Trouble Analysis And Troubleshooting; Storage And Transportation; Storage - HUSTLER HPGH5500 Instruction Manual

TROUBLE ANALYSIS AND TROUBLESHOOTING

Symptom
Engine cannot be
started.
Generator has no output

Storage

The generator should be started at least once every two weeks and allowed to run
for at least 20 minutes. Follow the instructions below for longer term storage if the
generating set will be out of service for 2 months or more
FIRE OR EXPLOSION
Gasoline is highly flammable and extremely explosive.
Empty the fuel tank before storing or transporting the generator
1. Allow the generator to cool completely before storage.
2. Clean the generator according to the instructions in the MAINTENANCE section.
3. Drain all fuel completely from the fuel hose and carburetor to prevent gum
from forming.
4. Turn off the fuel supply at the fuel valve.
5. Change the oil.
6. Reattach the spark plug.
7. Remove the spark plug and pour about 15 ml of oil into the cylinder. Crank the
engine slowly to distribute the oil and lubricate the cylinder.
8. Store the unit in a clean, dry area out of direct sunlight.
Possible Cause
Generating set switch is "OFF".
There is no fuel.
Inadequate engine oil.
There's no ignition.
There's no ignition.
Inadequate cord set or extension
cords.

STORAGE AND TRANSPORTATION

Solutions
Turn the switch to the "ON" position .
Fill tank per instructions in this manual.
Check oil level. This engine is equipped with a
low oil sensor. The engine cannot be started
unless the oil level is above the prescribed
lower limit.
Remove the spark plug cap. Clean any dirt
from around the plug base, and then remove
the spark plug. Install the spark plug in the
plug cap. Turn the engine switch "ON".
Grounding the electrode to any engine ground,
pull the recoil starter to see if sparks jump
across the gap. If there is no spark, replace
the plug.
Reinstall the plug and start engine according
to instructions in this manual.
Consult Customer Service if necessary.
Reset circuit breakers.
Check cord set or extension cords capabilities
in section Controls; Cable Size in this manual.
Consult Customer Service if necessary.
30- ENG