Qualifier series 1:8 scale electric monster truck (30 pages)
Summary of Contents for Associated Electrics Enduro Ecto Trail Truck ASC40117C
Page 2
Enduro Ecto more reliable and responsive steering without the fl ex. Our shock mount inserts TEAM ASSOCIATED is a Registered Trademark of Associated Electrics, Inc. with multiple mounting positions allow for precise suspension tuning, whether they’re moving the shocks up, down, REEDY is a Registered Trademark of Associated Electrics, Inc.
Page 3
33.664760, -117.676533 HARDWARE 1:1 SCALE VIEW HARDWARE USED WITH OPTIONAL REPLACEMENT PART NUMBERS FLAT HEAD SCREWS (FHCS) BUTTON HEAD SCREWS (BHCS) SHIMS AND WASHERS 2.5x10mm (41088) 2.5x10mm (31350) 3x7mmx1mm (42260) 3x5mm (31530) 2.5x14mm (41077) 3x7mmx2mm (42260) 3x6mm (31531) 3x8mm (25201) Titanium (91580) 3x7x3mm (42260) 3x10mm (25202)
Page 5
YOUR BUILD BEGINS HERE. GATE 01 CHASSIS BUILD: BAGS 1, 2 25201 31532 Front Back 42255 3x8mm, 3x8mm, FHCS BHCS Panhard 42254 Plate 31532 31532 3x8mm 3x10mm 3x16mm Panhard 3x8mm, BHCS BHCS BHCS 91477 Mount BHCS 31532 M3 Nuts, 3x8mm, 25211 Black BHCS...
Page 6
GATE 01 ELECTRONIC MOUNTS BUILD: BAG 3 71050 25203 Hook and 3x12mm Loop Straps FHCS 42003 Battery Box, Shorty Pack GATE 02 ELECTRONIC MOUNTS BUILD: BAG 3 25225 41090 3x3mm 3x10mm 6338 Set Screw LP SHCS Antenna Tube and Cap Servo Receiver 25211...
Page 7
33.664760, -117.676533 GATE 02 GEARBOX BUILD: BAG 4 42026 NOTE: There are optional 41078 42025 gearbox builds on page 28 Stealth X Idler 3x28mm Idler Shaft Pin Gear, 28T BHCS 2x9mm 42030 42025 Stealth X Gearbox Stealth X Gearbox Top Shaft, Rear Idler Shaft 91560 5x10x4mm...
Page 8
GATE 01 FRONT AXLE BUILD: BAG 5 41086 2.5x16mm SHCS 91560 5x10x4mm Bearing 91560 5x10x4mm Bearing 91474 7x14x3.5mm Bearing 42062 Caster Block, Left 42061 42066 Axle Housing, Pinion Gear, Front NOTE: Align the two NOTE: Install Left and 42060 42065 arrows when installing right side caster blocks Axle Housing...
Page 9
33.664760, -117.676533 GATE 02 REAR AXLE BUILD: BAG 6 71032 2.5x14mm SHCS 42019 Wheel Hex Pin, 2x11mm 42068 Driveshaft, 42069 Rear, 80mm Wheel Hex, 91560 5x10x4mm 42060 Bearing Lower 4-Link Mount 41089 3x6mm NOTE: Install left and NOTE: Install left and right side LP SHCS right side drive shafts axle mounts and wheel hexes...
Page 10
GATE 03 LINKS BUILD: BAG 7 41078 3x28mm, BHCS 42040 Rod End, Curved 42043 25188 Link, 3x20mm, 3x20mm, 93mm BHCS 42041 NOTE: Check the rod end Pivot Ball, angles before installation 122.00mm 42054 25215 FT Pivot Ball, M3 Locknut, Steel, 6mm Black GATE 04 LINKS BUILD: BAG 7...
Page 11
33.664760, -117.676533 GATE 06 LINKS BUILD: BAG 7 89233 3x24mm FHCS 42043 Link, 42041 73mm Pivot Ball, 42040 Rod End, Curved NOTE: Build and install two rear upper links NOTE: Check the rod end angles before installation 102.20mm 25215 42260 M3 Locknut, Spacer Black...
Page 12
GATE 09 LINKS BUILD: BAG 7 42253 Bumper Mount, 25187 89202 Rear 3x14mm, 3x12mm 89202 BHCS BHCS 3x12mm BHCS 25215 M3 Locknut, Black GATE 10 LINKS BUILD: BAG 7 42250 NOTE: Build and install two Trailing Arm, rear trailing arms. Note the Right orientation 42250...
Page 13
33.664760, -117.676533 GATE 02 DRIVESHAFT BUILD: BAG 8 NOTE: Make sure the screw NOTE: Make sure the phasing of the drive shafts is correct when installing pins are aligned with each them to the axles and gearbox. Correct Phasing female CVA during assembly Incorrect Phasing FRONT REAR...
Page 14
GATE 02 SHOCK BUILD: BAG 9 Shock Bleeding Steps: NOTE: Build 4 Pull shock shaft down. complete shocks Fill shock body 3/4 full with shock fluid. Slowly move the shock shaft up and down to remove air from under piston. 42080 Wait for bubbles to come to surface.
Page 15
33.664760, -117.676533 GATE 01 CAGE BUILD: BAG 10 42270 89233 Body Post, 42162 3x24mm Rear Winch FHCS Motor 42162 Winch Base 42162 Bumper 42162 Winch Cap 25211 42162 3x10mm Fairlead BHCS 42162 89210 89222 Winch 25188 Spool 2.5x8mm 3x20mm 3x20mm FHCS SHCS BHCS...
Page 16
GATE 04 CAGE BUILD: BAG 10 6332 Body Clip 41089 3x6mm LP SHCS Chassis 42260 4689 M3x16mm Set Screw 4689 6338 Antenna Tube and Cap 42251 25188 M3x20mm BHCS 25189 M3x22mm BHCS 25201 M3x8mm FHCS 42004 25211 M3x10mm BHCS 25215 M3 Locknuts 42002 42002...
Page 17
33.664760, -117.676533 Shocks 5407 O-Rings, Red, Silicone 6299 E-Clipp, 1/8” 31392 3x5x0.3mm Washer 42040 Enduro Rod Ends 42041 Enduro Pivot Balls Set - KIT 42054 FT Enduro Pivot Ball, Steel 42080 42055 FT Enduro, Shock Bushing, Steel 42056 6299 FT Enduro Pivot Ball Set, Steel, Set (28) 42081 42079 Enduro Shock Parts, Black Aluminum...
33.664760, -117.676533 Wheel/Tire 25391 FT M4 Locknuts, Blue 41088 M2.6x10mm 42106 42109 42100 Enduro Method 701 Trail Series Wheel, 1.9” Bronze 42101 Enduro Method 701 Trail Series Wheel, 42109 42106 1.9” Black 42102 FT Enduro Beadlock Rings, Brass 42103 FT Enduro Beadlock Hex Adapter, Aluminum 42104 FT Enduro Beadlock Hex Adapter, Brass 42105...
Page 22
REEDY BATTERIES / CHARGERS XP / AE ELECTRONICS BATTERIES 29204 AE XP-R4 2.4GHz 4CH Receiver AA Alkaline 1.5V (4) AE XP130 2.4GHz 3CH Radio System Wolfpack LiPo 3000mAh 30C 7.4V w/T-Plug 29262 ESS-One+ 2017 Engine Sound System Wolfpack LiPo 3000mAh 30C 11.1V w/T-Plug 29263 ESS-Dual+ Engine Sound System 27313...
Page 23
33.664760, -117.676533 APPAREL / PROMOTIONAL TOOLS TEE SHIRTS 1111 FT Turnbuckle Wrench SP124* AE 2017 Worlds Tee, Black (S, M, L, XL-5XL) 1112 FT 4mm Turnbuckle Wrench SP126* 1114 Team Associated Tri T-Shirt, Black (S, M, L, XL-5XL) FT Dual Turnbuckle Wrench SP140* Reedy Heritage Tee, Black (S, M, L, XL-5XL) 1449...
Page 24
GATE 01 STEALTH X: BUILD CONFIGURATION: MOTOR MOUNT FACING REAR (STOCK) OVERDRIVE: Overdrive is a scenario where the front and rear wheels do not rotate at the same speed. The Stealth X gearbox is designed to allow the front wheels to spin faster than the rear wheels. Overdrive is advantageouse when climbing up rock faces because the front tires will want to pull the vehicle up the rock.
Page 25
33.664760, -117.676533 TRAIL TIPS AND CHECKLIST PREPARING TO HIT THE TRAIL: When preparing to hit the trail, it’s a good idea to have a checklist to make sure you have everything and don’t end up having to head back early. We’ve compiled a checklist of the things we think you’ll need on the trail. We’ve also left some space for you to add your specifi...
Need help?
Do you have a question about the Enduro Ecto Trail Truck ASC40117C and is the answer not in the manual?
Questions and answers