Table of Contents
Advertisement
Quick Links
MANUAL FOR INSTALLATION, USE AND
MAINTENANCE
LODGE
Congratulations!
You have chosen an appliance of the JIDÉ range and we would like to thank you for it. We
are convinced that it will bring you warmth and comfort. In order to derive the greatest
benefit from your fireplace, we greatly stress the importance of following the instructions
and recommendations given in this notice.
1
JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 ––
www.jide.be
-
info@jide.be
ME-LODGE-V1.2 EN 16-11-2022
Advertisement
Table of Contents
Related Manuals for Jide LODGE
Summary of Contents for Jide LODGE
- Page 1 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
-
Page 2: Table Of Contents
End of life instructions ................................26 TROUBLESHOOTING..........................27 DECLARATION OF CONFORMITY JIDÉ ....................30 DECLARATIONS OF PERFORMANCE ....................... 31 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 3 TECHNICAL DOCUMENT ........................35 WARRANTY ............................36 Warranty agreement ............................36 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
-
Page 4: Introduction
A list of our dealers-installers is available on our site www.jide.be/en. Before using your fireplace for the first time and in order to guarantee its good usage and operation over time, we suggest you carefully read these instructions for use in order to familiarise yourself with its various functions and characteristics. -
Page 5: Technical Characteristics And Compliance
Ecological solution: cleaner emissions, less dust and CO Economic: greatly reduced wood consumption. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 6 CO emissions: 1125 mg/Nm³ Fuel: wood Fuel: wood Smoke temperature: 225 °C Smoke temperature: 225 °C Lodge 16/9 Lodge 16/9 XL Nominal power: 14 kW Nominal power: 14 kW Nominal efficiency: 80 % Nominal efficiency: 80 % CO emissions: 1125 mg/Nm³...
-
Page 7: Additional Parts - Identification Plate
(traceability) if necessary. We advise you to paste it on this user and installation notice or on your invoice. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 8: User Notice
When you open the door laterally it gets a few millimetres down, this is normal. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 9: Lightning The Fire
Your fireplace is now in its optimum configuration: post-combustion and maximum efficiency. You can regulate the air intake to the right according to the desired heat. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 10: Combustion
Position right, you fully open the combustion air intake. It is necessary to adjust this control regarding to the quantity of wood loaded in the fireplace. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 11 (speed of the fan too low). The unburned gases are converted into soot. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
-
Page 12: The Wood - Choice And Usage
Thus, the “hard” wood varieties such as beech, oak, whose density is high, will require a lower quantity than other low density species: JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 13 Lodge 77 .............. 4,1 kg (maximum) of dry wood per hour Lodge 16/9 ............4,1 kg (maximum) of dry wood per hour Lodge 16/9 XL ............4,1 kg (maximum) of dry wood per hour CAUTION The overloading of wood of your stove may have some consequences and the damage hereafter will obviously not be covered by the warranty;...
-
Page 14: Installation Notice
INSTALLATION NOTICE JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 15: Preparation - Arrangements
Still with regard to protection, your installer can also provide a floor plate in front of the insert in order to guard against the ejection of embers. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 16: Fireplace Base
The fireplace emits heat by radiation through the window and by air convection. It is thus essential to provide non-inflammable materials in the distribution zone (85 cm all around the glass). JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 17: Sealed Connection
The chimney must have a normal pulling i.e. that with its power maximum, the depression will have to range between 12 and 20 Pa. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 18: Fitting
(feet supports are pre-drilled each 5 cm). Screw the feet supports. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 19: Fitting Of The Finishing Frame
It fits onto the appliance. When the duct is placed on the appliance, fold back the 2 safety clamps. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 20: Installation Of The Connection For The Convection Air
Caution: Make sure not to create backflow of smoke by reducing too much their passage. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 21: Ventilation Fitting And Access (Option)
The four silent blocs set on this plate have to be placed on the four holes around the cut of the convection chamber. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 22 Complementary products used for the installation must be conform to local regulations. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
-
Page 23: Electrical Connection
"Line" and "Neutral" terminals. If present, connect the grounding wire (yellow and green) to the grounding terminal. Ventilator Circuit JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 24: Maintenance Of The Fireplace
This dust penetrates the seal and loses its elasticity and forms a hardened crust, which causes stress on the glass and leads to cracks. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 25: Door
Also ensure that smoke duct is not obstructed after long time of non-use of the fireplace. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 26: Life Cycle
The door glass is made of boro-silicate glass and must be treated separately from food glass. The control units will be recycled at an electronics processing centre. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 27: Troubleshooting
- Open the air inlet before opening the door - Always open the door slowly in order to avoid smoke being sucked outside the fireplace JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 28 - Small diameter fuel often - Decrease the air flow of combustion - Too important opening of the air for combustion JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 29 The paint flakes - Overheating - Sanding and repainting - Respect the maximum loading of wood per hour JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
-
Page 30: Declaration Of Conformity Jidé
DECLARATION OF CONFORMITY JIDÉ JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... -
Page 31: Declarations Of Performance
DECLARATIONS OF PERFORMANCE JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022... - Page 32 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 33 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 34 JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 35 TECHNICAL DOCUMENT JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 36 ▪ Intentional and permanent interruption of the ventilation; ▪ Usage with the door of the ash box open. JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 37 Surname …………………………….. Forename …………….………………… Purchaser: Address ………………………………………………………..………………………… Postcode …………… City ………………………..……………………………. Seller's stamp Stick your identification plate here JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 38 Notes …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 39 …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… …………………………………… JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...
- Page 40 JIDÉ, innovation and efficiency, that's us Heat and savings are for you JIDÉ s.a. – Rue des Meuneries 11 – B-4650 HERVE (Belgique) – Tél. +32 87 31.75.12 –– www.jide.be info@jide.be ME-LODGE-V1.2 EN 16-11-2022...