI;DVD-R155,HDMI-SUB, W001 6003-000275 SCREW-TAPTITE;BH,+,-,B,M3,L10,ZPC...
Page 40: Cabinet Assembly (Dvd-R156)
Exploded Views and Parts List 6-4 Cabinet Assembly (DVD-R156) W200 W009 W275 P141 P001 FL261 H001 W275 W275 W001 P022 W001 C015 W004 W002 W001 ASSY FRAME (S.N.A) P025 A001 W009 C001 P007 C022 C002 C011 Samsung Electronics...
Page 41 AK64-01957A CABINET-TOP;DVD-R155/XEF,PCM,T0.5,4 C022 AK64-01938B DOOR-FRONT;DVD-R155,ABS 94HB,T2.5,H FL261 3809-001906 FFC CABLE-FLAT;30V,80,65mm,40P,0.5m H001 AK97-01883C ASSY-LOADER;-,DVD-R157,Full Multi P001 AK92-01241A ASSY PCB-MAIN;DVD-R155,XEU, DV IN, P007 AK92-01239A ASSY PCB-FUNCTION KEY;DVD-R155,FUNC P022 AK92-01248A ASSY PCB-JACK;DVD-R155,XEU, PAL P025 AC39-12022K CBF-POWER CORD;AT,,GP2,HOUING(2P),2 P141 AK92-01238A ASSY PCB-HDMI;DVD-R155,HDMI-SUB, SI W001 6003-000275 SCREW-TAPTITE;BH,+,-,B,M3,L10,ZPC(B...
Page 42 Exploded Views and Parts List MEMO 6-10 Samsung Electronics...
Page 43: Electrical Parts List 7-1
2007-000171 R-CHIP;0ohm,5%,1/16W,TP,1005 DC59 2203-005061 C-CER,CHIP;100nF,+80-20%,16V,Y 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,100 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,100 2203-005061 C-CER,CHIP;100nF,+80-20%,16V,Y DR30 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,100 DC60 2203-005061 C-CER,CHIP;100nF,+80-20%,16V,Y DC61 2203-005061 C-CER,CHIP;100nF,+80-20%,16V,Y DR32 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,100 DC62 2203-005061 C-CER,CHIP;100nF,+80-20%,16V,Y DR35 2007-000140 R-CHIP;1Kohm,5%,1/16W,TP,1005 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 44 2011-001478 R-NETWORK;51ohm,5%,1/16W,L,CHI DRP2 2011-001474 R-NETWORK;47ohm,5%,1/16W,L,CHI TR35 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm 2007-000140 R-CHIP;1Kohm,5%,1/16W,TP,1005 DRP20 2011-001478 R-NETWORK;51ohm,5%,1/16W,L,CHI 2801-004021 CRYSTAL-SMD;24.576MHz,20ppm,28 DRP21 2011-001478 R-NETWORK;51ohm,5%,1/16W,L,CHI VBD1 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm DRP22 2011-001478 R-NETWORK;51ohm,5%,1/16W,L,CHI 2203-001405 C-CER,CHIP;22nF,+80-20%,25V,Y5 DRP23 2011-001478 R-NETWORK;51ohm,5%,1/16W,L,CHI Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 45 R-CHIP;0ohm,5%,1/10W,TP,1608 VR24 2007-000138 R-CHIP;100ohm,5%,1/16W,TP,1005 SR71 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 VR25 2007-001292 R-CHIP;33ohm,5%,1/16W,TP,1005 VR26 2007-001292 R-CHIP;33ohm,5%,1/16W,TP,1005 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 VR27 2007-001292 R-CHIP;33ohm,5%,1/16W,TP,1005 WJ243 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 VR28 2007-001292 R-CHIP;33ohm,5%,1/16W,TP,1005 WJ244 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 46 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y 2007-000115 R-CHIP;82ohm,5%,1/10W,TP,1608 PPC6 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y AR15 2007-000119 R-CHIP;560ohm,5%,1/10W,TP,1608 SC35 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y AR17 2007-000119 R-CHIP;560ohm,5%,1/10W,TP,1608 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y SR46 2007-000119 R-CHIP;560ohm,5%,1/10W,TP,1608 SR47 2007-000119 R-CHIP;560ohm,5%,1/10W,TP,1608 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y SC16 2203-000236 C-CER,CHIP;0.1nF,5%,50V,C0G,16 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 47 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 AHE10 2401-000408 C-AL;10uF,20%,16V,GP,TP,3.5x5, AHE13 2401-000408 C-AL;10uF,20%,16V,GP,TP,3.5x5, 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 AHE14 2401-000408 C-AL;10uF,20%,16V,GP,TP,3.5x5, 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 AHE15 2401-000408 C-AL;10uF,20%,16V,GP,TP,3.5x5, PPC2 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 AHE31 2401-000408 C-AL;10uF,20%,16V,GP,TP,3.5x5, PPC3 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,1 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 48 DIODE-RECTIFIER;SF26,400V,2A,D 2401-002165 C-AL;100uF,20%,16V,GP,TP,6.3x7 SZD16 0403-000361 DIODE-ZENER;UZ6.2BSB,5.96-6.27 2401-002165 C-AL;100uF,20%,16V,GP,TP,6.3x7 PPCF8 2401-002165 C-AL;100uF,20%,16V,GP,TP,6.3x7 PPZO1 0403-000390 DIODE-ZENER;UZP33B,31.4-34.6V, PVZL1 0403-000713 DIODE-ZENER;MTZJ20B,18.63-17.7 SE10 2401-002165 C-AL;100uF,20%,16V,GP,TP,6.3x7 AZD10 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V SE13 2401-002165 C-AL;100uF,20%,16V,GP,TP,6.3x7 AZD11 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 49 DIODE-ZENER;UDZ9.1B,8.85-9.23V PPLI1 AC27-12001N COIL CHOKE;10UH-15%,RA,K-30,Q8 SZD74 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V SQ11 0504-000128 TR-DIGITAL;-,NPN,200MW,22K/22K SZD76 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V SQ12 0504-000128 TR-DIGITAL;-,NPN,200MW,22K/22K SZD77 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V SZD81 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V SQ13 0504-000156 TR-DIGITAL;KSR2103,PNP,200MW,2 SQ14 0504-000156 TR-DIGITAL;KSR2103,PNP,200MW,2 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 50 2007-000267 R-CHIP;1.8Kohm,5%,1/8W,TP,2012 RC15 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 SR37 2007-000267 R-CHIP;1.8Kohm,5%,1/8W,TP,2012 RC16 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 PPCO1 2401-000385 C-AL;10uF,20%,100V,GP,TP,6.3x1 RC17 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 SL13 AC27-92001M COIL-INDUCTOR;RH3.5X6.5RS,BEAD RC21 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 SL18 AC27-92001M COIL-INDUCTOR;RH3.5X6.5RS,BEAD RC22 2404-001020 C-TA,CHIP;10uF,20%,10V,GP,TP,3 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 51 C-CER,CHIP;10nF,10%,16V,X7R,10 UC24 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 RC73 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 UC25 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 RC74 2203-000489 C-CER,CHIP;2.2nF,10%,50V,X7R,1 RIC2 AK13-00028A IC ASIC;S1L1101X01,-,128,5V,-0 UC26 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 UC27 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1 RR10 2007-000151 R-CHIP;15Kohm,5%,1/16W,TP,1005 UC28 2404-001020 C-TA,CHIP;10uF,20%,10V,GP,TP,3 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 52 2007-000171 R-CHIP;0ohm,5%,1/16W,TP,1005 UR16 2007-000170 R-CHIP;1Mohm,5%,1/16W,TP,1005 UR94 2011-001432 R-NET;82ohm,5%,1/16W,L,CHIP,8P UR17 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,100 UR95 2011-001432 R-NET;82ohm,5%,1/16W,L,CHIP,8P UR19 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm UR96 2011-001432 R-NET;82ohm,5%,1/16W,L,CHIP,8P 2011-001261 R-NET;33ohm,5%,1/16W,L,CHIP,8P UR20 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 UR97 2011-001432 R-NET;82ohm,5%,1/16W,L,CHIP,8P Samsung Electronics 7-10 This Document can not be used without Samsung’s authorization...
Page 53 VR45 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm AK61-00480A BLADE-ACT;SOH-DR3,E5006J,L,IVO VR46 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm VR47 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm AK97-01860A ASSY-FPCB;-,SOH-DR4,DVD-RECORD AC99-40335M ASSY-FPCB,c;-,SOH-DR4,DVD-RECO VR48 3301-001419 BEAD-SMD;220ohm,1608,TP,133ohm 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 2007-000076 R-CHIP;330ohm,5%,1/10W,TP,1608 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 2007-000113 R-CHIP;33ohm,5%,1/10W,TP,1608 7-11 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 54 RT02 2007-000071 R-CHIP;22ohm,5%,1/10W,TP,1608 RT01 2007-000882 R-CHIP;4.7ohm,5%,1/10W,TP,1608 CT02 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y CT04 2203-000189 C-CER,CHIP;100nF,+80-20%,25V,Y CT03 2203-000440 C-CER,CHIP;1nF,10%,50V,X7R,160 CT01 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 XT01 2802-001094 RESONATOR-CERAMIC;4.0MHz,0.5%, C- A/V AC39-42001R CABLE-A/V;PVC,-,-,3P,-,-,- CABLE AC39-00017A CABLE-ETC-RF(PAL);-,MALE/FEMAL Samsung Electronics 7-12 This Document can not be used without Samsung’s authorization...
Page 55: Block Diagrams
8-4 SAA7138 Block Diagram - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 56: All Block Diagram
Block Diagrams 8-1 All Block Diagram Video Audio This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 57: Internal Block Diagram
Block Diagrams 8-2 Internal Block Diagram Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 58: S5L3210 Block Diagram
Block Diagrams 8-3 S5L3210 Block Diagram This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 59: Saa7138 Block Diagram
Block Diagrams 8-4 SAA7138 Block Diagram Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 60 Block Diagrams MEMO Samsung Electronics...
Page 61: Wiring Diagram
9. Wiring Diagram Samsung Electronics...
Page 62 Wiring Diagram MEMO Samsung Electronics...
Page 63 10-3 Key PCB - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 10-7 10-4 HDMI PCB (DVD-R155, DVD-R156) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 10-8...
Page 64: Pcb Diagrams
RIC2 RIC3 RIC1 DIC2 DIC1 DIC2 Œ Tuner Audio (pin28 & pin29 of MCN2 of Jack Assy) VIC1 RIC1 DIC7 ´ VIC1 of Main PCB Clock (Pin72) RIC3 RIC2 ´ ˇ Œ ˇ AUDIO DATA (VIC1 pin105) 10-2 Samsung Electronics...
Page 65 PCB Diagrams CONDUCTOR SIDE DIC3 DIC5 TIC1 DIC6 DIC5 DIC6 DIC3 TIC1 Samsung Electronics 10-3...
Page 66: Jack Pcb
PCB Diagrams 10-2 Jack PCB COMPONENT SIDE 10-4 Samsung Electronics...
Page 67 PCB Diagrams CONDUCTOR SIDE IC216 IC217 FIC1 AIC1 Samsung Electronics 10-5...
Page 68 Œ CVBS(Color-bar) (Pin17 of IC216) ´ Y(Color-bar) (Pin21) IC216 IC217 ˇ C(Color-bar) (Pin19) ¨ Y(Color-bar) (IC216 pin25) FIC1 ˆ Pb(Color-bar) (IC216 pin23) Ø Pr(Color-bar) (IC216 pin24) AIC1 ∏ Tuner Audio (pin28 & pin29 of MCN2 of Jack Assy) 10-6 Samsung Electronics...
Page 69: Key Pcb
PCB Diagrams 10-3 Key PCB COMPONENT SIDE CONDUCTOR SIDE Samsung Electronics 10-7...
Page 70: Hdmi Pcb (Dvd-R155, Dvd-R156)
PCB Diagrams 10-4 HDMI PCB (DVD-R155, DVD-R156) COMPONENT SIDE CONDUCTOR SIDE HIC6 HIC5 HIC1 HIC4 HIC4 HIC5 HIC6 HIC1 10-8 Samsung Electronics...
Page 71: Schematic Diagrams 11-1
11-16 HDMI Trammitter (HDMI PCB (DVD-R155, DVD-R156)) - - - - - - - - - - - - - - 11-19 11-17 HDMI CEC (HDMI PCB (DVD-R155, DVD-R156)) - - - - - - - - - - - - - - - - - - - Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 72: Block Identification Of Main Pcb
◆ Block Identification of Main PCB ATAPI / AV / I/O Block Interface Decoder Block Block MPEG Codec Power System Block Control - Jack PCB Memory Interface - Main PCB 11-2 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 73 Schematic Diagrams 11-1 S.M.P.S. (Jack PCB) Samsung Electronics This Document can not be used without Samsung’s authorization. 11-3...
Page 74 Schematic Diagrams 11-2 System Control (Jack PCB) 11-4 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 75: Connector (Jcak Pcb)
Œ Tuner Audio (pin28 & pin29 of MCN2 of Jack Assy) Œ ◆ These are the waveforms of DVD-R155 / DVD-R150 / DVD-R156. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 76: Front Av (Jack Pcb)
Schematic Diagrams 11-4 Front AV (Jack PCB) Audio in Video in 11-6 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 77: Scart I/O (Jack Pcb)
Schematic Diagrams 11-5 SCART I/O (Jack PCB) Audio in Audio out Video in Video out Samsung Electronics This Document can not be used without Samsung’s authorization. 11-7...
Page 78: Av I/O Select (Jack Pcb)
ˇ Œ ¨ Y(Color-bar) (IC216 pin25) ˆ Pb(Color-bar) (IC216 pin23) ◆ These are the waveforms of DVD-R155 / DVD-R150 / DVD-R156. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Ø Pr(Color-bar) (IC216 pin24) 11-8 This Document can not be used without Samsung’s authorization.
Page 79: Ntsc Tuner (Jack Pcb)
Schematic Diagrams 11-7 NTSC Tuner (Jack PCB) Audio out Video out Samsung Electronics This Document can not be used without Samsung’s authorization. 11-9...
Page 80: Av Out (Jack Pcb)
Digital Audio out ´ ˇ ¨ Œ ◆ These are the waveforms of DVD-R155 / DVD-R150 / DVD-R156. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Œ AUDIO DATA (SJACK5) ´ Y(Color-bar) (IC216 pin25) ˇ Pb(Color-bar) (IC216 pin23) ¨...
Page 81: Mpeg Codec (Main Pcb)
Schematic Diagrams 11-9 MPEG CODEC (Main PCB) Analog Audio in Digital Audio out Digital Video in Analog Video out Digital Video out Samsung Electronics This Document can not be used without Samsung’s authorization. 11-11...
Page 82: Ddr_Sdram (Main Pcb)
Schematic Diagrams 11-10 DDR_SDRAM (Main PCB) 11-12 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 83: Ieee1394_Phy (Main Pcb)
Schematic Diagrams 11-11 IEEE1394_PHY (Main PCB) Samsung Electronics This Document can not be used without Samsung’s authorization. 11-13...
Page 84: Arapi Flash Memory (Main Pcb)
Schematic Diagrams 11-12 ARAPI FLASH MEMORY (Main PCB) 11-14 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 85: Connector (Main Pcb)
Œ Œ Tuner Audio (pin28 & pin29 of MCN2 of Jack Assy) ◆ These are the waveforms of DVD-R155 / DVD-R150 / DVD-R156. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 86: Saa7138_Av Decoder (Main Pcb)
´ VIC1 of Main PCB DATA (Pin75~84) ´ ˇ AUDIO DATA (VIC1 pin105) Œ ◆ These are the waveforms of DVD-R155 / DVD-R150 / DVD-R156. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. 11-16 This Document can not be used without Samsung’s authorization.
Page 87: Function-Key (Function Pcb)
Schematic Diagrams 11-15 Function-KEY (Function PCB) Samsung Electronics This Document can not be used without Samsung’s authorization. 11-17...
Page 88: Hdmi Trammitter (Hdmi Pcb (Dvd-R155, Dvd-R156))
Schematic Diagrams 11-16 HDMI Trammitter (HDMI PCB (DVD-R155, DVD-R156)) 11-18 This Document can not be used without Samsung’s authorization. Samsung Electronics...
Page 89: Hdmi Cec (Hdmi Pcb (Dvd-R155, Dvd-R156))
Schematic Diagrams 11-17 HDMI CEC (HDMI PCB (DVD-R155, DVD-R156)) Samsung Electronics This Document can not be used without Samsung’s authorization. 11-19...
Page 90 Schematic Diagrams MEMO 11-20 Samsung Electronics...
Page 91: Operating Instructions
12. Operating Instructions Samsung Electronics 12-1...
Page 92 Operating Instructions 12-2 Samsung Electronics...
Page 93 Operating Instructions Samsung Electronics 12-3...
Page 94 Operating Instructions 12-4 Samsung Electronics...
Page 95 Operating Instructions Samsung Electronics 12-5...
Page 96 Operating Instructions 12-6 Samsung Electronics...
Page 97 Operating Instructions Samsung Electronics 12-7...
Page 98 Operating Instructions 12-8 Samsung Electronics...
Page 99 Operating Instructions Samsung Electronics 12-9...
Page 100 Operating Instructions MEMO 12-10 Samsung Electronics...
Page 101 3) PALT4, PALT2, PACT1, PACT2 : Noise removal at power input/output. 4) PLRU1 : Rush current limit resistance at the momemt of power cord insertion. : Without PLRU1, the bridge diode might be damaged as the rush current increases. Samsung Electronics 13-1...
Page 102 # Use the output of transformer as PQIZ1 Vcc : The loads are different before and after PQIZ1 driving. (Vcc of PQIZ1 decreases below OFF voltage , using only the resistance dut to lode increase after PQIZ1 driving.) (d) Feedback Control Circuit Fig. 13-3 13-2 Samsung Electronics...
Page 103 Circuit Operating Descriptions 1) F/B terminal of PQIZ1 determines output duty cyle. 2) C-E (Collector-Emitter) of PQIZ1 and F/B potential of PQIZ1 are same. 13-1-3 Internal Block Diagram (Internal Block Diagram of S.M.P.S. Circuit) Fig. 13-4 Samsung Electronics 13-3...
Page 104: Circuit Operating Descriptions 13-1
Water mark detection and CPPM for DVD-Audio Samplerate MPEG-1,MPEG-2,DolbyDigital,DTS,and DVD-Audi oup to 192kHz SYSTEM Peripheral interface TwoUARTs,SPI,IR,I2C,Timer,GPIO Memory Up to 512M-byte DDR-SDRAM (16-bit Data Bus) PHYSICAL Operating voltage 3.3VI/O,2.5VSSTL,1.2Vcore Clock frequencies Input Frequency=27MHz,Operating=up to 150MHz Packaging 256-eLQFP 13-4 Samsung Electronics...
Page 105 Circuit Operating Descriptions ´ ´ Pin Layout of S5L32210 (256pin eLQFP ) Fig. 13-5 Samsung Electronics 13-5...
Page 106 Circuit Operating Descriptions ˇ ˇ Internal Block DiagramofS5L3210 Fig. 13-6 13-6 Samsung Electronics...
Page 107 Block Diagram arround S5L3210 ¨ ¨ DVD-R155 MPEG CODEC and Memory Interface is located in MAIN PCB Assembly. There are 4EA of memory device for several useage as below a. 2Mbyte Flashe Memory for Software Store b. 32MByte DDR-SDRAM as buffer Memory Device for Entire operating c.
Page 108 Œ Overview DVD-R155 Euro/Asia/Middle East Model use SAA7138 AV Decoder made by PHLIPS as a solution of several function which is done by individual ICs in SAMSUNG 3rd Generation model. This IC Located in top-side of MAIN Board, arround S5L3210 AV CODEC.
Page 109 - Two stereo base-band outputs, which can connect directly to the analog inputs (loop-through). 4) TV sound decoder and processor - Analog TV sound decoder for - NICAM - BTSC together with SAP; improved channel separation by Philips Noise Reduction (PNR) or optionally by dbx - A2 (stereo and dual-language) Samsung Electronics 13-9...
Page 110 - Audio sampling rates of 32.0 kHz, 44.1 kHz, 48 kHz or 96 kHz - I2S output - Associated digital sound of digital video output - Audio sampling rates of 32.0 kHz, 44.1 kHz or 48 kHz. 13-10 Samsung Electronics...
Page 111 Circuit Operating Descriptions Internal Block DiagramofS5L3210 Fig. 13-8 Samsung Electronics 13-11...
Page 112 Though SAA7138 have multiplexer function for several input source, but muliplexer of switching operation is done by other IC- HA118827 AV multiplexer. And asloAudio ADC function of SAA7138 is not used. but use built-in Audio ADC in S5L3210 MPEG CODEC. Fig. 13-9 13-12 Samsung Electronics...
Page 113 Only one of these CVBS signals is selected by HA118827(IC216) A/V Multiplexer and inputted to SAA7138 Video Decoder in MAIN Board. 2. Audio Input selection There are 4 pair of Analog Baseband Audio Input source for DVD-R155 Euro Model. - SCART1(AV1) - SCART2(AV2) - AV3 RCA Input(in Front Pannel), - Analog Tuner.
Page 114 656 Digital Video Audio ouput as the result of input selection is inputted built-in Audio ADC in S5L3210 7. ETC RGB signal form SCART2(AV2) of DVD-R155 Euro model and S-Video signal from S-Video of DVD-R155 ASAI Model inputted directly to SAA7138 Video Decoder regardless selection of HA118827 A/V Multiplexer becase they no need to select.(There are only 1 RGB Input in Euro model, and also only one S-Video Input for...
Page 115 Circuit Operating Descriptions ´ ´ Internal Bloack Diagram of HA118827 A/V Multiplexer Fig. 13-10 Samsung Electronics 13-15...
Page 116 Circuit Operating Descriptions 13-2-4 System contol by MC80F0208 Micro Controller DVD-R155/R150 Euro and ASIA Model use New Microcontroller of ABOV. When compared to uPD78F4928 Micro-controller which is used in previous model(DVD-R130), MC80F0208 is smaller both in size and function. Œ...
Page 117 - 4.5V ~ 5.5V (@ 1 ~ 12MHz) - Operating Frequency Range - 1 ~ 12MHz - Package : 44MQFP, 42SDIP type - Available Pb free package - Operating Temperature : -40°C ~ 85°C - Oscillator Type - Crystal, Ceramic resonator, External clock Samsung Electronics 13-17...
Page 118 Circuit Operating Descriptions ˇ ˇ Internal Block Diagram of MC80F0208Q Fig. 13-12 13-18 Samsung Electronics...
Page 119 DVD-R155 use New LED Display Driver IC (AIC1) to reduce material cost.. The name of New IC is "IK2102" and mad by IK Semicon. And to support back-up option for ASIA Model and CIS model, DVD-R155 use new IC for Real-Time Clock reading.
Page 120: Servo (Dvp Multi Drive)
A chip is RF processor. This module performs RF signal processing which includes RFIP, RFIN, AGC, RF equal izer. This processor is able to detect tracking error, focus error and various signals such as CE, PE, SBAD, DEFECT, BCA, MIRROR, Wobble, TZC, RC, and RECD. 3) S5L1484X TOP Block Diagram Fig. 13-14 13-20 Samsung Electronics...
Page 121 ¨ PR(a,b,b,a) Type Radix-16 Viterbi Detector (Flexible Type) ˆ Digital Frequency & Phase Error Detection with DAC PLL Controller Ø Blank/Defect Detect function ∏ Jitter Monitor(Digital Output) ” Raw Sync & Common Sync Monitoring Output ’ DVD RW/R, RAM Wobble PLL Samsung Electronics 13-21...
Page 122 ˘ 0.18 µm CMOS Technology ¿ VDD = 3.3V ± 10 % (Internal 1.8 ± 0.15 V) ¸ 256-pin ˛ Applications : CD Player, CD-ROM / DVD-ROM / DVD-RAM / DVD-R / DVD-RW / DVD+R / DVD+RW Drive/Player/Recorder 13-22 Samsung Electronics...
Page 123 ” 4-input fast interrupt (FIQ) controller (4 sources from IRQ) ’ Low-power clock modes (IDLE and SLEEP modes) support ˝ Supports 33.8688MHz, 67.7376MHz (selectable by the MCU). Ô peripheral registers can be accessed in a single cycle.  ETM7 embedded Samsung Electronics 13-23...
Page 124 ¨ Accumulation & Count for Jitter Value(from PRML) ˆ BIST Memory 12) Hardware Configuration(PC/Ex-Micom I/F) Features Œ PC Parallel Port I/F Support ´ Direct/Indirect Multiplex Micom Support ˇ Non-Multiplex Micom Support ¨ AV I/F Support ˆ JTAG I/F Support Ø ETM I/F Support 13-24 Samsung Electronics...
Page 125: Tuner
6) PLL IC The PLL IC plays a role selection of Tuner channel. It was built-in three wire PLL IC, charge pump and band driver. The minimum of step frequency is 31.25KHz. Fig. 13-15 Samsung Electronics 13-25...
Page 126 The 90 degree delayed phase signal is input at the same time to AFT and, the results come out. 5) IF AMP IF signal , which is selected in Saw filter, is amplified in IF amp frequency enough to be detected. The IF amp has parallel inputs & outputs structure. Fig. 13-16 13-26 Samsung Electronics...
Page 127: Reference Information 14-1
Reflective layer Semi-reflective layer Polycarbonate Polycarbonate Dual Side Dual Layer : 17GByte Dual Side Single Layer : 9.5GByte Polycarbonate Polycarbonate Semi-reflective layer Reflective layer Reflective layer Bonding layer Bonding layer Reflective layer Reflective layer Semi-reflective layer Polycarbonate Polycarbonate Samsung Electronics 14-1...
Page 128 This can be virtually used as hard-disk, with a random DVD-RAM (more than 100,000 times) read-write access Rewritable Similar to DVD-RAM except than its technology features DVD-RW (About 1,000 times) a separated read-write access more like phonograph than a hard disk. 14-2 Samsung Electronics...
Page 129: Dvd-Video Format
Recording type Dolby Digital Linear PCM MPEG-1 Layer 2 AUDIO Transmission rate 448Kbps/stream 6.144Mbps/stream 224Kbps 1 Analog CH. Channel 5.1CH/stream 8CH/stream 1 Stream of Dolby Digital 2 Digital CH. (16Bit/44.1KHz) Sampling frequency 48KHz 16, 20, 24Bit/48, 96KHz 16Bit/44.1KHz Samsung Electronics 14-3...
Page 130 Data loss and enables Time efficient compression. Loss area • MPEG-1 (Fixed compression : Max. 1/140) Amount of data - Frame unit compression. - Compresses all data using the same ratio. Video-CD - Fast movements are jagged, and unnatural Time 14-4 Samsung Electronics...
Page 131 - Various Digital Recordings are possible as shown in the table to the right. Sampling Frequency Bit Rate 16bit 48KHz 20bit 24bit 16bit 96KHz 20bit 24bit • Dolby Digital compatible Audio Mode Channel Format Audio Coding Front Surround (Rear) Remark Mode Mono Stereo Mono Mono Surround Samsung Electronics 14-5...
Page 132 • Up to 9 angles of view may be stored, enabling the viewer to select a specific viewpoint at a given time. --> Especially, for the Music Video and Sports Title, this provides a more lively image of the scene. Note ; This function is disc-dependent, may not work on all DVDs. 14-6 Samsung Electronics...
Page 133 - Region 6 : China. - Region 0 : Worldwide (All Code) ˆ Œ ´ Œ Ø ´ Œ ˇ ˆ ¨ ´ ¨ • Adoptation of the Macrovision System disables the copying on to other media. Samsung Electronics 14-7...
Page 134 - Different Authoring Process are used accoring to the Software developers, and this may affect the DVD image quality. • Authoring Process bit stream Video/Audio MPEG-2 Master Encoding Disc Production bit stream Video/Audio Surround Audio AC-3/MPEG Audio Cutting Subtitle Master Encoding Master Multiplexing bit stream Subtitle Subtitle Master Encoding Authoring Process 14-8 Samsung Electronics...
Page 135: About Ieee1394
However, the specification is open and line scan suppor t could be achieved via Format 7. As for USB 2, it is still in its infancy in machine vision and we are not aware of any kind of machine vision support. Samsung Electronics 14-9...
Page 136 Price 1394 Solution Price with multiple frame grabbers Four Cameras 18,000 Four 1394 Cameras 18,000 Four Frame Grabbers 4,400 One 1394 Interface Card Four Cable One 1394 Hub Four power Supplies Five Cables Total $23,120 Total $18,370 14-10 Samsung Electronics...
Page 137 - Easy and inexpens ive cabl ing , - The system meet s the expect ations for spee d and accuracy, - The range of inspect able parts is much bigger than with the old syste m. Samsung Electronics 14-11...
Page 138 Reference Information MEMO 14-12 Samsung Electronics...

This manual is also suitable for:

Dvd-r150 Dvd-r156

Samsung DVD-R155 Service Manual

Quick Links

Related Manuals for Samsung DVD-R155

Summary of Contents for Samsung DVD-R155

This manual is also suitable for:

Table of Contents