Related Manuals for Hussmann RGDC
Summary of Contents for Hussmann RGDC
- Page 1 R G D C REFRIGERATED CURVED SELF-SERVICE MERCHANDISER I N S T A L L A T I O N & O P E R A T I O N G U I D E...
-
Page 2: Table Of Contents
Setting and Joining ..............5 and the carrier has assumed responsibility for safe arrival. Leveling ..................5 METHOD: RGDC/RGDC ALIGNMENT FOR LINE UPS ... 5 If damaged, either apparent or concealed, claim must be Bumper Installation Instructions..........8 made to the carrier. -
Page 3: Cut And Plan Views
Cut and Plan Views 24 3/4" ENDPANEL BALLAST BOX 36 1/2" 6 1/4" 23 5/8" 47 7/8" 73 5/8" 23 7/8" 73 5/8" ENDPANEL 24 1/8" 24 1/8" 18 3/8" 12 1/2" 22 7/16" 18 1/4" 37 3/16" 22 1/4" RGDC24 72 Self Service Deli Merchandiser Self Contained... - Page 4 BRIDGETON RGD D5X-E RGDC D5X-E 46 7/8" 30" DETAIL A *NOTE - CORRECT FRONT HEIGHT SELCTION IS ESSENTIAL TO PROPER CASE LINE UP BETWEEN BRIDGETON RGD CASE AND CHINO RGDC.* ELECT (Bottom Drain of Case) 6" RGDC- D5XE Self Service Refrigerated Bump-out...
-
Page 5: Installation
1. Surface must be clean, dry, and free of debris. Apply possible. Remove the top of the crate. Detach the walls Devan Sealant to RGDC case sides along joint from each other and remove from the skid. Unbolt the case faces. - Page 6 Installation (Cont'd) SPLASH GUARD MOUNT HOLE LOCATION...
- Page 7 Installation (Cont'd) Mount Splashguard and Bracket ● Set bracket, align ¼ slot to set screw hole ● Screw bracket, loosely to a low to drop to floor ● Snap in splashguard by setting the top in first ● And push in firmly to snap in. ●...
-
Page 8: Bumper Installation Instructions
Installation (Cont'd) Bumper Installation Instructions Step 2: Use silicone lubricant to help the Step 1: Make sure the aluminum channel and end caps bumper slide into the channel. are installed. Step 3: Starting on one end: while inserting the bumper, Step 4: As you insert the bumper into the channel with push it up against the end cap to prevent one hand, pull the bumper toward you with... -
Page 9: Plumbing
RGDC (Self Contained) 1. Never use pipe for condensate drains smaller The waste outlet and P-TRAP are the same as the remote than the nominal diameter of the pipe or P-TRAP supplied with the case. -
Page 10: Refrigeration
Condenser Ventilation Control Settings Be sure to supply adequate ventilation for the condenser in See RGDC technical data sheet for the appropriate Self Contained units. Allow 150 square inches for units up settings for your merchandiser. Maintain these parameters to 1 1/2 h.p., and 200 for condenser units over 2 h.p. -
Page 12: Electrical
Finishing Touches If more than one RGDC is being installed next to each other, the factory fitted continuous fascia may need to be installed. All fasciae rest on the top of their cases. The self contained fascia has a hook that needs to be slid through a gusset on... -
Page 13: User Information
Important Steps product. Hussmann cases were not designed to “heat up” 1. Do not set temperature too cold, as this causes or “cool down” product - but rather to maintain an item’s product dehydration. -
Page 14: Cleaning Glass And Mirrors
User Information (Cont'd) Plexiglass and Acrylic Care 1. Scrub thoroughly, cleaning all surfaces, with soap and hot water. Cleaning 2. Rinse with hot water, but do not flood. Clean with plenty of nonabrasive soap (or detergent) and 3. Apply the sanitizing solution according to the lukewarm water, using the bare hand to feel and dislodge manufacturer’s directions. -
Page 15: Maintenance
When contacting the factory, Copper Coils be sure to have the Case Model and Serial The copper coils used in Hussmann merchandisers may Number handy. This information is on a plate be repaired in the field. Materials are available from local located on the case itself. -
Page 16: Stainless Steel Cleaning And Care
Maintenance (Cont'd) 3. Use Alkaline, Alkaline Chlorinated or Stainless Steel Cleaning and Care There are three basic things, which can break down your Non-chloride Containing Cleaners stainless steel’s passivity layer and allow corrosion. While many traditional cleaners are loaded with chlorides, the industry is providing an ever 1. -
Page 17: Electrical Wiring Diagrams
Electrical Wiring Diagrams RGD-24-72-3-SC R-404/448 3127775 RGD-24-72-3'9"-SC R-404/448 3'9" 3127776 RGD-24-72-4-SC R-448 3127777 RGD-30-72-4-SC R-448 3127778 RGD-24-72-5-SC R-404/448 3127779 RGD-30-72-5-SC R-404/448 3127780 RGD-24-72-6-SC R-404/448 3127781 RGD-30-72-6-SC R-404/448 3127782 RGD-24-72-8-SC R-448 3127783 RGD-30-72-8-SC R-448 3127784 RGD-24-72-3-S W/XR75 CTLR 3160912 RGD-24-72-4R-S/XR75 CTLR 3157196 RGD-24-72-3'9"-S W/XR75 CTLR 45"... -
Page 46: Appendices
Public Health will use the temperature of the product in NOTE: provided by Hussmann for the installation determining if the refrigerator will be allowed to display of each individual type refrigerator. potentially hazardous food. For the purpose of this... -
Page 47: Appendix D. - Recommendations To User
Fahrenheit shall be accurate to 1°C (1.8°F). 12. Are the shelf positions, number, and size Temperature measuring devices that are other than recommended by Hussmann? scaled only in Fahrenheit shall be accurate to 13. Is there an improper application or control 2°F. - Page 48 Food store refrigerators are not food chillers nor can they reclaim quality lost through previous mishandling. For further technical information, please log on to http://www.hussmann.com/products/RGDC.htm...
- Page 49 August 31, 2018 This warning does not mean that Hussmann products will cause cancer or reproductive harm, or is in violation of any product-safety standards or requirements. As clarified by the California State government, Proposition 65 can be considered more of a ‘right to know’...
-
Page 50: Controller Instructions
Danfoss Controller Operations User Guide Controller for temperature control User Guide AK‐CC 210 Controller for temperature control ADAP‐KOOL® Refrigeration control systems AK-CC 210 ADAP-KOOL® Refrigeration control systems Open Camera IPhone User Hold the camera up to the QR code Android User Open QR Code Reader app if necessary. - Page 51 Dixell Controller Operations 026-1210 Rev 3 03-FEB-2015 User Guide Controller for temperature control XR75CX Digital Controller for Medium‐Low Temperature AK‐CC 210 Refrigeration Applications Installation and Operation Manual ADAP‐KOOL® Refrigeration control systems Open Camera IPhone User Hold the camera up to the QR code Android User Open QR Code Reader app if necessary.
- Page 52 Additional copies of this publication may be obtained by contacting: unit. Hussmann® Chino They can be found on a small metal plate on the unit. 13770 Ramona Avenue • Chino, California 91710 Please note them below for future reference.