7.11 Pipes from tank to dispenser ......25 7.12 Replace dispenser casing ........26 The Toucan Eco Active Plus and Toucan Eco Active are designed to be wall-mounted using electrical and 7.13 Install water input pipe ........27 mains water services to produce eco-cleaning and disinfection fluid that is used instead of disposable 7.14 Install power cable ..........27...
CENTREGO RENEW CENTREGO RENEW 2.0 SPECIFICATIONS Solution Production Details (This applies to Toucan Eco Active & Toucan Eco Active Plus) Centrego Toucan Eco batch ECA batch production products Capacity 10 Litres for Toucan Eco Active & 5 Litres for Toucan Eco Active Plus...
The following safety symbols may be used in this manual and on the device itself. The following safety information is guidance for the use of the ECA solution that is produced by the Toucan Eco Active and Toucan Eco Active Plus. • Use only for surface and fabric cleaning, disinfection and deodorisation •...
• Use water input that has a temperature between 5 °C and 40 °C • Read this manual fully before installation and use, of the Toucan Eco Active and Toucan Eco Active Plus • Low-calcium water is recommended •...
Spray Dispenser can be supplied by the manufacturer. A spray bottle/dispenser is commonly used with the Toucan Eco Active. If stock is needed of these, they can be Parts Supplied with the Unit supplied by the manufacturer. This is not listed below.
CENTREGO RENEW CENTREGO RENEW P 13 6.0 INSTALLATION GUIDE 6.1 Toucan Eco Active - Installed device example 1 - Toucan Eco Active Control Box 6.2 Prepare the wall space for installation 2 - Soft touch activation button 3 - Powercable input to control box...
P 14 CENTREGO RENEW CENTREGO RENEW P 15 6.4 Place solution tank into shelf and x control 6.6 Fit water input pipe box to wall After placing the solution tank in metal shelf as Fit the 10mm blue water input pipe from the shown.
P 16 CENTREGO RENEW CENTREGO RENEW P 17 6.8 Brine tank preparation Fill brine tank with 2 litres of tap water To prepare the brine tank first collect the following: • Brine tank and pump from the device • 2 litres of water •...
P 18 CENTREGO RENEW CENTREGO RENEW P 19 7.0 Toucan Eco Active Plus - Installed device example 1 - Toucan Eco Active Plus control unit 2 - Soft touch activation button 3 - Power cable 6.9 Place brine tank onto metal shelf...
P 20 CENTREGO RENEW CENTREGO RENEW P 21 7.1 Prepare the wall space for installation Choose a wall space of 800mm wide by 800mm 7.3 Prepare dispenser for installation high at 800mm above floor level. Push the white key into the top of the dispenser Install close to a water and electrical supply as per to release the front casing as shown.
P 22 CENTREGO RENEW CENTREGO RENEW P 23 7.7 Screw dispenser casing to wall 7.5 Release internal tubing Fix the dispenser to the wall with the screw set supplied. Screw holes are shown with red circles. After unclipping the internal tubes you will be able to pull them out and up to remove the tube set from the casing.
P 24 CENTREGO RENEW CENTREGO RENEW P 25 7.9 Install connection between water input and 7.11 Pipes from tank to dispenser dispenser unit After fitting the 15mm to 10mm reducers. Follow the below order to connect The 15mm flexible pipe can be hand screwed into...
P 26 CENTREGO RENEW CENTREGO RENEW P 27 7.12 Replace dispenser casing 7.13 Install water input pipe Replace the top casing for the dispenser 1) Connect blue 10mm water by resting the bottom of the top casing against pipe to mains water input the back casing.
P 28 CENTREGO RENEW CENTREGO RENEW P 29 7.15 OPERATION INSTRUCTIONS To prepare the brine tank first collect the Fill brine tank with 2 litres of tap water following: • Brine tank and pump from device • 2 litres of water •...
P 30 CENTREGO RENEW CENTREGO RENEW P 31 8.0 Toucan Eco Active - Maintenance process 7.16 Add the brine tank to the installation Empty the tank before following these steps. Put the prepared brine tank on the metal shelf. To fill the solution tank with water using The installation is now complete.
P 32 CENTREGO RENEW CENTREGO RENEW P 33 8.1 Toucan Eco Active - Start solution production Unscrew the cap from the Make sure the control box is plugged in and main tank. The soft touch button will go green when on and ready.
P 34 CENTREGO RENEW CENTREGO RENEW P 35 8.2 Fill spray bottle from dispenser 8.3 Fill large container from dispenser Unscrew the top from the spray bottle that you wish to fill. Ensure the large container is on the floor with the long pipe from the dispenser inside as shown.
Page 19
P 36 CENTREGO RENEW CENTREGO RENEW P 37 8.4 Fill large container from dispenser To lock the button on the dispenser to fill a large container so that you do not need to hold the button down. Once the large container is full, push button into the dispenser and then rotate anticlockwise.
P 38 CENTREGO RENEW CENTREGO RENEW P 39 8.5 Toucan Active Plus decanting 8.6 Toucan Active Plus decanting solution to a spray bottle solution to a large container To fill a spray bottle with ECA solution Unscrew the lid from the spray bottle, Hold a large container under the tap.
P 40 CENTREGO RENEW CENTREGO RENEW P 41 8.7 Maintanance of Toucan Eco Active Plus For the monthly cleaning maintenance When the tank is empty, clean program, follow this process. the inside with a microfibre cloth. Unplug the device from the power supply.
Page 22
P 42 CENTREGO RENEW CENTREGO RENEW P 43 Lift the filter head out of the tube After using the dispenser key the front of the dispenser will come off Clean the filter with a soft plastic/nylon brush (not a metal brush) under a running tap.
Page 23
P 44 CENTREGO RENEW CENTREGO RENEW P 45 8.8 Maintanance of Toucan Eco Active For the monthly cleaning maintenance When the tank is empty, clean program, follow this process. the inside with a microfibre cloth. Unplug the device from the power supply.
P 46 CENTREGO RENEW CENTREGO RENEW P 47 9.0 warranty A warranty covers your product through your supplier; however, some claims resulting from misuse or careless use will not be covered by the warranty. The device is covered for one year under warranty for normal use. The spray bottle spray head is covered for three months of use under normal conditions.
Please read this instruction carefully and use the check list below. Please call your local supplier if a problem persists. After testing and quality control, the Toucan Eco Active Plus is packaged in a bespoke Centrego-branded cardboard box. His is packaged with bubble wrap and paper to ensure safety during transportation.
Page 26
Turn the water input off and re-assemble the dispenser based There is a leak in the dispenser Dispenser is leaking on the Centrego Youtube video for due to damage or incorrect assembly. this process.