Table of Contents
Advertisement
Quick Links
This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a
building, garage, screened-in porch, gazebo or any other enclosed area.
!
DANGER
IF YOU SMELL GAS:
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
Adults and especially children should be alerted to the hazards of high surface temperatures.
Young children should be supervised near the gas grill.
Notice to Installer: Leave these instructions with the grill owner for future reference.
N415-0704-AU REV - MAy 11.22
!
Do not try to light this appliance without
reading the "lighting" instructions section of
this manual.
Do not use or store gasoline or other
flammable liquids or vapors near this
appliance.
A ULPG cylinder not connected for use must
not be stored near this or any other appliance.
If the information in these instructions is
not followed exactly, a fire or explosion may
result, causing property damage, personal
injury or death.
Wolf Steel Ltd.
214 Bayview Drive,
Barrie, Ontario, CANADA L4N 4y8
grills@napoleon.com
APPLY SERIAL NUMBER LABEL FROM CARTON
Serial No.
XXXXXX000000
MODEL NO.
DO NOT DISCARD
ROGUE-1
RSE425-SB/SIB
RSE525-SB/SIB
RSE625-SB/SIB
WARNING
IAPMO GMK10539
AS/NZS 5263.1.7
www.napoleon.com
EN
PG.20
Advertisement
Table of Contents
Related Manuals for Napoleon ROGUE-1
Summary of Contents for Napoleon ROGUE-1
- Page 1 APPLY SERIAL NUMBER LABEL FROM CARTON Serial No. XXXXXX000000 MODEL NO. PG.20 DO NOT DISCARD ROGUE-1 RSE425-SB/SIB RSE525-SB/SIB RSE625-SB/SIB DANGER WARNING IF YOU SMELL GAS: Do not try to light this appliance without reading the “lighting”...
- Page 2 NAPOLEON. NAPOLEON warrants that components in your new NAPOLEON product will be free from defects in material and workmanship from the date of purchase, for the following period: Aluminum castings / stainless steel base ...........
-
Page 3: Safe Operating Practices
• Never use lighter fluid in a gas grill. • Use charcoal briquettes only with a Napoleon charcoal tray designed for this unit. • Burner controls must be off when turning supply cylinder or natural gas supply valve on. •... - Page 4 25% of total wall area total wall area In the case of balconies, at least 20% of the total of the side, back and front wall areas shall be and remain open and unrestricted. www.napoleon.com N415-0704-AU REV - MAy 11.22...
- Page 5 DIMENSIONS ORIFICE SIZES ULPG MAIN BURNER 1.79 mm SIDE BURNER (INFRARED) 1.07 mm REAR BURNER 1.15 mm 1.15 mm 1.85 mm SIDE BURNER (FLAME) 1.45 mm N415-0704-AU REV - MAy 11.22 www.napoleon.com...
- Page 6 DIMENSIONS ORIFICE SIZES ULPG MAIN BURNER 1.65 mm SIDE BURNER (INFRARED) 1.07 mm REAR BURNER 1.15 mm 1.15 mm 1.85 mm SIDE BURNER (FLAME) 1.45 mm www.napoleon.com N415-0704-AU REV - MAy 11.22...
- Page 7 DIMENSIONS ORIFICE SIZES ULPG MAIN BURNER 1.65 mm SIDE BURNER (INFRARED) 1.07 mm REAR BURNER 1.15 mm 1.15 mm 1.85 mm SIDE BURNER (FLAME) 1.45 mm N415-0704-AU REV - MAy 11.22 www.napoleon.com...
-
Page 8: General Information
The screw within the pressure tap must always be kept tight, except when performing a pressure test on the regulator (qualified service personnel only). www.napoleon.com N415-0704-AU REV - MAy 11.22... - Page 9 A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. Do not use an adaptor at the cylinder connection. N415-0704-AU REV - MAy 11.22 www.napoleon.com...
-
Page 10: Leak Testing Instructions
Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Solutions department and have the grill inspected by a certified gas installer. STOP If the leak cannot be stopped, immediately shut off the gas supply, disconnect it, and have the grill inspected by a certified gas installer or dealer. -
Page 11: Lighting Instructions
Hold the lit match down through minutes. Repeat. extinguished before closing side the grill and sear plate while turning the burner lid corresponding burner valve to high. NOTE! Do not use rear burner while operating main burner. N415-0704-AU REV - MAy 11.22 www.napoleon.com... -
Page 12: Cooking Instructions
Should a flare-up occur, move food away from the flames and reduce the heat. Leave the lid open. See Your All Season Grill cookbook by Napoleon for more detailed instructions. Direct Cooking: Place food to be cooked on the grill directly over the heat. This method is generally used for searing or for foods that do not require prolonged cooking times such as hamburgers, steaks, chicken pieces, or vegetables. - Page 13 Any juices or oils that escape from the food drip onto the charcoal and vaporize into smoke giving the food its delicious grilled taste. The Napoleon infrared burner cooks in the same way. In each burner, 10,000 ports – each with its own tiny flame – cause the surface of the ceramic tile to glow red.
- Page 14 To add an 6 min. – Well done exotic taste to your meat, High setting 3 min. each side. try adding hickory-flavored woodchips to Napoleon’s woodchip smoker. Chicken pieces High setting 2 min. each side. 20-25 min. The joint connecting the...
-
Page 15: Cleaning Instructions
Scrape the sear plates with a putty knife or scraper, and use a wire brush to remove the ash. Remove the sear plates and brush debris from the burners with the brass wire brush. Sweep all debris from inside the gas grill into the drip pan. N415-0704-AU REV - MAy 11.22 www.napoleon.com... -
Page 16: Maintenance Instructions
Cleaning The Outer Grill Surface: Do not use abrasive cleaners or steel wool on any painted, porcelain or stainless steel parts of your Napoleon Grill. Doing so will scratch the finish. Exterior grill surfaces should be cleaned with warm soapy water while the metal is still warm to the touch. To clean stainless surfaces, use a stainless steel or a non-abrasive cleaner. - Page 17 CAUTION! Check for abrasions, melting, cuts, and cracks in the hose. If any of these conditions exist, do not use the gas grill. Have the part replaced by your Napoleon Grill dealer or qualified gas installer. Aluminum Castings: Clean castings periodically with warm soapy water. Aluminum will not rust, but high temperatures and weathering can cause oxidation to occur on aluminum surfaces.
-
Page 18: Troubleshooting
Cracked ceramic tile. Allow burner to cool and inspect very closely for cracks. If any cracks are found, contact your authorized Napoleon dealer to order a replacement burner assembly. Leaking gasket surrounding the Contact your authorized Napoleon dealer for... -
Page 19: Ordering Replacement Parts
3. A concise description of the problem (‘broken’ is not sufficient). 4. Proof of purchase (photocopy of the invoice). In some cases, Napoleon could request to have the parts returned to the factory for inspection before providing replacement parts. Before contacting Napoleon dealer, please note that the following items are not covered by the warranty: •... - Page 20 Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. WARNING! Clip hose to cart heat shield using bushing supplied. Failure to follow these instructions could result in property damage, personal injury or death. www.napoleon.com N415-0704-AU REV - MAy 11.22...
- Page 21 WARNING – FIRE HAZARD WARNING! Do not route hose underneath drip pan. WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. N415-0704-AU REV - MAy 11.22 www.napoleon.com...
- Page 22 Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Solutions department and have the grill inspected by a certified gas installer. STOP...
- Page 23 N010-1601 manifold assembly N380-0039 large knob N520-0050 warming rack N520-0049 warming rack N520-0048 warming rack N510-0015 caster plug N010-1149-SER base assembly N010-1150-SER base assembly N010-1235-SER base assembly N305-0096 stainless steel main cooking grid N415-0704-AU REV - MAy 11.22 www.napoleon.com...
- Page 24 N570-0118 1/4-20 x 3/8” screw N735-0027 washer 1/2” N555-0097 lighting rod S82001 caster N080-0380-Gy1SG door magnet bracket N010-0869-M02-SER stainless steel door assembly N010-0984-M02-SER stainless steel door assembly N010-1221-M02-SER stainless steel door assembly www.napoleon.com N415-0704-AU REV - MAy 11.22...
- Page 25 Z580-0003 lid pivot rod N555-0091 lid pivot rod Z335-0007 side burner lid N335-0098-M02 side burner lid Z325-0013 side burner lid handle Z305-0008 side burner grate S83010 side burner grate Z100-0002 side burner N415-0704-AU REV - MAy 11.22 www.napoleon.com...
- Page 26 S83024 cast iron cooking grids S83022 stainless steel cooking grids S83021 cast iron cooking grids x - standard p - propane units only n- natural gas units only ac - accessory sp -special edition www.napoleon.com N415-0704-AU REV - MAy 11.22...
- Page 27 N415-0704-AU REV - MAy 11.22 www.napoleon.com...
- Page 28 Napoleon products are protected by one or more U.S. and Canadian and/or foreign patents or patents pending. N415-0704-AU www.napoleon.com...