1. Manuals
  2. Brands
  3. Graco Manuals
  4. Paint Sprayer
  5. 233001
  6. Instructions-parts list manual

Graco 233001 Instructions-Parts List Manual

45:1 king cart-mounted airless sprayers
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
INSTRUCTIONS-PARTS LIST
This manual contains important
warnings and information.
READ AND KEEP FOR REFERENCE.
INSTRUCTIONS
45:1 Kingt Cart-Mounted Airless Sprayers
Model 233001, Series A
45:1 King pump with outlet fluid filter and inlet air regulator
Model 233022, Series A
45:1 King pump with outlet fluid filter, inlet air regulator/filter, SilverR airless gun, and fluid hose
4050 psi (28 MPa, 283 bar) Maximum Fluid Working Pressure
90 psi (0.6 MPa, 6.2 bar) Maximum Input Air Pressure

Table of Contents

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440-1441
2
4
6
8
9
9
9
10
10
Model 233001
shown
ECOPYRIGHT 1999, GRACO INC.
Graco Inc. is registered to I.S. EN ISO 9001
309080
First choice when
quality counts.t
Rev. B
9478A

Advertisement

Table of Contents
loading

Related Manuals for Graco 233001

Summary of Contents for Graco 233001

  • Page 1: Table Of Contents

    ......Model 233001 shown 9478A GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440–1441 ECOPYRIGHT 1999, GRACO INC. Graco Inc. is registered to I.S. EN ISO 9001...

  • Page 2: Warnings

    D Read all instruction manuals, tags, and labels before you operate the equipment. D Use the equipment only for its intended purpose. If you are not sure, call your Graco distributor. D Check equipment daily. Repair or replace worn or damaged parts immediately.
  • Page 3 D Check the hoses, tubes, and couplings daily. Replace worn or damaged parts immediately. Do not repair high pressure couplings; you must replace the entire hose. D Use only Graco approved hoses. Do not remove the spring guard, which protects the hose from rupture caused by kinks or bends near the couplings.

  • Page 4: Setup

    The typical installation shown below is only a guide for selecting and installing system components and accessories. Contact your Graco distributor for assistance in designing a system to suit your needs. The pump requires 4.2 m#/min (150 scfm) of compressed air while operating at 90 psi (0.6 MPa, 6.2 bar) air pressure and 64 cycles per minute.
  • Page 5 Setup Airless Spray Gun Understanding Supplied Accessories Systems supplied with an airless spray gun are also supplied WARNING with gun instruction manual 308236. Before you spray, read the gun instruction manual. Spray some test patterns on scraps before you spray any permanent surfaces. See the A red-handled bleed-type master air valve (J) and a fluid gun manual for detailed spraying techniques.

  • Page 6: Operation

    The packing nut/wet-cup is shown in the Typical Installation CAUTION drawing on page 4. Keep it one-third full with Graco Throat Seal Liquid (TSL) (supplied with this sprayer). Do not allow the pump to run dry. It will quickly accelerate to a high speed and cause damage.
  • Page 7 Operation Priming the Pump Flushing The assumed starting point for this procedure is as follows: WARNING D Sprayer is set up, including fluid hose and gun, as shown in the Typical Installation drawing on page 4. Read Fire and Explosion Hazard on D Sprayer is grounded as explained in Ground the System page 3.

  • Page 8: Parts

    Parts 45:1 King Cart-Mounted Airless Sprayer, Model 233001, Series A (includes items 1 to 35) 45:1 King Cart-Mounted Airless Sprayer, Model 233022, Series A (includes items 1 to 41) Ref. Ref. Part No. Description Qty. Part No. Description Qty. 100131...

  • Page 9: Technical Data

    82.7 (dBa) 90.5 (dBa) (measured 1 meter from unit) Sound Power Level 86.5 (dBa) 88.8 (dBa) 97.7 (dBa) (measured per ISO 9614–2) Dimensions Model 233001 shown width across 26 in. 51.2 in. wheels (660 mm) (1300 mm) 28.1 in. (714 mm) 30.7 in.

  • Page 10: Graco Warranty

    Graco distributor to the original purchaser for use. With the exception of any special, extended, or limited warranty published by Graco, Graco will, for a period of twelve months from the date of sale, repair or replace any part of the equipment determined by Graco to be defective.

This manual is also suitable for:

233022

Table of Contents