Page 2
WARNING DANGER FOR OUTDOOR USE ONLY • Never operate this appliance unattended. • Never operate this appliance within 3 m / 10 ft of any structure, combustible DANGER material or other gas cylinder. If you smell gas: • Never operate this appliance within 7.5 m •...
REPLACEMENT PARTS MODEL SHP60 Item Part Number Description Quantity Item Part Number Description Quantity SHP60-1 SHP60 Stove asm SHP100-9 SHP Heat Shield SHP100-2 Match holder SHP60-2 60 QT pot lid SHP100-3 SHP Bolt plate SHP60-3 60 QT strainer SHP100-4 SHP ignitor cover...
Page 4
REPLACEMENT PARTS MODEL SHP80 Item Part Number Description Quantity Item Part Number Description Quantity SHP80-1 SHP80 Stove asm SHP100-8 SHP Regulator SHP100-2 Match holder SHP100-9 SHP Heat Shield SHP100-3 SHP Bolt plate SHP80-2 80 QT pot lid SHP100-4 SHP ignitor cover SHP80-3 80 QT strainer SHP100-5...
Page 5
REPLACEMENT PARTS MODEL SHP100 SHP100 Item Part Number Description Quantity Item Part Number Description Quantity SHP100-1 SHP100 Stove asm SHP100-8 SHP Regulator SHP100-2 Match holder SHP100-9 SHP Heat Shield SHP100-3 SHP Bolt plate SHP100-10 100 QT pot lid SHP100-4 SHP ignitor cover SHP100-11 100 QT strainer SHP100-5...
IMPORTANT SAFETY WARNINGS 1. Do NOT leave this appliance unattended 10. In the event of fire do NOT attempt to while in use. The user must remain in the extinguish with water. Use a Type BC dry immediate area of the product and have chemical fire extinguisher or smother fire a clear view of the product at all times with dirt, sand or baking soda.
Page 7
• Always have a BC or ABC fire extinguisher and diameter recommended by the readily available when cooking. manufacturer: • This appliance is not designed for use with • SHP60: 17.3" natural gas. • SHP80: 18.9" • Before opening LP tank valve, check the • SHP100: 20.1"...
Page 8
LP Tank Removal, Transport and Storage WARNING: Hose is a trip hazard. • Turn OFF all control valves and LP tank valve. Turn coupling nut counterclockwise by hand only – do not use tools to disconnect. Place dust cap on cylinder 24"/61cm valve outlet whenever cylinder is not in use.
Page 9
LP Tank LP Tank Filling The LP tank used with your appliance must • Use only licensed and experienced dealers. meet the following requirements: • LP dealer must purge tanks before filling. • The tank must be approximately 31.1 • Dealer should NEVER fill LP tank more cm/12 in diameter x 46 cm/18.25 in tall than 80% of LP tank volume.
Page 10
LP Tank Leak Test Connecting Regulator to the LP Tank Only use the pressure regulator and hose WARNING supplied with this appliance. Appliance must be leak checked outdoors 1. Place LP tank on a secure, level, and in well-ventilated area, away from ignition stable surface.
Page 11
Hose Check WARNING • Before each use, check to see if hoses Appliance must be leak checked outdoors are cut or worn. Replace damaged hose in well-ventilated area, away from ignition assembly before using appliance. Use sources such as gas fired or electrical only valve/hose/regulator specified by appliances.
Page 12
Instructions for lighting burner with match: Burner Flame Check Do not lean over LP cooker while lighting. • Light burner. You should see a smaller Read all instructions before lighting and only flame in the LOW position than seen on light burner outdoors.
Page 13
Component Cleaning: • BURNER: Wire brush loose corrosion from burner exterior. Clean clogged gas port holes with an opened paper clip. Replace corroded or damaged burners that would emit excess gas. • COOKING SURFACES, POTS AND PANS: Clean the cooking surface with soapy water and a nylon cleaning pad.
TROUBLESHOOTING Why won’t my burner light? • Make sure your regulator is fully tightened on the propane tank. Try unscrewing and re-tightening the coupling nut. • Make sure your LP tank has propane. • Make sure you press and hold the ignition button on ignition. It may take a few clicks for the gas to catch fire.
Camp Chef No-Hassle Limited Warranty: Here at Camp Chef we stand by our products, quality controls, and take pride in our customer service. Because of this, your new Camp Chef product comes with a No-Hassle Limited Warranty. For Hassle-Free warranty service, be sure to register your products at campchef.com/productregistration.