Weber Summit E-470 Owner's Manual
  1. Manuals
  2. Brands
  3. Weber Manuals
  4. Grill
  5. Summit E 470
  6. Owner's manual

Weber Summit E-470 Owner's Manual

Hide thumbs Also See for Summit E-470:
Table of Contents

Advertisement

Quick Links

Download this manual
BARBECUE OWNER'S GUIDE
UNIVERSAL LIQUEFIED PETROLEUM GAS
E-470
™
If you smell gas:
1) Shut off gas to the appliance.
2) Extinguish any open flames.
3) Open lid.
4) If odor continues, keep away from the appliance and
immediately call your gas supplier or your fire department.
1) Do not store or use gasoline or other flammable liquids or
vapors in the vicinity of this or any other appliance.
2) An LP cylinder not connected for use shall not be stored in
the vicinity of this or any other appliance.
NOTICE TO INSTALLER: These instructions must be left with the
owner, who should keep them for future use.
m DANGER
m WARNING
#48529
YOU MUST READ THIS OWNER'S
GUIDE BEFORE OPERATING
YOUR GAS BARBECUE.
Leaking gas may cause a fire
or explosion which can cause
serious bodily injury, death, or
damage to property.
Carefully follow all leak-check
procedures in this Owner's Guide
prior to barbecue operation.
Do this even if the barbecue was
dealer-assembled.
Do not ignite this appliance
without first reading the burner
ignition sections of this manual.
THIS GAS APPLIANCE IS
DESIGNED FOR OUTDOOR
USE ONLY.
48529 08/01/15 ULPG
AU - AUSTRALIA
NZ - NEW ZEALAND

Advertisement

Table of Contents
loading

Related Manuals for Weber Summit E-470

Summary of Contents for Weber Summit E-470

  • Page 1 BARBECUE OWNER’S GUIDE UNIVERSAL LIQUEFIED PETROLEUM GAS E-470 ™ #48529 YOU MUST READ THIS OWNER’S m DANGER GUIDE BEFORE OPERATING If you smell gas: YOUR GAS BARBECUE. 1) Shut off gas to the appliance. Leaking gas may cause a fire 2) Extinguish any open flames.

  • Page 2: Warnings

    LPG cylinder should be transported to relight, using the lighting instructions. and stored accordingly. m Do not use charcoal or lava rock in your Weber gas barbecue. ® m If you see, smell or hear the hiss of escaping gas from the LPG...

  • Page 3: Table Of Contents

    DRIPPINGS AND GREASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 WEBER SPIDER/INSECT SCREENS .

  • Page 4: Exploded View

    EXPLODED VIEW SUMMIT_470_ULPG_XV_AU_052215...

  • Page 5: Exploded View List

    56. Fuel Scale Assembly 17. Control Panel 37. IR Burner Igniter Wire 57. Matchstick Holder 18. Small Knob Bezel 38. Thermocouple 58. Caster 19. Small Knob 39. IR Burner Hose 59. Locking Caster 20. Large Knob 40. Rotisserie Spit Assembly WWW.WEBER.COM...

  • Page 6: Warranty

    Weber may choose (at its option) to replace the barbecue in question with a new barbecue of equal or greater value . Weber may ask you to return parts for inspection, shipping charges to be WEBER MAY FROM TIME TO TIME CHANGE THE DESIGN OF ITS PRODUCTS. NOTHING CONTAINED pre-paid .

  • Page 7: Operating

    Refer to AS5601.1, local authority, gas, electricity, and other relevant statutory regulations for installation and use. ◆ STORAGE AND/OR NON-USE • The gas must be turned off at the LPG cylinder when the Weber gas barbecue is not ® in use .

  • Page 8: Gas Instructions

    GAS INSTRUCTIONS REPLACEMENT HOSE, REGULATOR AND VALVE ASSEMBLY 470 DIMENSIONS m IMPORTANT NOTICE: We recommend that you replace the gas hose assembly on your Weber gas barbecue every 5 ® years. Some countries may have requirements that the gas 127 cm hose be replaced within less than 5 years, in which case that country’s requirement would take precedence.

  • Page 9: Purchase A Full Lpg Cylinder

    Weber gas barbecue. ® A) Turn the LPG cylinder so the opening of the valve is to the front of the Weber ® barbecue . B) Lift and hook the LPG cylinder onto the AU adapter bracket on the fuel scale (6) .

  • Page 10: Leak Check Preparation

    Note: All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting.
  • Page 11 DO NOT OPERATE THE BARBECUE. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com. D) Side burner hose to bulkhead (4) . E) Side burner hose to quick disconnect, side burner valve and orifice connections (5) .

  • Page 12: Refilling The Lpg Cylinder

    GAS INSTRUCTIONS REFILLING THE LPG CYLINDER We recommend that you refill the LPG cylinder before it is completely empty . To refill, take LPG cylinder to an authorized gas supplier . Removal of the LPG cylinder: A) Close LPG cylinder valve (turn clockwise) (1) . B) Unscrew regulator by turning POL fitting nut clockwise, by hand only (2) .

  • Page 13: Before Using The Barbecue

    WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.

  • Page 14: Snap Ignition Operation

    SNAP IGNITION OPERATION m Always open the lid before igniting the burners. A) Each control knob has its own igniter electrode built in . To create a spark you must push the control knob in (1) and turn to START/High (2) . B) This action will generate gas flow and a spark to the burner lighting tube (3) .

  • Page 15: Main Burner Ignition & Usage

    OFF and wait five minutes to let the gas clear before you try again or try to light with a match. ◆ TO EXTINGUISH Push in and turn each burner control knob clockwise to OFF position . Turn gas supply off at the source . ◆ START/HI MEDIUM WWW.WEBER.COM...

  • Page 16: Main Burner Manual Ignition

    MAIN BURNER IGNITION & USAGE MAIN BURNER MANUAL IGNITION m DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up, which can cause serious bodily injury or death.

  • Page 17: Barbecuing Tips & Helpful Hints

    • Using a timer will help to alert you when “well-done” is about to become “overdone . ” ◆ Note: If barbecue loses heat while cooking refer to the troubleshooting section of this manual. m WARNING: Do not move the Weber gas barbecue when ® operating or while barbecue is hot.

  • Page 18: Cooking Methods

    COOKING METHODS The most important thing to know about barbecuing is which cooking method to use for 4 BURNER a specific food, Direct or Indirect . The difference is simple: place the food directly over the fire, or arrange the fire on either side of it . Using the right method is the shortest route to great results—and the best way to ensure food is safely cooked through .

  • Page 19: Side Burner Ignition & Usage

    WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber ® authorized replacement hose. Contact the Customer Service...

  • Page 20: Side Burner Manual Ignition

    SIDE BURNER IGNITION & USAGE SIDE BURNER MANUAL IGNITION The barbecues illustrated in this Owner’s Guide may vary slightly m DANGER from the model purchased . Failure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death.

  • Page 21: Sear Station ® Ignition & Usage

    Note: See “MAINTENANCE” for burner removal and cleaning procedure. ◆ TO EXTINGUISH Push in and turn each burner control knob clockwise to OFF position . Turn gas supply off at the source . ◆ WWW.WEBER.COM...

  • Page 22: Sear Station ® Burner Manual Ignition

    SEAR METHOD Food is placed in the area of intense heat between the lit burners USING THE SEAR STATION ® Your Weber gas barbecue includes a sear burner for searing meats such as steak, ® poultry parts, fish, and chops .

  • Page 23: Smoker Burner Ignition & Usage

    H) Close smoker cover after wood starts to smoulder and turn control knob to LOW (8) . ARRÊTÉ ◆ TO EXTINGUISH Push in and turn each burner control knob clockwise to OFF position . Turn gas supply START/HI off at the source . ◆ WWW.WEBER.COM...

  • Page 24: Smoker Burner Manual Ignition

    SMOKER BURNER IGNITION & USAGE SMOKER BURNER MANUAL IGNITION A) Open the lid (1) . m DANGER Failure to open the lid while igniting the barbecue, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up, which can cause serious bodily injury or death.

  • Page 25: Using The Smoker

    To a lesser degree a “smoke” residue will accumulate on the inside of your gas barbecue. This residue need not be removed and will not adversely affect the function of your gas barbecue. ◆ WWW.WEBER.COM...

  • Page 26: Rotisserie Burner Ignition & Usage

    ROTISSERIE BURNER IGNITION & USAGE ROTISSERIE BURNER IGNITION Rotisserie Burner Snap Ignition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to START/HI.

  • Page 27: Rotisserie Burner Manual Ignition

    Turn off the rotisserie burner once the food has browned to the desired colour. Finish cooking on indirect heat. ◆ TO EXTINGUISH Push in and turn the rotisserie burner control knob clockwise to OFF position . Turn gas supply off at the source . ◆ WWW.WEBER.COM...

  • Page 28: Important Safeguards

    Representative in your area using the contact information on m To protect against electrical hazards do not immerse power our web site. Log onto www.weber.com. lead, plugs, or motor in water or other liquids. m Unplug the motor from outlet when not in use, or before C) Make sure the rotisserie shaft handle is securely fastened .

  • Page 29: Rotisserie Cooking

    (1) . m CAUTION: Do not allow rotisserie spit to come into contact with any gas lines. B) Store rotisserie forks by placing them on the hooks located on the catch pan holder within the barbecue cabinet (2) . ◆ WWW.WEBER.COM...

  • Page 30: Troubleshooting

    . Replace with a spare LPG cylinder and resume cooking . If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com. SIDE BURNER TROUBLESHOOTING...

  • Page 31: Sear Station ® Troubleshooting

    IGNITION & USAGE . ” Call Customer Service . If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com. ROTISSERIE TROUBLESHOOTING...

  • Page 32: Maintenance

    MAINTENANCE CLEANING WEBER SPIDER/INSECT SCREENS ® m WARNING: Turn your Weber gas barbecue off and wait for it to Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders ® ® and other insects . They can nest in the venturi section (1) of the burner tubes . This cool before cleaning.

  • Page 33: Replacing Main Burners

    . Pull manifold assembly away from burner tubes and let it hang loose from grill cabinet (8) . Do not disconnect the blue wire from the left side of the manifold assembly. B) Pull the selected burner tube(s) through the front of cookbox and replace with new burner tube(s) (9) . WWW.WEBER.COM...

  • Page 34: Side Burner Maintenance

    MAINTENANCE Remove Sear Station Burner ® To remove the Sear Station burner , pull the burner tube toward you . This removes it ® from the burner tube notch (10) . Then rotate the tube clockwise (11), so that the screw at the end of the tube (12) fits through the notch in the heat shield opening (13).

  • Page 35: Annual Maintenance

    Insect screens and burners are clean, replace the burners . If the Spider/Insect screen becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our web site . Log onto www .weber .com . Burner Flame Pattern The Weber gas barbecue burners have been factory set for the correct air and gas ®...
  • Page 36 ATTENTION: This product has been safety tested and is only certified for use in a specific country. Refer to country designation located on outer carton. These parts may be gas carrying or gas burning components . Please contact Weber-Stephen Products LLC Customer Service Department for genuine Weber-Stephen Products LLC replacement part(s) information .

This manual is also suitable for:

48529

Table of Contents