Swing Slide Climb Ponderosa MPS132 Assembly Instructions Manual

Ponderosa Multi Play Set(MPS132)
Thank you for purchasing the Ponderosa Multi Play Set (MPS132)
Warning:Only for domestic outdoor use.
This Play Set satis es all the requirements of the Australian Standard AS/NZS ISO
8124 and has been certi ed by an independent laboratory. To guarantee safety,
please give special attention to the assembly, safety, and care instructions
detailed in this document.
ASSEMBLY ADVICE
- Follow the instructions exactly.
- This product must be assembled by adults.
- Once assembly has been completed, keep the instructions in a safe place for
future reference. This can be particularly handy for identi cation of parts if any
after sales service is required.
- Before commencing assembly, check that none of the parts are missing. If you
nd that you are missing a part please contact our after sales service depart-
ment.
- Retain extra parts to use as spares in the future if necessary.
- Pre-Drill timber before xing with screws to avoid cracks in the timber.
The dimensions given in the instructions are indicative only, they may vary
according to the assembly method.
SAFETY ADVICE
- As per legal requirements, a swing seat with exible means of suspension must
have a 40cm minimal distance between the ground and the swing. This distance
is important for safety. The distance between the swing seat and the ground and
the trapeze and the ground can be adjusted using the plastic height adjustment
hooks.
- Warning: This product is only to be used by children between the ages of 3 and
12.
- Warning: Not to be used by anyone weighing over 50kgs.
- Warning: Choking hazard-small parts can be dangerous for children .
- Warning: This play set must be used under adult supervision.
- This product is for private use at home only. Under no circumstances is it to be
used in parks, schools, camp sites, hotels, public leisure areas etc.
- The Play Set should be set up on a at surface and 2 metres away from any
structures or obstacles (walls, fences, trees, washing lines, cables etc).
- To avoid eye damage, we advise that the swing and slide should not be setup
directly facing the sun.
- The Play Set should be installed over impact absorbing surfaces such as sand,
wood-bark chips, rubber and foam and must NOT be set up on a hard surface
(concrete, tarmac etc). For detailed information about surfaces please refer to
the attached consumer information sheet.
- We recommend to secure your swing set rmly into the ground using cement
- The anchorage must be checked regularly.
- Dispose of packaging thoughtfully.
- Do not allow children to play with packaging.
- Please see below diagram for maximum fall height of swing.
CAUTION ! This Product includes timber and/or fabric, Please Keep away from
re.
FIXING INTO THE GROUND
IMPORTANT ! For safety reasons, your Play Set must be embedded into the
ground.
- Place your Play Set in the desired position and mark a square area 350mm x 350
mm around each of the feet. Dig holes 350 mm deep. (The feet must be in the
center of the square)
SL 804132-1_IM.indd 1
All manuals and user guides at all-guides.com
Customer Support: (03) 9786 0055
- Fill the holes with concrete. Do not exceed the ground level. Fit the embedding
piece into the center of the concrete so that xtures for screwing the posts into
place rise out of the concrete.
- When the concrete is dry, screw the posts to the embedding pieces.
- Anchors shall be placed level with or under ground in order to reduce tripping
hazards.
IMPORTANT ! Wait until the concrete is set before using and check anchorages
regularly.
MAINTENANCE
- All parts should be checked at least once a month.
- Check all nuts and bolts for tightness and tighten when required.
- Check for signs of wear to bolt coverings. If sharp edges are found, replace as
required.
- In certain regions (seaside areas), certain coatings could be prone to damage.
In this case, it is advised to use a rust prevention treatment.
- Check swing seats, chains, ropes and other means of attachment for evidence
of deterioration; replace when required in accordance with the manufacturer's
instructions.
- All parts that are under constant friction should be oiled regularly using a
suitable lubricant.
- The ground on which the play centre is set up should be cleared regularly. All
objects such as stones or anything else that could cause injury in the case of a fall
should be removed.
- It is recommended that during the winter period when the equipment is not in
use, all apparatus are removed to prevent deterioration due to bad weather.
- Sand rusted areas and tubular members and repaint using a non-lead based
paint when required
- Modi cations to the original activity toy should only be carried out under
instructions from the manufacturer.
- Defective parts should only be replaced in accordance with the manufacturer's
instructions
- As timber is a natural product, It will deteriorate in the weather over time. For
maximum longevity of your timber, it is highly recommended to apply an initial
3 coats of a timber protectant such as an exterior grade oil before rst use of the
play set.
All outdoor wooden products require routine inspection and regular mainte-
nance. After installation, a follow-up inspection should take place after one
week and twice a month thereafter for the remaining life of your play products.
Maintenance should be performed at any time it is deemed necessary. As a
general rule, major maintenance (wood re nishing) should be performed at
twelve month intervals from the date of installation. Inspect and perform
maintenance based on the following checklist.
Major wooden parts: Inspect for splintering and structure defects at regular
intervals. For very minor splinters or chipping, lightly sanding and re nish with
an exterior water repellent stain can assist. If timber has cracked or split
signi cantly, replacement parts may be required, please contact national
customer service centre for any replacement requirements
At regular intervals, the application of a penetrating oil based sealer stain to all
wooden components is essential. Please consult your local hardware or home
improvement store for recommendation of an appropriate product. Ensure the
product does not contain hazardous chemicals once dry that can pose a
potential health risk to children.
We hope you have a safe and enjoyable time using the Multi Play Set.
2013-7-25 13:49:14