Advertisement
Quick Links
Advertisement
Related Manuals for Summerset SIZZLER
Summary of Contents for Summerset SIZZLER
- Page 1 SI DE BU R NER M A N U A L...
-
Page 2: Table Of Contents
SIDE BURNERS Safety Warnings & Codes ........01 Safety & Installation Instructions ......04 ........07 Gas Safety Requirements ........10 Cleaning & Maintenance Operating Instructions ........... 11 Parts List & Line Drawing.........14 Warranty ...............22... - Page 3 Liquid propane & natural gas configurations available THANK YOU Thank you for your purchase. We’d like to welcome you to the Summerset family of luxury outdoor kitchen products and look forward to being a part your home for years to come. As a family business with over 30 years of industry experience, we aim to deliver exceptional quality and personal service.
-
Page 4: Safety Warnings & Codes
Safety Warnings & Codes... - Page 5 IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION WARNING! WARNING! Improper installation, adjustment, IF YOU SMELL GAS alteration, service, maintenance Shut off the gas to the appliance. cause injury or property damage. Extinguish any open flame. assistance additional Open lid to vent. information consult qualified...
- Page 6 Do not repair or replace any part of the Side Burner unless specifically recommended by this manual. A qualified technician should perform all other necessary service. • Summerset Side Burners are not designed/certified for and cannot be installed in or on recreational vehicles, portable trailers, boats or any other mobile vehicle. •...
-
Page 7: Safety & Installation Instructions
Safety & Installation Instructions... - Page 8 SHIPMENT ARRIVING DAMAGED: CONSTRUCTION ZONES Keep all stainless steel products away from VISIBLE DAMAGE construction zones. Construction debris such as If your shipment arrives with visible damage to (but not limited to) stone dust, stucco, and lime the box/carton, be sure the damage is noted on dust could damage or permanently discolor the bill of freight or express receipt and signed stainless steel products.
- Page 9 EN SURIN G PROPER COMBUSTION AIR AND MINIMUM PRESSURE REQUIREMENTS COOLING AIR FLOW Ensure the gas supplied meets the minimum You must maintain proper air flow for your pressure requirements. See below table for gas Side Burner to perform as it was designed requirements measured in water column (w.c.) (diagram below).
-
Page 10: Gas Safety Requirements
Gas Safety Requirements... - Page 11 sealants that are approved for use with natural WARNING! and LP gases. An installer-supplied gas shutoff valve must be installed in an accessible location. (Reference: leak test procedure). CHECK TO ENSURE THAT THE GAS SUPPLY HOSE DOES NOT COME IN CONTACT Although LP Gas Cylinders may be used, it is WITH ANY HOT SURFACE OF THE SIDE not recommended due to the large amount of...
- Page 12 Do not use any replacement regulator other not have any cuts and wear that may affect the than that specified by Summerset. Use only pipe safety before each use. Only the factory supplied sealants that are approved for use with NG and regulator must be used.
-
Page 13: Cleaning & Maintenance
Cleaning & Maintenance... -
Page 14: Operating Instructions
NOTE: Be extra careful when cleaning around the highlights. Metal polisher or mild chrome cleaner It is recommended to build the Side Burner at can be used to bring back the luster on highlights. least 6”-12” lower than the counter-top. To touch-up minor scratches in the stainless steel, sand the affected surface very lightly, with 100-dry SPIDER AND INSECT WARNING... - Page 15 Inspect the gas supply piping or hose prior to Important: If burner fails to light within 5 seconds, turning the gas ON. If there is evidence of cuts, turn off gas and wait 5 minutes before repeating wear, or abrasion, it must be replaced prior to the process.
- Page 16 LIQUID PROPANE INSTALLATION A dented or rusty LP cylinder may be hazardous and should be avoided. If in doubt, have it NOTE: Ventilation required checked by your LP supplier. Always check for leaks the enclosure opposite sides after every LP cylinder change. (See Checking For create cross-ventilation.
-
Page 17: Parts List & Line Drawing
Side Burner Parts List & Line Drawings... - Page 18 SINGLE SIDE BURNER PARTS LIST & LINE DRAWING LID HANDLE GRATE BURNER KNOB IGNITER KNOB BEZEL IGNITER WIRE VALVE ORIFICE BURNER BASE LID HINGE PIN FLEX TUBE BODY...
- Page 19 SIZZLER DOUBLE SIDE BURNER PARTS LIST & LINE DRAWING LID HANDLE GRATE IGNITER WIRE 480mm IGNITER FLEX TUBE 400mm IGNITER WIRE BURNER 330mm FLEX TUBE 200mm ORIFICE BURNER BASE BURNER PLATE BODY VALVE MANIFOLD FRONT PANEL VALVE LATCH DRIP TRAY...
- Page 20 SIZZLER PRO DOUBLE SIDE BURNER PARTS LIST & LINE DRAWING LID HANDLE GRATE IGNITER WIRE SHORT IGNITER FLEX TUBE IGNITER WIRE LONG BURNER LONG FLEX TUBE ORIFICE SHORT BURNER BASE BURNER PLATE BODY VALVE LED WIRE MANIFOLD FRONT PANEL TRANSFORMER...
- Page 21 TRL DOUBLE SIDE BURNER LID HANDLE PARTS LIST & LINE DRAWING GRATE IGNITER BURNER FLEX TUBE 400mm ORIFICE FLEX TUBE BURNER BASE 200mm LED LIGHT WIRE BODY LED LIGHT BASE T-FITTING VALVE FRONT PANEL RUBBER HOSE KNOB BEZELS VALVE LATCH KNOBS MANIFOLD 10 7/8"...
- Page 22 LID HANDLE TRL SEAR SIDE BURNER PARTS LIST & LINE DRAWING GRATE BODY IR BURNER ORIFICE BRASS NUT ORIFICE ORIFICE IGNITER PIN MOUNTING RIGHT PLATE ANGLE FRONT PANEL IGNITER WIRE IGNITER BUTTON BRASS INLET FITTING FLEX TUBE SHORT FLEX TUBE LONG KNOB KNOB BEZEL VALVE...
- Page 23 ALTURI DOUBLE SIDE BURNER PARTS LIST & LINE DRAWING IGNITER WIRE - SHORT GRATE IGNITER WIRE - LONG BURNERS FLEX LINE - LONG FLEX LINE - SHORT IGNITER PINS ORIFICES LED WIRE LED LIGHT BULBS BODY BULL NOSE LED SWITCH FLEX LINE &...
- Page 24 ALTURI SEAR SIDE BURNER PARTS LIST & LINE DRAWING GRATE IR BURNER FLASH TUBE BODY WIRE PROTECTIVE SLEEVE LED LIGHT BASE LED PLUG & WIRING BULL NOSE VALVE FLEX LINE BRACKET MANIFOLD FRONT PANEL FLEX LINE & FITTING 650mm VALVE LATCH KNOB BEZEL KNOB DRIP TRAY...
-
Page 25: Warranty
G O L D S T A N D A R D LIFETIME WARRANTY AMD DIRECT GAS APPLIANCES GOLD STANDARD GRILLS, SIDE/POWER BURNERS, & OVEN WARRANTY • Gold Standard Lifetime Warranty on construction and manufacturer defects • Gold Standard Lifetime Warranty on stainless steel construction •... - Page 26 14520 Delta Ln Suite 105 Huntington Beach, CA 92647 ( 800 ) 966-8126 AMDDIRECT.COM VER. 122122...
Need help?
Do you have a question about the SIZZLER and is the answer not in the manual?
Questions and answers