Related Manuals for UNITED TC250
Summary of Contents for UNITED TC250
- Page 1 TC250 Operation & Maintenance Manual United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623...
-
Page 2: Table Of Contents
7.0 Preventive Maintenance ..............................15 7.1 Shift Inspections ................................15 7.2 Weekly Maintenance ..............................15 7.3 Bi-Weekly Maintenance ............................16 7.4 Monthly Maintenance ............................... 16 United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 3: Introduction
The entire microencapsulation process is completed in just minutes, leaving clear and in most cases sewerable, water. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 4: Overview
2.0 Overview 2.1 Components 55 Gallon Clean Water Tank 55 Gallon Process Tank Notification Beacon 3-Button Controls Optional Drainage Valves Optional Sink United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 5: Specifications
Country of Origin Warranty Up to 3 years, determined by component type. Height 84” Width 56” Depth 44.25” 2’ Rear+Sides Clearance 4’ Front United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 6: Setup
Operation: 1. As you use the Sink the TC250 will automatically fill up the Left/Process tank, when it is full the Red light will come on - this indicates you need to start the process. NOTE: There is a small reserve of clean water to continue rinsing parts while processing. - Page 7 2. Flush Process Tank with clean water to remove all sludge and debris. 3. Clean UV Light daily using scraper rod on UV tank. CLEAN WATER PROCESS TOWER CONTROL FAUCE SINK SLUDGE TRAY United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623...
- Page 8 AIR VENTURI WITH TANK MIXER FRESH WATER CHECK PRESSURE PROCES S TANK DRAIN SYSTEM VALVE PURGE VALVE United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623...
- Page 9 UV SCRAPER REMOVE PANEL United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623...
-
Page 10: Operation - With Sink
Ensure wastewater being pumped in does not exceed 30 GPM (gallons per minute). 2. When the process tank fills, the alert beacon will illuminate like usual. Start the process as described in “With Sink” operation. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 11: Cleaning
Valves can be flushed out by inserting a hose into a valve and opening it as water flows through. Valves can also be removed at unions and cleaned manually. 5.2 Tanks Due to the stainless steel construction, the TC250 will not corrode due to moisture. Tanks can be rinsed periodically. 6.0 Process Troubleshooting If you are having trouble processing your water, please refer to the following troubleshooting guide. -
Page 12: Problem: Floc Won't Float
Verification Visual inspection. Correction Give the solution additional time to float. If practical, leave overnight. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 13: Problem: Sludge Clogs Filter
Using a filter device other than one recommended by United Surface Solutions. Verification Check with your purchasing department or contact United Surface Solutions. Correction Order supplies from United Surface Solutions or its distributors. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 14: Problem: Sludge Seeps Through Filter
WARNING: This will involve a decrease in the safety of the system due to powerful acid-base reactions needed for emulsification. If possible, eliminate the oils before treating. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 15: Preventive Maintenance
Pumps. If needed, clean this sludge residue from all tanks using fresh water only. DO NOT use any type of liquid or paste cleaners. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623... -
Page 16: Bi-Weekly Maintenance
Also, inspect to ensure that a back-flow of water will push the check valve close and not allow the water to pass. United Surface Solutions | 11919 Burke St, Santa Fe Springs, CA 90670 | info@unitedusa.com | (877) 837-4623...