Advertisement
Quick Links
608
-IMPORTANT NOTICE -
RESIDENTIAL HOME USE ONLY. Not intended for public areas
such as schools, churches, nurseries, day cares or parks
Parts missing or damaged?
Need assistance with assembly?
Contact Us First!
Please send your request to our central
customer service email: welcome@petitseal.com
One of our customer service agents will reply to
you within 24 hours
Advertisement
Related Manuals for Petit SEAL 2006
Summary of Contents for Petit SEAL 2006
- Page 1 -IMPORTANT NOTICE - RESIDENTIAL HOME USE ONLY. Not intended for public areas such as schools, churches, nurseries, day cares or parks Parts missing or damaged? Need assistance with assembly? Contact Us First! Please send your request to our central customer service email: welcome@petitseal.com One of our customer service agents will reply to you within 24 hours...
-
Page 2: Assembly And Installation Instructions
REV: 6-27-2022 Monkey Bar Assembly and Installation Instructions Intended for children from ages 3 to 10 Model: 2006 WARNING: ASSEMBLY BY AN ADULT RETAIN (BOXES: 1008) THESE INSTRUCTIONS Swiss Walterli Kft. Petit Seal Simonffy utca 4-6, fszt. 41. Do not use this playset... -
Page 3: Warnings And Safe Play Instructions
Warnings and Safe Play Instructions CONTINUOUS ADULT SUPERVISION REQUIRED. Most serious injuries and deaths on playground equipment have occurred while children were unsupervised! Our products are designed to meet mandatory and voluntary safety standards. Complying with all warnings and recommendations in these instructions will reduce the risk of serious or fatal injury to children using this play system. -
Page 4: Instructions For Proper Maintenance
Instructions for Proper Maintenance Your Petit Seal Playset is designed and constructed of quality materials with your child's safety in mind. As with all outdoor products used by children, it will weather and wear. To maximize the enjoyment, safety and life of your Play Set, it is important that you, the owner, properly maintain it. - Page 5 Playground Surfacing Materials Section 4 of the consumer product safety commission’s outdoor home playground safety handbook Select Protective Surfacing One of the most important things you can do to reduce the likelihood of serious head injuries is to install shock-protective surfacing under and around your play equipment.
-
Page 6: Assembly Information
Assembly Information Tools Required Robertson Drive Tape Measure Open End Wrench 8’ (2.4m) Step Ladder Carpenters Level (Included) 7/16" (11mm) & 1/2" (13mm) Safety Glasses Ratchet with extension Carpenters Square Adjustable Wrench Adult Helpers Claw Hammer Drill Bits (up to 3/8” (10mm) 7/16"... - Page 7 About our wood Petit Seal Play Systems uses only premium playset lumber, ensuring the safest product for your children’s use. Although we take great care in selecting the best quality lumber available, wood is still a product of nature and susceptible to weathering which can change the appearance of your set.
- Page 8 OCCUPANTS / WEIGHT LIMITS / TOTAL WEIGHT / FALL HEIGHT Petit Seal recommends that the weight limits for all components must not be exceeded. Failure to adhere to these and other safety guidelines could result in damage to the playset and/or serious injury.
- Page 9 Refer to the following pages for the Safety Use Zones with Monkey Bars for your playset. Refer to the playset instructions for the Playset Specifications. 24.75" [62.87] 60.00" [152.40] 42.46" [107.86] 74.75" [189.86] 32.28" [82.00] Ground Monkey Bars Specifications Units: Inches/Centimeters 29'-10"...
- Page 10 24'-2" [7.35] 6' [1.83] Monkey Bars 13'-5" [4.09] Swing Safety Zone [1.83] 30'-6" [9.31] [1.83] 12'-9" [3.89] Swing Safety Zone 24'-2" [7.35] 6' [1.83] 13'-5" [4.10] Swing Safety Zone [1.83] [1.83] 26'-6" [8.09] Monkey Bars 12'-9" [3.89] Swing Safety Zone Units: Feet/Meters Swing Set Deluxe with Monkey Bars Safety Use Zone...
- Page 11 21'-1" [6.43] 6' [1.83] 9' [2.75] Monkey Bars [1.83] 6' [1.83] 29' [8.84] 1'-1" [0.32] 13' [3.95] 2'-3" [0.69] 3'-8" [1.13] 6' [1.83] Units: Feet/Meters Swing Set Deluxe with Monkey Bars Safety Use Zone The minimum Safety Use Zone extends no less than 6' [1.83] from all sides of the play structure.
- Page 12 29'-7" [9.02] 6' [1.83] 9' [2.75] Monkey Bars 13'-5" [4.10] Swing Safety Zone 6' [1.83] [3.95] 30'-6" 6' [1.83] 1'-1" [9.31] [0.32] 2'-3" [0.69] 3'-8" [1.13] 12'-9" [3.89] Swing Safety Zone 6' [1.83] Units: Feet/Meters Swing Set Deluxe with Monkey Bars Safety Use Zone The minimum Safety Use Zone extends no less than 6' [1.83] from all sides of the play structure.
- Page 13 WOOD INDENTIFICATION...
- Page 14 MONKEY BAR HARDWARE LISTING (Fasteners are shown full size)
- Page 15 TOP RAILS Note - (1) Hole at these ends Orient rails with pre-drilled holes opposite each other. Locate all rungs on the pre-drilled holes with the RUNG FLAT SIDE AGAINST RAILS #12 x 2.00 Pan Head Screw Flat Washer Maintain width measurement shown at BOTH ends then attach rungs as shown.
- Page 16 UP RAILS Angle Part 233 flush to rails Angle #8 x 2.50 Wood Screw X4 Angle Same Angle Maintain width measurement shown at ends (approximately 22.00 [55.9]) BOTH then attach Part 234 as shown. 22.00 [55.9] 3.00 [7.6] Inside 3 - Spaces Flush to Step 233 Begin here 22.00 [55.9]...
- Page 17 ASSEMBLE MONKEY BARS ⁵⁄₁₆ x 1.50 Hex Bolt X2 ⁵⁄₁₆ Lock Washer X2 ⁵⁄₁₆ Flat Washer X2 ⁵⁄₁₆ T-Nut X2 on this side ⁵⁄₁₆ T-Nut X2 ⁵⁄₁₆ x 2.50 Hex Bolt X2 on this side ⁵⁄₁₆ Lock Washer X2 ⁵⁄₁₆ Flat Washer X2 Angle Bolt thru this hole in plate...
- Page 18 ATTACH TO PLAYSET Notes: 1. The attachment method shown is the same for these playsets: Play Deck XXL Swing Set Deluxe + Play Deck Refer to the pages showing attachment to these playsets. Step 1 - Locate rail assembly flush to playset rail to measurement shown.
- Page 19 ATTACH TO SWING SET DELUXE Notes: 1. The Monkey Bars can safely be installed at the locations shown. 2. Do not install the Monkey Bars in the locations noted NO MB's. 3. The wall under the Monkey Bars attach to must be closed to prevent access to the deck.
- Page 20 ATTACH TO PLAY DECK XXL Notes: The Monkey Bars can safely be installed at the locations shown. 2. Do not install the Monkey Bars in the locations noted NO MB's. The wall under the Monkey Bars attach to must be closed to prevent access to the deck.
- Page 21 ATTACH TO SWING SET DELUXE LADDER THE MONKEY BAR INSTALLATION IS THE SAME AT THE LADDER AND SLIDE LOCATIONS AS SHOWN. ROOF OUTLINE SLIDE Locate rail assembly against playset upright and flush to playset rail and install beginning at Step 6 Flush Flush Flush...
- Page 22 ATTACH TO SWING SET DELUXE TABLE THE SWING SET DELUXE TABLE MUST BE INSTALLED TO THE INSIDE OF THE FORT AS SHOWN FOR SAFETY UNDERNEATH THE MONKEY BARS ROOF OUTLINE #8 x 2.50 Wood Screw X4 Part 136 X2 Flush 21.00 [53.3] Two Places Flush to top and ends of 136...
- Page 23 ATTACH TO SWING SET DELUXE TABLE THE SWING SET DELUXE TABLE MUST BE INSTALLED TO THE INSIDE OF THE FORT AS SHOWN FOR SAFETY UNDERNEATH THE MONKEY BARS ROOF OUTLINE #8 x 1.75 Wood Screw X13 in all table top holes Part 137 Flush to edge REFER TO YOUR SWING SET DELUXE INSTRUCTIONS FOR ATTACHING...
- Page 24 ATTACH TO SWING SET DELUXE TABLE THE SWING SET DELUXE TABLE MUST BE INSTALLED TO THE INSIDE OF THE FORT AS SHOWN FOR SAFETY UNDERNEATH THE MONKEY BARS ROOF OUTLINE Flush 5.50 [13.9] Flush Locate rail assembly flush to playset rail and to measurement shown and install beginning at Step 6.
- Page 25 ATTACH TO PLAY DECK XXL UPRIGHTS LADDER ROCKWALL Locate rail assembly flush to playset rail and centered as shown and install beginning at Step 6. 3.00 [7.6] Between 111 3.00 [7.6] Between 111 Center MB's between uprights (Part 100) Flush Center 111 between the attached (2) 111's Flush...
- Page 26 ANCHOR MONKEY BARS The Monkey Bars are required to be anchored after installed on the playset Attach on underside #12 x 2.00 Pan Head Screw X2 Pre-drill hole using an "drill bit x 1.50" deep Parts Required: 1. Anchor as shown after attaching Monkey Bars to the Playset 309 Anchor X2...
-
Page 27: Warranty
Excludes all, surface cracks, knotholes and knots in the wood components. A note about wood: The wooden components in your Swiss Walterli's (dba. PETIT SEAL) swing set will have natural imperfections such as surface cracks, knots and knot holes. These are natural characteristics of wood. Natural imperfections such as these that do not affect structural integrity are expressly excluded from Warrant.