In line with this, Toshiba proactively promotes Green Procurement, and seeks to purchase and use products, parts and materials that have low environmental impacts.
All manuals and user guides at all-guides.com CHAPTER 1 GENERAL ADJUSTMENTS SAFETY INSTRUCTIONS WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” INSTRUCTIONS BELOW. X-RAY RADIATION PRECAUTION 1. Excessive high voltage can produce potentially hazardous 2.
All manuals and user guides at all-guides.com WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF THIS MANUAL. SET-UP ADJUSTMENT R The following adjustments should be made when a complete realignment is required or a new picture tube is installed. Perform the adjustments in order as follows : 1.
Page 5
All manuals and user guides at all-guides.com CONVERGENCE ADJUSTMENTS R CIRCUMFERENCE CONVERGENCE ADJUSTMENT NOTE: Before attempting any convergence adjustments, the 1. Loosen the clamping screw of deflection yoke slightly to receiver should be operated for at least fifteen allow the yoke to tilt. minutes.
Page 6
All manuals and user guides at all-guides.com WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU- TION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF SERVICE MANUAL. SET-UP ADJUSTMENT (FOR FLAT TUBE) I The following adjustments should be made when a complete realignment is required or a new picture tube is installed. Perform the adjustments in order as follows : 1.
Page 7
All manuals and user guides at all-guides.com (5)Adjust the sub-4-pole magnets only in case there is any deviation of Xv bow-shaped convergence. (To be usually set at the initial position) Align both sides with the sub-4-pole magnets and minimize the deviation of blue and red with the main 4-pole magnets. Xv bow-shaped deviation of convergence red/blue blue...
All manuals and user guides at all-guides.com SERVICE MODE 1. ENTERING TO SERVICE MODE 1) Press o button once on 2) Press o button again to 3) While pressing the o button, Remote Control. keep pressing. press MENU button on TV. Item Data (Service mode display)
Page 9
All manuals and user guides at all-guides.com 4. SELECTING THE ADJUSTING ITEMS 1) Every pressing of CH s button in the service mode changes the adjustment items in the order of table-2. (t button for reverse order) Refer to table-2 for preset data of adjustment mode. (See SETTING &...
Page 10
All manuals and user guides at all-guides.com 7. SELF DIAGNOSTIC FUNCTION 1) Press “9” button on the remote control during display of adjustment menu in the service mode. The diagnosis will begin to check if interface among IC’s are executed properly. 2) During diagnosis, the following displays are shown.
All manuals and user guides at all-guides.com DESIGN MODE 1. ENTERING TO DESIGN MODE 1) When in Service mode (see 2) While pressing CALL button 3) Press MENU button on TV. page 8), press CALL button again and press MENU button on the remote control once.
All manuals and user guides at all-guides.com ELECTRICAL ADJUSTMENTS ADJUSTMENT PROCEDURE ITEM FOCUS VR ADJ 1. Enter the service mode, then input AV1 black cross-bar pattern with signal generator. 2. Adjust the FOCUS control (on T461) for well defined scanning lines on the picture screen.
All manuals and user guides at all-guides.com ADJUSTMENT PROCEDURE ITEM WHITE BALANCE 1. Select AV1 (with no input). ADJUSTMENT 2. Enter Service mode and press “0” button. 3. Adjust Screen VR until OSD “HBC” toggle SCREEN VOLTAGE ADJUST- between 1 & 0. MENT (SCREEN VR) of FBT 4.
All manuals and user guides at all-guides.com CHAPTER 2 SPECIFIC INFORMATIONS SETTING & ADJUSTING DATA SAFETY INSTRUCTIONS 29" HIGH VOLTAGE AT MAX BEAM CURRENT: 30.0 kV MAX HIGH VOLTAGE: 32.0 kV AC VOLTAGE 110-240 V Table-1 SERVICE MODE ADJUSTING ITEMS AND DATAS IN THE SERVICE MODE: Item Adjustment Reference Data...
All manuals and user guides at all-guides.com NAMES AND FUNCTIONS OF CONTROLS Model 29CZ5DE is used in this manual for illustration purpose. TV Front and Remote control " Open the lid & Remote Control Main power on/off Power on/standby Stereo/bilingual mI/II Remote sensor selection...
All manuals and user guides at all-guides.com PROGRAMMING CHANNEL MEMORY Model 29CZ5DE is used in this manual for illustration purpose. Preset the channels automatically To use the SEARCH function (ASM function) Press MENU and then ; -/+ to highlight the “ TUNING”...
Page 17
All manuals and user guides at all-guides.com To skip a position number Auto fine tuning (AFT) After presetting the channels, you may skip unnecessary If the signal frequency is unstable due to environmental position numbers so that only the channels you want to watch conditions, use auto fine tuning.
All manuals and user guides at all-guides.com PROCEDURES TO SET HOTEL MODE 1. Set the Channel Programs which you want the Customer to watch. Use ASM (see page 16) or SEARCH (see page 16) to select the programs. Choose the position you want the programs to be stored in TUNING menu. Save the programs by MEMORY operation in TUNING menu (see page 16).
All manuals and user guides at all-guides.com CHASSIS AND CABINET REPLACEMENT PARTS LIST WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRE- CAUTION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF THIS MANUAL. CAUTION: The international hazard symbols “ ”...
Page 20
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description C509 76109561 CERAMIC CHIP 50V B 560PF K C899 76214471 CERAMIC DISC 500V B 470PF K C510 76105220 CERAMIC CHIP 50V CH 22PF J C901 76214103 CERAMIC DISC 500V B 0.01UF K C511...
Page 21
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description CV10 76100104 CERAMIC CHIP 25V F 0.1UF Z R117 #3 76366153 CARBON FILM 1/6W 15K OHM J CV11 76100104 CERAMIC CHIP 25V F 0.1UF Z R118 #1 76011101 CHIP 1/20W 100 OHM J...
Page 22
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description R505 76011101 CHIP 1/20W 100 OHM J R902 76376222 CARBON FILM 1/2W 2R2K J R620 76011103 CHIP 1/20W 10K OHM J R903 76376222 CARBON FILM 1/2W 2R2K J R621 76366103 CARBON FILM 1/6W 10K OHM J...
Page 23
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description RS26 76011103 CHIP 1/20W 10K OHM J LA03 23289043 COIL PEAKING TRF4100AU RS27 76011103 CHIP 1/20W 10K OHM J LA04 23289043 COIL PEAKING TRF4100AU RS28 76011103 CHIP 1/20W 10K OHM J LA05...
Page 24
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description D883 23357364 DIODE RU4JGF- M2 QA51 #1 23085647 IC TDA12021H/N1F01 D885 23357471 DIODE RU4DG-3AM2 #2 23085798 IC PHILIPS UOC3-AVST (NO-TXT) TDA12063H/N1F00 D891 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41A #3 23085796 IC TDA12011H/N1F00 D892...
Page 25
All manuals and user guides at all-guides.com Location Parts No. Description Location Parts No. Description Z894 23144415 FUSE PROTECTOR 125V 4A SMP125M04A00 PC BOARD ASSEMBLIES U901 23764818 PC BOARD ASSY PD2078A CRT/D U902 #1 23764737 PC BOARD ASSY PD2249C SIGNAL #2 23764846 PC BOARD ASSY PD2249R SIGNAL #3 23764768...
All manuals and user guides at all-guides.com TERMINAL VIEW OF TRANSISTORS 1 2SD2253 2 2SA1186A 3 2SA1020 4 2SA1015 6 2SA1788 (old) 2SA1306 2SC2482 2SA1320(F) 2SC5243 2SA1788 2SC2655 2SA2980 2SC5859 2SA1837 2SC4721P 2SA562TM 2SA1930 2SC5343 2SA9335 2SC1569 2SC5344 2SC1740S 2SC3852 2SC752GTM 2SC1815 2SC4544...
Page 29
All manuals and user guides at all-guides.com SPECIFIC INFORMATIONS SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY radiation precaution”, “SAFETY PRECAUSTION” and “PRODUCT SAFETY NOTICE” ON THE MANUAL FOR THIS MODEL. CAUTION: The international hazard symbols “ ”...
Page 30
All manuals and user guides at all-guides.com...
All manuals and user guides at all-guides.com SPECIFICATIONS MODEL 29CZ5DE/29CZ5T/29CZ6SI Rated voltage g 110 V – 240 V, 50/60 Hz Power consumption 123 W (at g 220 V, 50 Hz) Dimensions 782.1 (W) × 492.5 (D) × 585.1 (H) mm (Width ×...
All manuals and user guides at all-guides.com – 34 –...
Page 33
All manuals and user guides at all-guides.com SPECIFIC INFORMATIONS SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY radiation precaution”, “SAFETY PRECAUSTION” and “PRODUCT SAFETY NOTICE” ON THE MANUAL FOR THIS MODEL. CAUTION: The international hazard symbols “ ”...
Page 34
All manuals and user guides at all-guides.com...
Page 35
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (1/8) 21CZ6/7/8 29CZ5/6 21CZ7 ONLY HOLDER DB02 DB02A TLSG116 CH UP CH DN VOL UP VOL DN VIDEO MENU DB01 SA01 SA02 SA03 SA04 SA05 SA06 GREEN KB01 RMT SENSER PIC-TB19 21CZ6/8...
Page 36
All manuals and user guides at all-guides.com LOCATION RUSSIA MODEL OTHER MODEL VIETNAM MODEL H001 23321514 ENV59DA7G3 (R1) 23321549 115B8A86ST 23321514 ENV59DA7G3 (R2) 23321545 ENV59K11G3F (R3) 23321534 TAEM-G107D LC04 (RA) 23103279 TEM2014AO (R1) SHORT 100R (RB) 23103248 TEM2014AA LC05 (R2) 100R (R3) 100R...
Page 37
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5/6 B 6B-EH-A PLUG 4P TLA0111 TLA0110 R110 TLA0013 1/6P10k GJ14 KETSU R118 SAW_SW FROM FRONT BOARD C107 Q108 B1000p DTC114EUA G103 M804A 1.8V-2 3.3V-1 R117 1/6P15k SDA1 SDA1 SCL1 SCL1 RFAGC...
Page 38
All manuals and user guides at all-guides.com EL : 29CZ5DE/29CZ5T/29CZ6SI (1/8) 21CZ6/7/8 21CZ7 ONLY HOLDER DB02 TLSG116 DB02A CH UP CH DN VOL UP VOL DN VIDEO MENU DB01 SA01 SA02 SA03 SA04 SA05 SA06 GREEN KB01 RMT SENSER 21CZ6/8 PIC-TB19 TLC09 TLC10...
Page 39
All manuals and user guides at all-guides.com 6-A8 6-E8 POWER 5-B2 P902A PLUG 8P TLC0195 I-BLACK GJ48 KETSU TLC0193 12V_FBT 12V_FBT SHORT GJ47 BOUT GOUT ROUT TLA0098 RV21 TLC0159 4P JACK CV21 PV01 1000p TLC0160 TLC0223 TLC0161 RV02 CV01 E1 S-VIDEO 100p TLC0162 RC02...
Page 42
B/P IN3 CV15 25V0.1 TLC0343 G/YIN3 TLC0250 CV14 All manuals and user guides at all-guides.com 25V0.1 CC03 RV04 RC02 R/P IN3 LC09 LC08 SHORT CV02 CV13 SHORT SHORT 100p 1000p 25V0.1 INSSW3 RA36 DVD IN Detect RA33 VOUT(SW01) TLC0225 E2-DVD RC03 E2-CVBS LC10...
Page 43
TLC0162 All manuals and user guides at all-guides.com RC02 SHORT TLC0164 TLC0163 TLC0166 RC03 SHORT TLC0230 TLC0168 RC04 SHORT CC05 1000p TLC0171 V / Y CV04 RV08 100p E2 DVD RV09 TLC0175 TLC0176 CV06 TLC0248 TLC0234 LC15 TLC0180 SHORT 10V470 TLC0237 TLC0228 R-Out...
Page 44
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (2/8) 1-(161.5,248) VGUARD 1-(161.5,232),3-A3,5-A2 1-(161.5,188) VDR–A 23477932 Q301A Q301 AN5523 C328 R347 R346 Q301B 100V0.1uF TLC0040 TLC0049 Q301C C323 R348 Q320 5.6K KETSU R354 2SC2712-Y Use a chip jumper TLA0051 TLA0050 TLA0049...
Page 45
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (3/8) EHT–INFO 1-(161.5,225) TLC0111 1-(161.5,232),2-A1,5-A2 D475 1SS133 R439 1/6P2.2k TLC0109 TLA0014 C402 R403 C498 1W 472 KETSU D441 1-(161.5,101) TLC0115 D476 MTZJ9.1C 1SS133 C473 OPEN FOCUS D406 EU2A SCREEN TLA0061 TLC0103...
Page 46
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (4/8) 1-(161.5,242.5) PROTECT F470 250V_1A R470 6-C8 125V 125V–1 3-B3 F470A F470B C472 0.47 R156 1R15k 1-(161.5,262) Q471 2SA949-Y R4760 D470 1/4R39K R4770 RD36ESAB2 C470 29CZ5 21CZ6/7/8 R473 50V47u 1/4R18K (RA)23144297(RB)23144210 250V 1A...
Page 47
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (5/8) Q835A Q835 AN34040A TLA0060 TLA0059 TLA0058 TLA0057 TLA0056 TLA0055 3.3V-2 GJ808 TLC0032 1-(161.75,277) SHORT 6-C8 1-(161.5,232),2-A1,3-A3 6-C8 1-(161.5,253.5),3-D3 Q831 KIA78D05F TLC0003 TLC0007 6-C8 27V-2 C837 C839 C838 16V100 C890 63V0.33...
Page 48
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (6/8) RZ92P2E180M5 R808 SR83 KETSU TLA0062 TLC0072 R814 GJ805 12V–FBT 1-(161.25,39),3-B3 7W 271J TLA0063 SHORT D845 TLC0074 KETSU P910 TO DEG COIL C812 SHORT Q805 KETSU R811 1-(680,434) SHORT P802 OPEN...
Page 49
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (7/8) CRT-Drive BOARD R907 P903B PLUG 6P 100ohm +200V TLA021 +200V Q901A HEAT SINK 23474116 C901 500V Q901 10nF C931 R992 D911 500V 1/6W TDA6108AJF EU2A 100p 15ohm TLA022 23474116 HEATER GND...
Page 50
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (8/8) CH UP CH DN VOL UP VOL DN VIDEO MENU DB21 W661 W662 SA11 SA12 SA13 SA14 SA15 SA16 23351255 SPK1401AN 23351255 SPK1401AN GREEN KB21 RMT SENSOR PIC-TB19 TLC09 TLC10...