Page 1
Quadivator UTV Harrow Assembly/Operators/Parts Manual English Language Version 08 Printed: xxxxxxx 2009 READ & SAVE THIS MANUAL QUADIVATOR INC. 1000 6th Ave. NE Portage La Prairie, MB Canada, R1N 3C5 www.quadivator.com Part # : 86XXXA...
Page 2
Any engine service difficulty is the responsibility of the engine manufacturer and in no way is Quadivator Inc. or its agents responsible for the engine warranty. The Briggs & Stratton Engine Service Hot Line is 1-800-233-3723.
Page 3
Quadivator UTV Harrow FOREWORD Congratulations on the purchase of your new Quadivator UTV Harrow. To obtain the best use of your Quadivator UTV Harrow, read this manual carefully. It will help you become familiar with the operation and maintenance of the Quadivator UTV Harrow. It is Quadivator Policy to use all research, design and manufacturing improvements to improve our products.
1 Operate for 5 – 10 minutes, check for excessive operation or unusual noise, when using the Quadivator UTV Harrow and attachment(s). 1 The Quadivator UTV Harrow and customer ordered attachments have been tested and to the best of my knowledge, is ready to be delivered to the customer! Date Pre-delivered –...
Page 6
1 Tell the customer not to remove any of the safety shields or guards. 1 Review the Quadivator Warranty. 1 Review the Safe Operation and Service of the Quadivator Attachment. 1 Review the Daily and Periodic Lubrication and Maintenance. 1 Review the Daily and Periodic Inspections.
Quadivator UTV Harrow Safe Operation 13. Shut off engine and wait for all parts to come to a complete stop before cleaning, servicing and/or unplugging the machine. Failure to observe the following safety DANGER 14. Operate machine in daylight or good instructions could artificial light.
Page 8
Quadivator UTV Harrow 9. Keep all movement on slopes slow and Towing gradual. Do not make sudden changes in speed 1. Tow only with a machine having a hitch or direction, which could cause the machine to designed for towing. Do not attach towed roll over.
9. Remove support stands. Lower evenly the cart frame. This eases installing the hitch tube UTV Harrow to the ground so wheels and hitch and wheels. contact at the same time.
30 psi. The smaller turf tires on the left and right hand lift frames should have 30 psi. Do not exceed 6 mph (or 9 kph). The UTV harrow will not do a good finishing job - if ground speed is Actuator Installation too high.
Quadivator UTV Harrow 4. Check depth and adjust to conditions. 5. The UTV Harrow should be level when operating. Locate the UTV, ATV or compact tractor on a level surface; adjust the hitch height so the harrows are flat on a level surface.
Page 12
Quadivator UTV Harrow AFTER END OF SEASON USE: Remove 5. Inspect the UTV Harrow for loose, damaged wheels, clean shafts and inside wheel. Apply a or worn parts. Adjust, or replace if needed. light coating of grease and reinstall with flatwashers and new cotterpin.
Quadivator UTV Harrow Troubleshooting POSSIBLE POSSIBLE POSSIBLE POSSIBLE PROBLEM PROBLEM CAUSE SOLUTION CAUSE SOLUTION Actuator is not Connect wiring to Wait for softer connected to Hard ground switch – check. ground the switch. Check switch and Adjust the hitch Penetration...
Torque Chart Use the Torque Chart to ensure that the Use the Torque Chart to make sure that the hardware used on the Quadivator Product(s) is hardware on your Quadivator Product(s) is tightened to the capacity of the hardware. secure.
Quadivator UTV Harrow WARRANTY REGISTRATION – Quadivator UTV Harrow Please fax this sheet to (204) 239-4271 or mail it to: Quadivator Inc. P.O. Box 1127 1000 – 6 Ave NE Portage la Prairie Manitoba, R1N 3C5 CANADA Harrow UTV Model # -...