Table of Contents
Advertisement
Quick Links
This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a
building, garage, screened-in porch, gazebo or any other enclosed area.
!
DANGER
IF YOU SMELL GAS:
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
Adults and especially children should be alerted to the hazards of high surface temperatures.
Young children should be supervised near the gas grill.
Notice to Installer: Leave these instructions with the grill owner for future reference.
DO NOT REMOVE
N415-0574-AU REV A JUN 08.22
!
Do not try to light this appliance without
reading the "lighting" instructions section of
this manual.
Do not use or store gasoline or other
flammable liquids or vapors near this
appliance.
A ULPG cylinder not connected for use must
not be stored near this or any other appliance.
If the information in these instructions is
not followed exactly, a fire or explosion may
result, causing property damage, personal
injury or death.
Wolf Steel Ltd.
214 Bayview Drive,
Barrie, Ontario, CANADA L4N 4Y8
grills@napoleon.com
APPLY SERIAL NUMBER LABEL FROM CARTON
Serial No.
XXXXXX000000
MODEL NO.
DO NOT DISCARD
ROGUE 365-1
ROGUE 425-1
WARNING
IAPMO GMK10539
AS/NZS 5263.1.7
www.napoleon.com
EN
PG.18
Advertisement
Table of Contents
Related Manuals for Napoleon ROGUE 365-1
Summary of Contents for Napoleon ROGUE 365-1
- Page 1 APPLY SERIAL NUMBER LABEL FROM CARTON Serial No. XXXXXX000000 MODEL NO. PG.18 DO NOT DISCARD ROGUE 365-1 ROGUE 425-1 DANGER WARNING IF YOU SMELL GAS: Do not try to light this appliance without reading the “lighting” instructions section of •...
- Page 2 NAPOLEON. NAPOLEON warrants that components in your new NAPOLEON product will be free from defects in material and workmanship from the date of purchase, for the following period: Aluminum castings / stainless steel base ...........
-
Page 3: Safe Operating Practices
• Never use lighter fluid in a gas grill. • Use charcoal briquettes only with a Napoleon charcoal tray designed for this unit. • Burner controls must be off when turning supply cylinder or natural gas supply valve on. •... - Page 4 25% of total wall area total wall area In the case of balconies, at least 20% of the total of the side, back and front wall areas shall be and remain open and unrestricted. www.napoleon.com N415-0574-AU REV A JUN 08.22...
- Page 5 DIMENSIONS ORIFICE SIZES ULPG MAIN BURNER 1.15 mm 1.15 mm 1.79 mm SIDE BURNER (INFRARED) 1.07 mm SIDE BURNER (FLAME) 1.45 mm N415-0574-AU REV A JUN 08.22 www.napoleon.com...
- Page 6 DIMENSIONS ORIFICE SIZES ULPG MAIN BURNER 1.79 mm SIDE BURNER (INFRARED) 1.07 mm REAR BURNER 1.15 mm 1.15 mm 1.85 mm SIDE BURNER (FLAME) 1.45 mm www.napoleon.com N415-0574-AU REV A JUN 08.22...
-
Page 7: General Information
The screw within the pressure tap must always be kept tight, except when performing a pressure test on the regulator (qualified service personnel only). N415-0574-AU REV A JUN 08.22 www.napoleon.com... -
Page 8: Gas Hook-Up Instructions
Do not use tools. Leak test all joints prior to using the grill. A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. www.napoleon.com N415-0574-AU REV A JUN 08.22... -
Page 9: Leak Testing Instructions
Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Solutions department and have the grill inspected by a certified gas installer. STOP If the leak cannot be stopped, immediately shut off the gas supply, disconnect it, and have the grill inspected by a certified gas installer or dealer. -
Page 10: Lighting Instructions
5. If lighting the unit with a match, clip the match into the supplied lighting rod. Hold the lit match down through the grill and sear plate while turning the corresponding burner valve to high. www.napoleon.com N415-0574-AU REV A JUN 08.22... -
Page 11: Cooking Instructions
Should a flare-up occur, move food away from the flames and reduce the heat. Leave the lid open. See Your All Season Grill cookbook by Napoleon for more detailed instructions. Direct Cooking: Place food to be cooked on the grill directly over the heat. This method is generally used for searing or for foods that do not require prolonged cooking times such as hamburgers, steaks, chicken pieces, or vegetables. -
Page 12: Cleaning Instructions
Scrape the sear plates with a putty knife or scraper, and use a wire brush to remove the ash. Remove the sear plates and brush debris from the burners with the brass wire brush. Sweep all debris from inside the gas grill into the drip pan. www.napoleon.com N415-0574-AU REV A JUN 08.22... -
Page 13: Maintenance Instructions
Cleaning The Outer Grill Surface: Do not use abrasive cleaners or steel wool on any painted, porcelain or stainless steel parts of your Napoleon Grill. Doing so will scratch the finish. Exterior grill surfaces should be cleaned with warm soapy water while the metal is still warm to the touch. To clean stainless surfaces, use a stainless steel or a non-abrasive cleaner. - Page 14 CAUTION! Check for abrasions, melting, cuts, and cracks in the hose. If any of these conditions exist, do not use the gas grill. Have the part replaced by your Napoleon Grill dealer or qualified gas installer. Aluminum Castings: Clean castings periodically with warm soapy water. Aluminum will not rust, but high temperatures and weathering can cause oxidation to occur on aluminum surfaces.
-
Page 15: Troubleshooting
Humming regulators will not be replaced. Burners will not cross light Dirty or corroded cross light brackets. Clean or replace as required. each other. N415-0574-AU REV A JUN 08.22 www.napoleon.com... - Page 16 Ensure lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn tank on slowly to allow pressure to equalize. See lighting instructions. www.napoleon.com N415-0574-AU REV A JUN 08.22...
-
Page 17: Ordering Replacement Parts
3. A concise description of the problem (‘broken’ is not sufficient). 4. Proof of purchase (photocopy of the invoice). In some cases, Napoleon could request to have the parts returned to the factory for inspection before providing replacement parts. Before contacting Napoleon dealer, please note that the following items are not covered by the warranty: •... - Page 18 Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. WARNING! Clip hose to cart heat shield using bushing supplied. Failure to follow these instructions could result in property damage, personal injury or death. www.napoleon.com N415-0574-AU REV A JUN 08.22...
- Page 19 WARNING – FIRE HAZARD WARNING! Do not route hose underneath drip pan. WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. N415-0574-AU REV A JUN 08.22 www.napoleon.com...
- Page 20 Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Solutions department and have the grill inspected by a certified gas installer. STOP...
- Page 21 N105-0011 door bushings N010-0961 assembly lid - black N010-0874-BK assembly lid - black S91003 temperature gauge N385-0307-SER NAPOLEON logo N510-0013 black silicone lid bumper S87014 lid pivot hardware kit N010-1281-SER assembly control panel N415-0574-AU REV A JUN 08.22 www.napoleon.com...
- Page 22 S83015 cast cooking grid kit S83016 stainless cooking grid kit S83008 cast cooking grid kit S83013 stainless cooking grid kit x - standard p - propane units only ac - accessory sp -special edition www.napoleon.com N415-0574-AU REV A JUN 08.22...
- Page 23 28 28 29 29 33 33 31 31 30 30 N415-0574-AU REV A JUN 08.22 www.napoleon.com...
- Page 24 Napoleon products are protected by one or more U.S. and Canadian and/or foreign patents or patents pending. N415-0574-AU...