ULTRA LEGS Tri-Toon Installation Manual

Ultra Legs are a hydraulic leg lift that attaches to your pontoon, giving you the freedom and
®
range to take your lift anywhere you can take your pontoon. The Twin-Tube model operates
with two sets of legs, each set is strengthened by a reinforced crossbar and holds a sturdy
footpad. The Tri-Toon model comes complete with four separate legs. When not in operation,
the legs nestle within inches of the deck of your pontoon, invisible to the unknowing eye, yet
when operating, Ultra Legs
of the water in nearly any shallow water situation. Rocks, muck, wind and current are no match
for your new lift. Welcome to Ultra Legs
CAUTION:
Installation of Ultra Legs
a minimum of two people and requires access to the underside of the pontoon receiving the
Ultra Legs . Under no circumstances should installation be attempted in water as severe injury,
®
drowning or death may occur. Install only in a well-lit area on a hard, flat surface. Ultra Legs
require at minimum six feet above and in front of your pontoon to check product operation
during installation. Always wear appropriate protective equipment.
Do not begin installation until these requirements have been met.
Equipment Checklist:
Included in your Ultra Legs
• Ultra Legs Power Unit and Remote Control (1): 2.5 HP, 12VDC, uni-rotational electric motor for
®
raising and retracting lifting leg cylinders.
• Ultra Legs Leg Component (4): Leg Components with 3500 psi and solid steel Hydraulic
®
Cylinder construction.
• Ultra Legs Oil
®
o 2.5 Gallon Bottle (1): Used for initial installation.
o 1 Gallon Bottle (1): Used for initial installation.
• Ultra Legs Installation Kit
®
o 360" Hydraulic Hose (1)
o 252" Hydraulic Hose (2): Purple, Purple/Brown
o 192" Hydraulic Hose (3): Orange, White, Orange/White
o 96" Hydraulic Hose (2)
o 28.5" Hydraulic Hose (2)
o 12" Hydraulic Whip Hose (4)
o 15' Battery Cables (2): Red, Black
o 5/16" x 1" Zinc-plated Hex Lag Screw (4)
o 5/16 – 18 x 1" Hex Cap Bolts (56)
o 5/16 – 18 Flange Lock Nut (56)
o #8 x 1" Stainless Steel Screws (9)
o Cable Tie with Eye (5)
o Cable Tie without Eye (10)
o T-Fitting (2)
o 90° Fitting (8)
gives your boat up to six feet of lift, keeping it safe, secure and out
®
.
®
should be done only by trained and authorized professionals, needs
®
package should be the following:
®
www.ultralegs.com
Ultra Legs Tri-Toon
®
Installation Guide
3006.4611
®
1