General Inspection; Maintenance Performed Every 30 Days; Disinfect The Reservoir And Change Recirculating Solution For Distilled Water And 35% Isopropyl Alcohol Solution; Maintenance Performed Every 12 Months - Smith Medical LEVEL 1 HOTLINE 3 HL-390-38 Operator's Manual

General Inspection

Check the condition of the HOTLINE
inspection before using. Remove from service any HOTLINE
that shows physical damage.

Maintenance Performed Every 30 Days

Disinfect the Reservoir and Change Recirculating Solution for
Distilled Water and 35% Isopropyl Alcohol Solution

Disinfect the Reservoir and Change the Recirculating Solution

Refer to
procedure in this section.

Maintenance Performed Every 12 Months

Disinfect the Reservoir and Change Recirculating Solution for
0.3% Hydrogen Peroxide Solution
Refer to Disinfect the Reservoir and Change the Recirculating Solution
procedure in this section.
Disinfect the Reservoir and Change the Recirculating
Solution
Disinfect the reservoir and change the recirculating solution every 30 days
or every 12 months based on the recirculating solution used for the

HOTLINE 3 Warmer. Refer to the following table for the maintenance
schedule .
Recirculating Solution Preparation
0.3% Hydrogen Peroxide Mix 140 ml of 3% hydrogen
Solution peroxide with 1,260 ml of
distilled water.
Distilled Use distilled water.
Water
35% Isopropyl Alcohol Mix 700 ml of 70% isopropyl
Solution alcohol with 700 ml of distilled
water.
Note: Use distilled water only, not tap water. Failure to do so may cause build-up of
mineral deposits in the recirculating solution path, which may impair heater
performance.
®
HOTLINE 3 Blood and Fluid Warmer | Operator's Manual
S E C T I O N 1 0 • M a i n t e n a n c e

3 Warmer with a visual
Maintenance
Replace solution and
disinfect reservoir every
12 months.
Replace solution and
disinfect reservoir every
30 days.
Replace solution and
disinfect reservoir every
30 days.

Warmer
31