All manuals and user guides at all-guidesbox.com TABLE OF CONTENTS CHAPTER 1 GENERAL ADJUSTMENTS SAFETY INSTRUCTIONS ............................3 SET-UP ADJUSTMENT ............................4 SERVICE MODE ..............................6 DESIGN MODE ................................ 9 ELECTRICAL ADJUSTMENTS ..........................10 CIRCUIT CHECK ..............................17 CHAPTER 2 SPECIFIC INFORMATIONS SETTING &...
All manuals and user guides at all-guidesbox.com CHAPTER 1 GENERAL ADJUSTMENTS SAFETY INSTRUCTIONS WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” INSTRUCTIONS BELOW. X-RAY RADIATION PRECAUTION 1. Excessive high voltage can produce potentially hazardous 2.
All manuals and user guides at all-guidesbox.com WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF SERVICE MANUAL. SET-UP ADJUSTMENT ■ The following adjustments should be made when a complete realignment is required or a new picture tube is installed. Perform the adjustments in order as follows : 1.
Page 5
All manuals and user guides at all-guidesbox.com (5)Adjust the sub-4-pole magnets only in case there is any deviation of Xv bow-shaped convergence. (To be usually set at the initial position) Align both sides with the sub-4-pole magnets and minimize the deviation of blue and red with the main 4-pole magnets. Xv bow-shaped deviation of convergence red/blue blue...
All manuals and user guides at all-guidesbox.com SERVICE MODE 1. ENTERING TO SERVICE MODE 1) Press o button once on 2) Press o button again to 3) While pressing the o button, Remote Control. keep pressing. press MENU button on TV set. Item Data or Sound Mute...
Page 7
All manuals and user guides at all-guidesbox.com 4. SELECTING THE ADJUSTING ITEMS 1)Every pressing of CHANNEL s button in the service mode changes the adjustment items in the order of table-2. (t button for reverse order) Refer to table-2 for preset data of adjustment mode. (See SETTING &...
Page 8
The diagnosis will begin to check if interface among IC’s are executed properly. 2) During diagnosis, the following displays are shown. JH9_000 29CJZ8UR Firmware: Version information of microprocessor In case of file name : JH9 and Version : 1.00 indicates[JH9_100].
All manuals and user guides at all-guidesbox.com DESIGN MODE 1. ENTERING TO DESIGN MODE 1) Select the Service mode. 2) While pressing CALL button on Remote 3) The following displays and press MENU button on TV. are shown on the screen Press Press JH9_039...
All manuals and user guides at all-guidesbox.com ELECTRICAL ADJUSTMENTS ITEM ADJUSTMENT PROCEDURE FOCUS VR ADJ 1. Enter the service mode, then select any register item. 2. Press the TV/VIDEO button on the Remote until the black cross-bar pattern ap- pears on the screen. 3.
Page 11
All manuals and user guides at all-guidesbox.com ITEM ADJUSTMENT PROCEDURE WIDTH 1. Call up the adjustment mode display, then select the item WID. (WID) 2. Press the ; – /+ button to get the picture so the left and rightedges of raster begins to lack.
Page 12
All manuals and user guides at all-guidesbox.com V/C system adjustment ADJUSTING ITEMS REMARKS ADJUSTMENT PROCEDURE AND POINTS No outside lighting shall be Cutoff adjustment and 1) Setting to horizontal alignment, turn the screen VR to white balance adjust- stop where the brightness lines are slightly luminous. allowed.
Page 13
All manuals and user guides at all-guidesbox.com Circuit Adjustment (Procedure Manual for Deflection Adjustment) ADJUSTING ITEMS ADJUSTMENT PROCEDURE AND POINTS Focus Adjustment (1) Conditions : PAL RETMA ch Static (main): T461 Screen Size : Wide Dynamic : T461 Presentation Mode : Dynamic Only for 34-inch model Adjustment Procedure: 1) Turn the static VR knob to the “MIN.”...
Page 14
All manuals and user guides at all-guidesbox.com Horizontal adjustment * Deflection adjustment shall be made from PAL/100 Hz/WIDE mode. ADJUSTING ITEMS ADJUSTMENT PROCEDURE AND POINTS Hori- For PAL/100 Hz/WIDE <Adjustment condition> zontal Horizontal amplitude Horizontal adjusment shall be made using E-12CH Philips pattern and DY- (WID) NAMIC image mode.
Page 15
All manuals and user guides at all-guidesbox.com Vertical adjustment ADJUSTING ITEMS ADJUSTMENT PROCEDURE AND POINTS Verti- For PAL WIDE 1) With E-12ch, WIDE mode, DYNAMIC and 100 Hz, adjust the vertical screen posi- Vertical amplitude tion (VPOS) and amplitude (HIT) as shown in the following figure: (HIT) Flags shall just be blinded.
Page 16
All manuals and user guides at all-guidesbox.com Geomagnetic compensation (chassis adjustment) ADJUSTING ITEMS ADJUSTMENT PROCEDURE AND POINTS Output voltage control Conditions: User control for geomagnetic compensation: 0 (GMF) Geomagnetic compensation coil: Unconnected Perform voltage measurement at both ends of RJ06 and adjust the volt- age to the following adjustable value with GMF of data adjustment mode: 0 ±...
All manuals and user guides at all-guidesbox.com CIRCUIT CHECK HIGH VOLTAGE CHECK CAUTION: There is no HIGH VOLTAGE ADJUSTMENT on this chassis. Checking should be done following the steps below. 1. Connect an accurate high voltage meter to the second anode of the picture tube. 2.
All manuals and user guides at all-guidesbox.com CHAPTER 2 SPECIFIC INFORMATIONS SETTING & ADJUSTING DATA SAFETY INSTRUCTIONS 29" HIGH VOLTAGE AT ZERO BEAM: 29.5 kV MAX HIGH VOLTAGE: 33.0 kV AC VOLTAGE 220~240 V Table-1 SERVICE MODE ADJUSTING ITEMS AND DATAS IN THE SERVICE MODE: Item Name of adjustment Item...
All manuals and user guides at all-guidesbox.com LOCATION OF CONTROLS Front ON-TIMER indicator (green) Press to open the door. I POWER indicator (red) Remote sensor Behind the door Input source selection Headphones jack – + Volume POWER switch (ø3.5 mm) <...
Page 20
All manuals and user guides at all-guidesbox.com Remote Control /CALL Power on/Standby CALL (For Toshiba TV/VCR/DVD only) Number buttons (0-9) Input source selection 1 or 2 digit channel selection (a1, a2, a3, aC1, aC2) Selectable sound Selectable picture MENU EXIT...
All manuals and user guides at all-guidesbox.com PROGRAMMING CHANNEL MEMORY First, use the Auto tuning to preset all the active channels in your area automatically. Then, arrange the preset channels with the Manual tuning so that you can tune into only desired channels. Use the Manual tuning if desired channels cannot be preset with the Auto tuning or if you would like to preset channels to specific position numbers one by one.
Page 22
All manuals and user guides at all-guidesbox.com D. Program position skip selection Press the button to turn the program position skip option on “ ” or off “ ”. The program position will then be skipped when you select program positions with the CH8 or CH9 button.
• The part number must be used when ordering parts, in order to assist in processing, be sure to include the Model number and Description. ∗ • The PC board assembly with mark is no longer available after the end of the production. Model : 29CJZ8UR Capacitors ..... CD Ceramic Disk : Plastic Film : Electrolytic Resistors ....
Page 24
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description C676 24669479 ELECTROLYTIC, 50V 4.7UF M 3A C910 24669478 ELECTROLYTIC, 50V 0.47UF M 3A C677 24503042 PLASTIC FILM, 63V 0.12UF J C911 24203100 ELECTORLYTIC, 16V 10UF M 7L 3A C678 24503041 PLASTIC FILM , 63V 0.1UF J...
Page 25
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description CS56 24092538 CERAMIC CHIP, 10V F 1UF Z R330 24998103 CHIP, 1/16W 10K OHM CS57 24794470 ELECTROLYTIC, 16V 47UF M R331 24872823 CHIP, 1/16W 82K OHM J CS64 24794220 ELECTROLYTIC, 16V 22UF M...
Page 26
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description R662 24366101 CARBON FILM, 1/6W 100 OHM J @U905A R883 24366561 CARBON FILM, 1/6W 560 OHM J 24011222 CHIP, 1/20W 2.2K OHM J @U902 R899 24004718 METAL GLAZE 1/2W 8R2M J R663...
Page 27
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description R4560 24011102 CHIP, 1/20W 1K OHM J RS45 24011562 CHIP, 1/20W 5.6K OHM J R4562 24011103 CHIP, 1/20W 10K OHM J RS46 24011562 CHIP, 1/20W 5.6K OHM J R4563 24011752 CHIP, 1/20W 7.5K OHM J...
Page 28
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description RV123 24011102 CHIP, 1/20W 1K OHM J LV10 23103159 EMI FILTER, TEM2028AA, 7.5X6.4X8 60MMH 0.5A RV124 24011330 CHIP, 1/20W 33 OHM J LV11 23103159 EMI FILTER, TEM2028AA, 7.5X6.4X8 60MMH 0.5A RV201 24011750 CHIP, 1/20W 75 OHM J...
Page 29
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description Q908 23114429 TRANSISTOR, 2SC2120-Y D630 23316591 DIODE, ZENER, MA8100-M Q910 23114433 TRANSISTOR, 2SC1815-Y D631 23118041 DIODE, MA111 Q4021 23314204 TRANSISTOR, 2SC2412K,Q D632 23118041 DIODE, MA111 Q4022 23314163 TRANSISTOR, 2SA1162-Y...
Page 30
All manuals and user guides at all-guidesbox.com Location Location Parts No. Description Parts No. Description DJ02 23357366 DIODE, FR105-B5 N724 23965900 TAPE, GLASS-CLOTH, W/ADHESIVE W=18 T=0.18 DJ03 23357366 DIODE, FR105-B5 N728 23960101 SILICONE RUBBER, TSE-382 RTV DJ04 23357366 DIODE, FR105-B5 P018A 23368577 CONNECTOR, PLUG, 3P 2.5MM G JST-EH, B3B-EH-F1-TV4...
Page 31
All manuals and user guides at all-guidesbox.com Location Parts No. Description Y101 23566560 OWNERS MANUAL, ENGLISH/RUSSIAN Y120 23943846 BAG, POLY Y121 23943846 BAG, POLY CABINET PARTS A201 23533040 COVER, FRONT COVER A401 23532442 COVER, BACK COVER A902 23428340 DOOR, DOOR PROPER A905 23445889 BUTTON, BUTTON POWER...
Page 32
All manuals and user guides at all-guidesbox.com MEMO - 32 -...
All manuals and user guides at all-guidesbox.com MODULE HYPER SIG BOARD UD1842E (UM01) BOTTOM (FOIL) SIDE - 33 - - 34 -...
Page 34
All manuals and user guides at all-guidesbox.com MODULE HYPER SIG BOARD UD1842E (UM01) TOP (COMPONENT) SIDE - 35 - - 36 -...
Page 35
All manuals and user guides at all-guidesbox.com POW/DEF BOARD PD1883J (U903) BOTTOM (FOIL) SIDE CAUTION LIVE AREA D815 R805 R379 P498 R818 G380 C396 R829 D808 D817 T803 C823 GJ406 23547685 C807 R807 D803 G406 C812 C816 C809 T400 G810 D801 R814 L811...
Page 36
All manuals and user guides at all-guidesbox.com CRT-D BOARD PD1882L-1 (U901A) BOTTOM (FOIL) SIDE CCP-6400S 23547684 Q904 D905 Q907 L910 R939 R981 R983 R985 R984 C922 C924 C904 C905 R924 R917 R933Z Q911 Q903A Q901A R933 L905 R987 R988 R943 Q903 R912 R932...
Page 37
All manuals and user guides at all-guidesbox.com AV-TERMINAL BOARD PD1846H (U902) BOTTOM (FOIL) SIDE BB03A BB06A P602 P603 BB09A GR800 GRS06 R609 R610 GRS05 BB05A RS23 R603 R603 BB04A RS09 C602 CS11 RS05 RS23 C8345 C8352 RS03 RS01 GRS03 P018B RS07 Q601 GRS01...
Page 38
All manuals and user guides at all-guidesbox.com AV-TERMINAL BOARD PD1846H (U902) TOP (COMPONENT) SIDE JP033 JP010 P602 P603 BB05A BB06A BB03A C8345 BB04A C601 C602 PP06 BB09A 3 2 1 CS01 R672 P018B Q833 C678 GND_AUDIO GND_AUDIO D601 27V_AUDIO C836 27V_AUDIO C680 C661...
Page 39
All manuals and user guides at all-guidesbox.com CONTROL BOARD PD1890B-1 (U905A) BOTTOM (FOIL) SIDE SA06 SA05 SA04 SA03 SA02 SA01 CC13 CC14 PV03 R662 CC12 RA76 RA71 RA72 RA73 CC11 RA87 D821 P661 S801 D863 R844 PB01A SR85 SR84 SR83 CV50 Q863 P019A...
Page 40
All manuals and user guides at all-guidesbox.com SCHEMATIC DIAGRAM MODEL : 29CJZ8UR WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL. CAUTION: The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list.
Page 41
All manuals and user guides at all-guidesbox.com SCHEMATIC DIAGRAM STRUCTURE: HYPER SIGNAL (1/3) [SHEET-1/3] .... 1/54 .... 2/54 (2/3) [SHEET-2/3] (3/3) [SHEET-3/3] .... 3/54 REGULATOR .................... 4/54 (1/2) [SHEET-1/2] .... 5/54 (2/2) [SHEET-2/2] .... 6/54 ACTIVE-FILTER ..................7/54 AD-CONVERTER [SHEET-1/2] ....
Page 42
All manuals and user guides at all-guidesbox.com - 49 -...
All manuals and user guides at all-guidesbox.com SPECIFICATIONS MODEL 29CJZ8UR Rated voltage 220 – 240 V, 50 Hz Power consumption 180 W 220 V, 50 Hz) Dimensions 782 mm 488 mm 585 mm (Width Depth Height ) Mass (Weight) 45.5 kg...
Page 44
All manuals and user guides at all-guidesbox.com...
Page 45
All manuals and user guides at all-guidesbox.com SCHEMATIC DIAGRAM MODEL : 29CJZ8UR WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL. CAUTION: The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list.
Page 46
All manuals and user guides at all-guidesbox.com SCHEMATIC DIAGRAM STRUCTURE: HYPER SIGNAL (1/3) [SHEET-1/3] .... 1/54 .... 2/54 (2/3) [SHEET-2/3] (3/3) [SHEET-3/3] .... 3/54 REGULATOR .................... 4/54 (1/2) [SHEET-1/2] .... 5/54 (2/2) [SHEET-2/2] .... 6/54 ACTIVE-FILTER ..................7/54 AD-CONVERTER [SHEET-1/2] ....
Page 47
All manuals and user guides at all-guidesbox.com...
Page 48
All manuals and user guides at all-guidesbox.com 0.1V/div 0.1V/div 29CJZ8UR BEP (1/3) SH.NO. SHEET-1/3 (1/54)
Page 92
All manuals and user guides at all-guidesbox.com U901A L801Z L802Z OPEN OPEN L802 L801 TPW2064AL/TPW2058AS TPW2064AL/TPW2058AS P804B Lock 2P_11.88mm_S GJ16 OPEN GJ14 OPEN GJ17 OPEN GJ15 OPEN 29CJZ8UR CRT-D/SVM CHOKE COIL (45/54)
Page 93
RXD_EXT 5V1_EXT 7-C3 TO CONTROL BOARD TXD_EXT IF_GND RXD_EXT P018B 3P_2.5mm_1.5A_Beige 7-B5 7-B5 GND_AUDIO GND_AUDIO 7-B5 GND_AUDIO 27V_AUDIO 27V_AUDIO 27V_AUDIO 7-B5 7-B5 P805 CON 1P TO B/M MODULE TO PC/D TERMINAL TO PC/D TERMINAL 29CJZ8UR AV TERMINAL (1/7) SHEET-1/7 (46/54)
Page 94
Q4103 2SC4667 2SC4081-Q R4102 R4107 G_PC G_PC R4109 R4104 Q4102 2SC4081-Q R4123 R4121 2.2k B_PC 2.2k B_PC Q4100 2SC4667 R_PC R_PC VS_PC VS_PC HS_PC HS_PC GRV01 OPEN GRV02 OPEN GRV03 OPEN GRV04 OPEN 29CJZ8UR AV TERMINAL (V SW) SHEET-2/7 (47/54)
Page 100
4.7k 1SS133 SR83 R808A G5PA-2 RZ92P2E4R5M1 D821 1SS133 Q821 2SC1815-Y R844 R843 5V-2 14 13 FROM POW/DEF TO POW/DEF POWER/DEF BOARD HYPER SIGNAL BOARD HYPER SIGNAL BOARD AV TERMINAL BOARD AV TERMINAL BOARD BB07/BB08 OR P018A/P019A 29CJZ8UR CONTROL LED (53/54)