Page 1
STARTING MODEL YEAR 2019 ISSUED FEBRUARY 2019 ETECH DIVISION OF ZHONGSHAN ETECH ELECTRIC VEHICLE CO., LTD.. RESERVES THE RIGHT TO INCORPORATE ENGINEERING AND DESIGN CHANGES TO PRODUCTS IN THIS MANUAL WITHOUT OBLIGATION TO INCLUDE THESE CHANGES ON UNITS LEASED/SOLD PREVIOUSLY THE INFORMATION CONTAINED IN THIS MANUAL MAY BE REVISED PERIODICALLY BY THE ETECH DIVISION, AND THEREFORE IS SUBJECT TO CHANGE WITHOUT NOTICE.
FORWARD Thank you for the purchase of your ETECH H-Series Electric Vehicle. Your satisfaction with your new vehicle is important to all of us at ETECH. Please take the time to review this OWNER’S MANUAL and abide by all safety and operation warnings before allowing anyone to operate your new H-Series Electric Vehicle.
Page 3
TABLE OF CONTENTS The table of contents is empty because you aren’t using the paragraph styles set to appear in it. all rights reserved OWNER’S MANUAL 2019-O-M-001...
1. INTRODUCTION AND SAFETY INFORMATION This manual contains information for the proper operation and care of your vehicle. This vehicle has been designed and constructed with safety in mind, but improper operation can be hazardous. It is necessary to thoroughly review and understand the information contained in this manual in order to maximize your safety and enjoyment in the use of this vehicle.
Page 5
2. DESCRIPTION AND USE OF CONTROLS, INDICATORS & ACCESSORIES The H-SERIES vehicle includes the following controls, indicators and accessories: Off/On(POWER) switch ▪ ▪ Forward/reverse direction switch Charge status indicator ▪ ▪ Accelerator pedal ▪ Steering wheel ▪ Service brake pedal ▪...
This switch is located on the dashboard. To enable the vehicle drive system, insert the key into the key slot (OFF position) and turn clockwise to the ON position. In this position the vehicle electrical system also will be fully enabled. The headlights, tail lights and electrical accessories will be enabled.
2.5 STEERING WHEEL The steering wheel controls the direction in which the vehicle is driven. Turning the steering wheel clockwise will cause the vehicle to move to the right and turning the steering wheel counterclockwise will cause the vehicle to move to the left. ∆...
2.10 LOCKING GLOVE BOX The vehicle is equipped with a locking glove box at the right edge of the dashboard. There is a key switch that is used to unlock the glove box. 2.11 RUN/TOW SWITCH The Run/Tow switch is located on controller cover. When the Run/Tow switch is in the Run position, the controller and all operating features of the vehicle are enabled.
3. VEHICLE OPERATION 3.1 STARTING THE VEHICLE ▪ Select the direction of motion using the Forward/Reverse Direction Switch. NOTE ….When the reverse direction is selected a beeper will sound until the Forward/Reverse Direction Switch is moved to neutral or forward. Turn the power switch to the ON position to enable the vehicle electrical system.
Page 10
4. CHARGER INSTALLATION AND USE This vehicle is equipped with a built-in charger. This charger is mounted under the driver’s seat beside the batteries. A circuit must be dedicated to the charger. Information regarding appropriate circuit protection may be found in the charger manual. The charger output wires (DC cord) are connected to the batteries .Before beginning to charge the batteries, turn the power key to the OFF position.
5. VEHICLE CARE AND MAINTENANCE ∆ WARNING ….To avoid damage to the vehicle or severe injury or death DO NOT attempt any type of maintenance or servicing operations before reading and understanding all NOTES, CAUTIONS AND WARNINGS included in this manual. Servicing operations such as adjustments to the vehicle power train or the removal or installation of batteries should be performed by an authorized ETECH dealer or trained technician.
Page 12
1. Battery 2. Wire(long) 3. Wire(short) 4. Fixed screw 5. plastic insulation plate 6. spring washer 7. nut 5.2 MOTOR CARE AND MAINTENANCE ∆ CAUTION …Only an authorized ETECH dealer or qualified technician should be allowed to perform maintenance on the motor. Periodic removal of any materials that cling to the motor housing such as mud or grass is necessary to •...
Page 13
∆ CAUTION …Only an authorized ETECH dealer or qualified technician should be allowed to perform maintenance of the controller. Any attempt by a non-qualified individual to open or repair the controller may result in damage to the controller and void the warranty. The controller is located in the battery compartment on the passenger’s side (see the following figure).
Page 14
It is recommended that the DC/DC converter be kept clean and dry and that its fault history file be checked and cleared periodically. Periodically cleaning the DC/DC converter exterior will help protect it against corrosion and possible electrical control problems created by the dirt, grime, and chemicals that are part of the operating environment.
Page 15
PERIODIC SERVICE SCHEDULE √---CHECK C&A---CHECK&ADJUST CL---CLEAN R---REPLACE B e f 5 r o 2 0 r 6 0 r 1 2 5 2 5 0 o r e u n d nds/ nds/ rnds r n d e a c s / 5 /125 h r s...
6. TRANSPORTING THE VEHICLE ∆ WARNING ….To reduce the possibility of damage to the vehicle or severe injury or death never ride on a vehicle that is being hauled and take the following steps before hauling the vehicle: Remove the windshield from the vehicle. •...
7. TECHNICAL DATA HA2+2 Dimensions(M) 96*47*73 in(2440*1200*1850mm) 108*47*75 in(2740*1200*1900) Weight with Batteries(kg) 1212 lbs. (550 kg) 1367 lbs. (620 kg) Load Capacity(kg) 800 lbs. (360 kg) 800 lbs. (360 kg) Passengers Motor Power Letrika 48V 3.3 KW AC Letrika 48V 5.0 KW AC Controller power(R/min) Curtis 300A AC Curtis 300A AC...
Forward/Reverse Switch OTTO switch OTTO switch Feature and specification of vehicles subject to change without notice. Vehicles as photographed may include options not included on base model. 8. LIMITED WARRANTY ETECH 2019 HA2 CAR WARRANTY Vehicle Type Length of Warranty Coverage 24 MONTHS Frame 24 MONTHS...
Page 19
NOTES: 1: REFERENCE “EXCLUSIONS” SECTION OF THE WARRANTY FOR DETAILS. 2: EXCLUDES NORMAL WEAR AND TEAR. 9. LABELS & PICTOGRAMS all rights reserved OWNER’S MANUAL 2019-O-M-001...
Page 20
all rights reserved OWNER’S MANUAL 2019-O-M-001...
Page 21
10. MEMO all rights reserved OWNER’S MANUAL 2019-O-M-001...
Page 22
MEMO all rights reserved OWNER’S MANUAL 2019-O-M-001...
Page 23
MEMO all rights reserved OWNER’S MANUAL 2019-O-M-001...
Page 24
all rights reserved OWNER’S MANUAL 2019-O-M-001...
Vehicle Warranty Registration Card TO ACTIVATE YOUR VEHICLE WARRANTY COMPLETE AND RETURN Document Number THIS CARD WITHIN 10 DAYS OF PURCHASE.This is important 2019-O-M-001 information should we need to contact you about warranty changes or product information. Section 1.DEALER INFORMATION: [Dealer To Fill In This Information] Purchase Date Serial Number Dealer Name...