Fuel System; Turbocharger; Cooling System; Electrical System - Volvo Penta TAMD71B Instruction Manual

13.3 Fuel system

Injection pump, settings .................................................
Injectors, opening pressure ...........................................
Injectors, adjustment pressure (new spring) .................

13.4 Turbocharger

Charging pressure, min. values (measured in the engine's inlet manifold at 100% load and wide open
throttle (WOT), air temperature approx. +25°C (77°F). When measuring at a different temperature, the
charging pressure measured must be corrected (see Workshop Manual).
If full power cannot be achieved, the pressure is considerably lower.
Rating 1 ("Genset operation"),
1500 rpm ....................................................................
1800 rpm ....................................................................

13.5 Cooling system

Freshwater system capacity incl. heat exchanger,
approx. ..........................................................................
Freshwater system capacity incl. radiator,
approx. ..........................................................................
Thermostat starts to open at .........................................
fully open at ...............................................

13.6 Electrical system

System voltage ..............................................................
Battery capacity .............................................................
Battery electrolyte density at 25°C (77°F),
fully charged battery ...................................................
battery to be recharged at ..........................................
Alternator (optional)
Make .............................................................................
Voltage/max. current .....................................................
Output ...........................................................................
Brush length ..................................................................
Starter motor
Make .............................................................................
Brush length ..................................................................
Brush spring force .........................................................
58 AB Volvo Penta / Diesel Engine TAMD71B
22° ±0.5° BTDC
30 (+0.8) MPa, (306 (+8) kp/cm
30,5 (+0.8) MPa, (311 (+8) kp/cm
63 kPa
80 kPa
35 liters (9.3 US gals)
25 liters (6.7 US gals)
73–77°C (163–171°F)
86–90°C (187–194°F)
24V DC
2 pcs./12V series connected max. 220 Ah
3
1.280 g/cm (0.462 lb/cu.in)
3
1.240 g/cm (0.447 lb/cu.in)
VALEO
28V/60A
1700W
min. 8 mm (0.3150")
Bosch KB 24V
min. 17.5 mm (0.6890")
12–14 N (1.2–1.4 kp = 2.7–3.1 lbf)
2 = 4351 psi)
2 = 4424 psi)