Table of Contents
Advertisement
Safety of the operator is one of the main concerns all equipment manufacturers. It is
considered in the design and development of a new piece of equipment. In spite of this,
many accidents occur which could have been avoided by the operator being more
careful. The operator, You, can avoid most if not all accidents by observing and
following the instructions in the manual. Use common sense and require those working
with you do the same.
SAFETY FIRST
Do not allow personnel other than the qualified operator near the machine.
Never start a machine until all guards and safety shields are in place.
Do not lubricate, clean or adjust the machine while it is in motion or under power.
Before starting the tractor be sure the PTO shields turn freely.
If any WARNING or DANGER label is damaged, obscured or missing replace it.
Do not paint over any labels. The location of all safety related labels are in the
first few pages of the parts portion of this manual.
Do not attempt to operate this equipment under the influence of drugs or alcohol.
Have all operators review the safety instructions annually.
Keep all children and bystanders a safe distance away from this machine it is
dangerous to the uninformed. The discharge elevator can be remotely lowered or
raised suddenly. The discharge chain can start remotely. These are controlled by
the operator in the cab of the truck or tractor who may not be able to see all sides
of the elevator.
The limits of the machine are noted on the yellow loading instruction label on the
front of the machine. Do not exceed them.
This machine is designed to mix roughage and food supplements for ruminating
animals. Do not use it for any other purpose.
This machine is equipped with reflectors and a slow moving vehicle marking. It is
your responsibility to add additional lights as needed or required by law. A US
DOT compliant stop-tail -turn lighting kit is available as an option.
Disconnect PTO driveline before removing shields for maintenance, adjustment
or service.
Never enter a mixer/feeder while in operation.
Keep transmissions in gear when traveling downhill.
Wear close fitting clothing. Keep a safe distance from the PTO shaft.
If your machine is equipped with a battery keep sparks, lighted matches, and
open flame away from the top of battery. Battery gas can explode. Never check
battery charge by placing a metal object across the posts. Do not charge a frozen
battery; it may explode. Warm battery to room temperature before charging.
Escaping fluid under pressure can penetrate the skin causing serious injury or
death. Avoid the hazard by relieving hydraulic pressure before disconnecting any
lines. Tighten all connections before applying pressure. Search for leaks with a
piece of cardboard or wood. Protect hands and body from high pressure fluids. If
an accident occurs, see a doctor immediately. Any fluid injected into the skin
must be surgically removed within a few hours or gangrene may result.
FARM AID EQUIPMENT, INC. 40 EAST 1ST STREET, CORSICA, SD 57328
PHONE (605) 946-5479 FAX (605) 946 5899
www.farmaidequip.com
Advertisement
Table of Contents
