Table of Contents
Advertisement
Available languages
Available languages
as those dust masks that are specially designed to
grease tube cavity out microscopic particles.
•
Wear protective clothing and wash exposed areas
with soap and water. Allowing dust to get into your
mouth, eyes, or lie on the skin may promote absorption of
harmful chemicals. Direct particles away from face and body.
•
Use the appropriate dust extractor vacuum to remove
the vast majority of static and airborne dust. Failure
to remove static and airborne dust could contaminate the
working environment or pose an increased health risk to
the operator and those in close proximity.
•
Use clamps or other practical ways to secure and
support the workpiece to a stable platform. Holding
the workpiece by hand or against your body is unstable
and may lead to loss of control and injury.
•
Air vents often cover moving parts and should be
avoided. Loose clothes, jewelry or long hair can be caught
in moving parts.
•
An extension cord must have adequate wire size
(AWG or American Wire Gauge) for safety. The smaller
the gauge number of the wire, the greater the capacity
of the cable, that is, 16 gauge has more capacity than
18 gauge. An undersized cord will cause a drop in line
voltage resulting in loss of power and overheating. When
using more than one extension to make up the total length,
be sure each individual extension contains at least the
minimum wire size. The following table shows the correct
size to use depending on cord length and nameplate
ampere rating. If in doubt, use the next heavier gauge. The
lower the gauge number, the heavier the cord.
Minimum gauge for Cord sets
Total length of Cord in Feet
Volts
120 V
25 (7.6)
240 V
50 (15.2) 100 (30.5) 200 (61.0) 300 (91.4)
Ampere Rating
More
not
Than
More
Than
0
6
18
6
10
18
10
12
16
12
16
14
Additional Safety Information for
Dust
Extractors
•
Connect to a properly grounded outlet only (See
Grounding Instructions).
•
This vacuum meets the EPA lead‑related Renovations,
Repair and Painting (RRP) Rule for HEPA vacuum only when
used with the DWV9320 or DWV9330 HEPA Filter. (included
with DWV015).
Contact the United States Environmental Protection Agency
(EPA) for more information on their Renovations, Repair
and Painting (RRP) Rule.
•
This vacuum is approved for use in OSHA Silica 1926.1153
dust collection applications when properly utilized per the
OSHA 1926.1153 ruling.
(meters)
50 (15.2) 100 (30.5) 150 (45.7)
American Wire gauge
16
16
16
14
16
14
12
Not Recommended
•
Do not pick up anything that is burning or smoking, such
as cigarettes, matches, or hot ashes.
•
Do not use to vacuum combustible explosive
materials, such as coal, grain, or other finely divided
combustible material.
•
Do not use to vacuum hazardous, toxic or carcinogenic
materials, such as asbestos or pesticide, unless the
vacuuming of the material is specifically identified in this
instruction manual as an approved use.
•
Never pick up explosive liquids (e.g. gasoline, diesel fuel,
heating oil, paint thinner, etc.), acids or solvents.
•
Do not use vacuum without filters in place, except as
described under Wet Pickup Applications.
•
Some wood contains preservatives which can be toxic. Take
extra care to prevent inhalation and skin contact when
working with these materials. Request and follow any
safety information available from your material supplier.
•
Do not use vacuum as a step ladder.
•
Do not place heavy objects on vacuum.
The label on your tool may include the following symbols. The
symbols and their definitions are as follows:
V ......................... volts
Hz ....................... hertz
min ..................... minutes
or DC ...... direct current
...................... Class I Construction
.../min .............. per minute
BPM .................... beats per minute
IPM ..................... impacts per minute
OPM .................... oscillations per
RPM .................... revolutions per
sfpm ................... surface feet per
14
SPM .................... strokes per minute
12
A ......................... amperes
12
W ........................ watts
Wh ...................... watt hours
Ah ....................... amp hours
ON MOTOR HOUSING (on back of
vacuum head):
WARNING:
•
TO REDUCE THE RISK OF INJURY, USER MUST READ
INSTRUCTION MANUAL. DO NOT RUN UNATTENDED.
DO NOT PICK UP FLAMMABLE, COMBUSTIBLE OR HOT
MATERIALS. DO NOT USE AROUND EXPLOSIVE DUST,
LIQUIDS OR VAPORS. ELECTRICAL DEVICES PRODUCE
ARCS OR SPARKS WHICH CAN CAUSE FIRE OR EXPLOSION.
DO NOT USE AT FILLING STATIONS OR ANYWHERE
GASOLINE IS STORED OR DISPENSED. DO NOT VACUUM
TOXIC OR CARCINOGENIC MATERIALS OR OTHER HEALTH
ENDANGERING MATERIAL SUCH AS ASBESTOS OR
or AC ........... alternating current
or AC/DC .... alternating or direct
...................... Class II Construction
n o ....................... no load speed
(grounded)
n ......................... rated speed
PSI....................... pounds per square
...................... earthing terminal
..................... safety alert symbol
minute
..................... visible radiation–
minute
..................... wear respiratory
minute
..................... wear eye protection
..................... wear hearing
..................... read all documentation
..................... do not expose to rain
English
current
(double insulated)
inch
do not stare into
the light
protection
protection
5
Advertisement
Table of Contents
