Page 1
IMPORTANT! It is extremely important to read and understand the entire contents of this Owner’s Manual for the Titan Model TG 7250ES before attempting to operate the generator. This is a gas engine powered, industrial strength generating unit of electrical power. The gas engine and the generator are both potentially extremely hazardous and could cause physical in- jury or even death if improperly used.
It is extremely important to read and understand the entire contents of this Owner’s Manual for the Titan Model 7250ES before attempting to operate the generator. This is a gas engine powered, industrial strength generating unit of electrical power. The gas engine and the generator are both potentially extremely hazardous and could cause physical injury or even death if improperly used.
Page 3
CONNECTING LOADS Add up the Watts of all devices you connect to the Titan Generator at one time. Do not exceed 6000 Watts on Titan Generator Model TG 7250ES (see wattage refer- ence guide). MODEL TG 7250ES The rated Watts of most electrical devices can be found on its nameplate.
Page 4
SAFETY This generator was designed for specific applications. DO NOT attempt to modify the unit in any way or use it for any application that it was not designed to do. Ask the dealer or contact the factory if you have any questions concerning the generator’s application.
OPERATION OF THE GENERATOR Starting the engine Stopping the engine 1. Check oil and fuel levels Turn off all electrical devices connected to the generator. 2. Turn fuel valve to the “ON” position WARNING: 3. Put choke lever in the “ON” position DO NOT start or stop generator with electri- cal devices plugged in.
Page 7
240 Volt. L14-30 120 Volt. Recep- Breaker Ignition Switch Receptacle tacle P.O.Box 791, Travelers Rest, S.C. 29690 Phone 864-834-7212 Service/Replacement Parts 800-845-4141...
TROUBLESHOOTING Problem Cause Solution 1. Reset the circuit breaker. Engine is running but no 1. Circuit breaker is open. 2. Check & repair. 2. Poor connection or defective power output is available. 3. Connect another device cord set. that is in good condition. 3.
1. Engine Block Assembly Part Name Titan Part # Titan Part # Part Name 125- Rings TI 12-14 163-Oil Drain Plug Washer TI 12-24 126- Piston Pin Clip TI 12-14 165-Main Seal TI 12-27 TI 12-14 127- Piston 166-Governor Arm...
2. Governor Assembly Part Name Titan Part # 147- Main Bearing TI 12-33 149- Governor Gear Assembly TI 12-09 150- Balancer Shaft Bearing TI 12-32 151- Crank Case Gasket TI 12-08 152- Guide Pins Some Parts Sold As Assemblies...
3. Starter Assembly Part Name Titan Part # TI 12-21 170- Ground Wire 171- Bolt TI 12-21 172- Ignition Coil TI 12-34 183- Fly Wheel TI 12-34 184- Fly Wheel Fan TI 12-27 185- Recoil Cup TI 12-34A 186- Nut...
Page 19
4. Carburator Part Name Titan Part # TI 12-02B 131- Gasket TI 12-35 132- Vaccum Spacer TI 12-02B 133- Gasket 134- Vaccum Line Clamp 135- Vaccum Line TI 12-02B 140- Gasket TI 12-02 209- Carburator Assembly Some Parts Sold As Assembly...
5. Choke Assembly Part Name Titan Part # 134- Vaccum Line Clamp 137- Vaccum Line 138- Vaccum Line Holder 139- Check Valve TI 12-02A 140- Gasket TI 12-02B 210- Choke Assembly TI 12-02A Some Parts Sold As Assemblies...
6. Head Assembly Titan Part # Part Name Part Name Titan Part # 97- Valve Cover Bolt 112- Rocker Adjustment TI 12-13 TI 12-12A 98- Washer 113- Rocker Arm TI 12-13A TI 12-12A 99- Valve Cover 114-Rocker Arm Stud TI 12-13A...
Page 22
7. Governor Arm Assembly Part Name Titan Part # 177- Governor Spring TI 12-10 178- Governor Rod TI 12-10 179- Throttle Return Spring TI 12-10 180- Nut 181- Bolt 182- Governor Arm TI 12-10 Some Parts Sold As Assemblies...