Related Manuals for Rapid Spray FIRE MARSHAL
Summary of Contents for Rapid Spray FIRE MARSHAL
- Page 1 FIRE MARSHAL OPERATORS HANDBOOK FIRE MARSHAL FIRE MARSHAL PLUS 250L / 325L Fire Fighting...
-
Page 2: Table Of Contents
Rapid Spray Fire Marshal Operators Handbook CONTENTS Introduction & Models Warnings Product Risk Assessment Troubleshooting Operation Before Beginning Operation Operation Honda GX35 Engine Kawashima Fire Pump Cleaning & Maintenance Fire Marshal Breakdowns & Spare Parts Marshal Tank Poly Fire Fighting Hose Reel... - Page 3 *WARNING: Always obey vehicle and UTV/ATV manufacturer instructions regarding loading and operation. Please check weight restrictions. Serious death or injury can occur from improper usage. Rapid Spray accepts no liability for the unsafe operation of this unit. AYH013...
-
Page 4: Warnings
Rapid Spray Fire Marshal Operators Handbook WARNINGS Read all warnings below and obey any instruction stickers or warnings on the unit. Failure to do so may result in serious bodily harm or death. When mounting to any vehicle, ensure that you have read the Vehicle Owner’s Manual and that you comply with all the weight restrictions as specified by the vehicle manufacturer, as overloading can cause injury or death. -
Page 5: Product Risk Assessment
Rapid Spray Fire Marshal Operators Handbook PRODUCT RISK ASSESSMENT TASK HAZARDS RISK CONTROL MEASURES Partially fill the tank Manual handling; Medium Concentrate on tasks, follow safe manual with water, start the slips, trips or falls; handling techniques: don’t lift on your motor and test the petrol fumes;... -
Page 6: Troubleshooting
Rapid Spray Fire Marshal Operators Handbook TROUBLESHOOTING CONDITION CAUSE REMEDY Pump will not Insufficient motor RPM Increase motor RPM until pump primes prime / draw Air leak on suction plumbing Tighten/ replace fittings and hose water Blocked/ restricted intake clamps. Verify suction hoses are in good hose condition. -
Page 7: Operation
Rapid Spray Fire Marshal Operators Handbook OPERATION BEFORE BEGINNING OPERATION Check all hoses, connections and hose clamps to ensure that the unit has been delivered to you without transportation loss or damage. Before attempting any fire fighting with your new unit, operate it to familiarise yourself with its features and capabilities and to ensure that your unit has arrived in a safe working condition. -
Page 8: Honda Gx35 Engine
Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE Please read the Honda® Owners Manual for full safety, operation, parts and maintenance instructions. Always follow manufacturers directions. SAFETY INFORMATION • Understand the operation of all controls and learn how to stop the engine quickly in case of emergency. - Page 9 Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE CONT. COMPONENT & CONTROL LOCATIONS TOP COVER SPARK PLUG (Inside the top cover) WARNING LABEL MUFFLER (Inside the top cover) AIR CLEANER PRIMING PUMP STARTER GRIP FUEL FILLER CUP OIL FILLER CAP/...
- Page 10 Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE CONT. BEFORE OPERATION CHECKS Is your engine ready to go? For your safety, to ensure compliance with environmental regulations, and to maximize the service life of your equipment, it is very important to take a few moments before you operate the engine to check its condition.
- Page 11 Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE CONT. SAFE OPERATING PRECAUTIONS Before operating the engine for the first time, please review the SAFETY INFORMATION section and the BEFORE OPERATIONS CHECKS on previous cards. For your safety, do not operate the engine in an enclosed area such as a garage. Your engine’s exhaust contains poisonous carbon monoxide gas that can collect rapidly in an...
- Page 12 Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE CONT. STARTING THE ENGINE cont. Turn the engine switch [3] to the ON (|) [A] position. Pull the start grip [4] lightly until you feel resistance, then pull briskly in the direction of the arrow [5].
- Page 13 Rapid Spray Fire Marshal Operators Handbook HONDA GX35 ENGINE CONT. STARTING THE ENGINE cont. IMPORTANT SAFETY PRECAUTION Turn the engine switch to OFF position before performing the following procedure. This will prevent the engine from starting and running at maximum speed when the throttle is in the MAX speed position.
-
Page 14: Kawashima Fire Pump
Rapid Spray Fire Marshal Operators Handbook KAWASHIMA FIRE PUMP Please read the Pump Owners Manual for full safety, operation, parts and maintenance instructions. Always follow manufacturers directions. SAFETY INFORMATION • Do not start the engine if the pump has no water. - Page 15 Rapid Spray Fire Marshal Operators Handbook KAWASHIMA FIRE PUMP CONT. WATER HOSE INSTALLATION CONT. Connect the strainer on the inlet hose end. WARNING! Be sure the strainer is installed or pump damage will occur. NOTE. Discharge port angle can be changed to 3 different directions.
- Page 16 Rapid Spray Fire Marshal Operators Handbook KAWASHIMA FIRE PUMP CONT. OPERATION - THROTTLE LEVER Pump output is controlled by adjusting the throttle lever. At maximum throttle position, the pump will deliver the highest output volume. Moving the throttle level toward the idle position will decrease the output volume of the pump.
-
Page 17: Cleaning & Maintenance
Rapid Spray Fire Marshal Operators Handbook CLEANING & MAINTENANCE Maintenance to pump and engine should be carried out regularly. Refer to pump and engine handbooks for Maintenance Schedule. PUMP MAINTENANCE Check pump Operators Handbook for maintenance schedule and further instructions. - Page 18 Rapid Spray Fire Marshal Operators Handbook CLEANING & MAINTENANCE cont. MAINTENANCE SCHEDULE Maintenance of your fire fighting unit should be carried out regularly. See below table for suggested guidelines in ensuring your unit stays at optimum performance. ITEM FREQUENCY TASK PUMP &...
- Page 19 Rapid Spray Fire Marshal Operators Handbook FIRE MARSHAL BREAKDOWN & PARTS Please consult with your local Rapid Spray dealership or contact the Rapid Spray service team on 1800 011 000 before replacing / altering parts. Any unauthorized alteration, modification, attachments or repair to equipment may void the warranty as offered on Rapid Spray product or other componentry.
-
Page 20: Marshal Tank
Rapid Spray Fire Marshal Operators Handbook MARSHAL TANK PARTS BREAKDOWN 250L MARSHAL TANK 910 (L) x 730 (W) x 620 (H) 325L MARSHAL TANK 1040 (L) x 880 (W) x 750 (H) Part No. Qty Description AMPTC00200ATT / 400BTT 200 / 400L Marshal Tank... -
Page 21: Poly Fire Fighting Hose Reel
Rapid Spray Fire Marshal Operators Handbook POLY FIRE FIGHTING HOSE REEL BREAKDOWN Parts No. Description ASR10B Base mount frame for fire hose reel AMATH100MYE Bare hose reel CFBE25M20B 1” BSP to 20mm tail brass elbow CFSPB25M25F 1” BSPM to 1” BSPF brass swivel... -
Page 22: Warranty
RAPID SPRAY in addition or inconsistent with these provisions. Purchasers to whom these provisions apply agree to hold RAPID SPRAY not liable for claims by their customers in excess of the obligations of RAPID SPRAY expressly set forth herein. - Page 23 RAPID SPRAY, only after inspection of the failed component. In no event shall RAPID SPRAY be liable to any person for indirect or consequential damages or for injury or INABILITY | UNSUITABILITY commercial loss resulting from any use or inability to use any RAPID SPRAY product.
- Page 24 Rapid Spray Fire Marshal Operators Handbook This page has been left blank intentionally. Compact Fire Fighters by Rapid Spray...
-
Page 25: Warranty Registration
25 - 40 Hobby farm Hire company 41 - 55 Industrial Home Over 55 Other............What influenced you to purchase a Rapid Spray product? Received Catalogue Better features than competitor product Newspaper advertisement Quality & reliability Magazine advertisement Price Dealer recommendation... - Page 26 Rapid Spray Fire Marshal Operators Handbook This page has been left blank intentionally. Compact Fire Fighters by Rapid Spray...
- Page 27 Rapid Spray Fire Marshal Operators Handbook NOTES AYH013 JUN 2023...
- Page 28 Rapid Spray Fire Marshal Operators Handbook NOTES Compact Fire Fighters by Rapid Spray...
- Page 29 Rapid Spray Fire Marshal Operators Handbook NOTES AYH013 JUN 2023...
- Page 30 Call us on 1800 011 000 or visit www.rapidspray.net 35 Enterprise Cres, Singleton NSW 2330 PO BOX 3119 Singleton NSW 2330 Telephone: 1800 011 000 Facsimile: 02 6571 2951 Rapid Spray Liquid Management Systems AYH013...