Table of Contents
Advertisement
WARNING!
!
death. Read and follow all warnings and instructions in this manual prior to operating grill.
Safe Operating Practices
•
This gas grill must be assembled exactly according to the instructions in the manual. If the grill was
store assembled, you must review the assembly instructions to confirm correct assembly and perform
the required leak tests before operating the grill.
•
Read the entire instruction manual before operating the gas grill.
•
Do not modify this appliance.
•
Do not use an adaptor at the cylinder connection.
•
Follow lighting instructions carefully when operating grill.
•
Gas must be turned off at the Universal Liquefied Petroleum Gas cylinder or at the natural gas supply
valve when the gas grill is not in use.
•
Keep children and pets away from hot grill, DO NOT allow children to climb inside cabinet.
•
Do not leave the grill unattended while in use.
•
Do not move grill when hot or operating.
•
This gas grill must not be installed in or on recreational vehicles and/or boats.
•
This gas grill must only be stored outdoors in a well-ventilated area and must not be used inside a
building, garage, screened -in porch or any other enclosed area. Natural gas units must be disconnected
from the supply when being stored indoors.
•
Maintain proper clearance to combustibles: 26" (660mm) to rear of unit and 10" (254mm) to the sides
and 47" (1200mm) above. Additional clearance is recommended near vinyl siding or panes of glass.
•
It is not recommended to operate the unit under any combustible construction in case of grease fires.
•
At all times keep the ventilation openings of the cylinder enclosure free and clear from debris.
•
Do not locate in windy settings. High winds adversely affect the cooking performance of the gas grill.
•
When the gas grill is stored indoors, the Universal Liquefied Petroleum Gas cylinder must be
disconnected from the grill and stored outdoors in a well-ventilated area, disconnected cylinders must
not be stored in a building, garage or other enclosed area. Natural gas units must be disconnected from
the supply when being stored indoors.
•
Do not use or store flammable materials in or near this appliance.
•
Inspect the gas line hose before each use. If there is evidence of excessive abrasion or wear, it
must be replaced before using the gas grill, with a replacement hose assembly specified by the grill
manufacturer.
•
Never store a spare ULPG gas cylinder under or near this grill.
•
Never fill the cylinder beyond 80 % full.
•
Do not attempt to use a cylinder, which is not equipped with the appropriate connection.
•
Periodically check the test date on the ULPG gas cylinder to ensure it is within its service life
specification. If required, contact an approved testing facility or ULPG supplier for re-certification or
replacement.
•
Leak test all connections before initial use, even if the grill was purchased fully assembled, annually or
whenever any gas component has been replaced.
•
Never use natural gas in a unit designed for Universal Liquefied Petroleum Gas.
•
Never use lighter fluid in a gas grill.
•
Use charcoal briquettes only with a Napoleon charcoal tray designed for this unit.
•
Burner controls must be off when turning supply cylinder or natural gas supply valve on.
•
Do not light burners with lid closed.
•
Do not operate rear burner with main burners operating.
•
Do not place articles on or against this appliance.
•
The lid is to be closed during the pre-heat period.
•
Do not route hose underneath drip pan-proper hose clearance to bottom of unit must be maintained.
•
Clean grease tray and sear plates regularly to avoid build-up, which may lead to grease fires.
•
Remove warming rack before lighting rear burner. The extreme heat will damage the warming rack.
•
Ensure sear plates are positioned properly according to sear plate installation instructions.
•
Do not spray aerosols near this appliance while it is in operation.
•
Keep gas line away from heated surfaces
•
Keep any electrical supply cord away from water or heated surfaces.
•
Inspect infrared burner venturi tube for spider webs and other obstructions periodically. Clean the
tubes completely if you find any such obstructions.
N415-0580-AU REV - MAy 11.22
Failure to follow these instructions could result in property damage, personal injury or
3
www.napoleon.com
Advertisement
Table of Contents
