Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for EB A-038105-03
- Page 1 REV 1.0/3.23 ® GEN2 LITHIUM BATTERY USER MANUAL MODELS COVERED: A-038105-03 38V 105Ah 51V 72Ah A-051072-03 51V 105Ah A-051105-01 51V 105Ah A-051105-03 70V 105Ah A-070105-06 51V 160Ah A-051160-06 WWW.ECOBATTERY.COM 877.ECO.BATT WWW.ECOBATTERY.COM...
-
Page 2: Battery Components
BATTERY COMPONENTS Lifting Handles Power Button Positive Negative Terminal Terminal COM Port Connectors Meter / CAN Cable State of Charge Meter User Manual - 2nd Gen Batteries... -
Page 3: State Of Charge Meter
STATE OF CHARGE METER (SOC Meter) Eco Battery Gen2 batteries are only compatible with Gen2 SOC meters. BATTERY VOLTAGE The voltage will vary based on the current load or charge placed on the battery. STATE OF CHARGE (SOC) The state of charge is displayed in percent. 0% = empty and 100% full. CAN LCD METER BATTERY CURRENT Discharge current (in amps) is diaplayed as a negative number. -
Page 4: Power Button
POWER BUTTON The power button controls flow of power in and out of the battery. It functions as a safety device to allow for safe handling of POWER the battery during installation and maintenance. It also serves BUTTON as a way to completely disconnect the battery during storage to prevent unnecessary discharge over extended periods. -
Page 5: Power Save Mode
POWER SAVE MODE If your battery was built after 08/01/2022 (or has updated firmware) it will be programmed to enter Power Save Mode after extended periods of inactivity. Power Save Mode will ensure that your battery will not be fully depleted in the event that your cart sits for an extended time. The time that must elapse before Power Save Mode will be activated, is dependent on SOC (see below). -
Page 6: Charging Instructions
CHARGER BATTERY CHARGER Use only genuine Eco Battery lithium chargers, or a lithium charger specifically approved by Eco Battery. This will ensure optimal charging and will extend the batteries service life. DO NOT USE UNAPPROVED BATTERY CHARGERS OR TENDERS. DO NOT CONNECT DC OUTPUT CABLES TO BATTERY WITH REVERSE POLARITY. Doing so will cause irreversible damage and is not covered under warranty. -
Page 7: Cold Weather
CLEANING Be mindful that there are sensitive electronics in your battery when cleaning your golf cart. Although your lithium battery is well sealed, DO NOT CLEAN BY PRESSURE WASHING. Pressure washing can lead to premature damage to the lid seal of the battery , and is not covered under the warranty policy. -
Page 8: Error Description
GEN 2 BMS ERROR CODES CODE ERROR DESCRIPTION LEVEL MOS Error External Short Circuit Cell Differential Cell Over Voltage Cell Under Voltage Pack Over Voltage Pack Under Voltage Discharge Over Current Charge Over Current Discharge Temp High Charge Temp High Charge Temp Low Discharge Temp Low MOS Temp High... -
Page 9: Need More Help
REV 1.0/2.23 ® NEED MORE HELP? CONTACT: SUPPORT@ECOBATTERY.COM OR CALL: 877-326-2288 WWW.ECOBATTERY.COM 877.ECO.BATT WWW.ECOBATTERY.COM...