Table of Contents
Related Manuals for Cosmo COS-640STX-E
Summary of Contents for Cosmo COS-640STX-E
- Page 1 GAS COOKTOP COS-850SLTX-E COS-640STX-E Drop-In Cooktop User & Installation Manual IMPORTANT: Read and save these instructions. NOTICE: Installer: Leave this guide with the homeowner Homeowner: Keep this guide for future reference Rev. 22.02...
- Page 2 DANGER COSMO appliances are designed according to the strictest safety and performance cooktop. IMPORTANT: To avoid damage to your standard for the North American market. We follow the most advanced...
-
Page 3: Table Of Contents
Statements of Installation, Electrical, Gas Requirements TABLE OF CONTENTS • A statement that the installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code, ANSI Z233.1/NFPA 54. INSTALLATION PREPARATION • A statement that the installation of this cooktop for manufactured (mobile) ELECTRICAL REQUIREMENTS home must conform to the Manufactured Home Construction and Safety Standard, Title 24 CFR, Part 3280 (formerly the Federal Standard for Mobile... -
Page 4: Installation Preparation
Surface Burner Grates (3) Cooktop Burners and Caps (4) Cooktop Burners and Caps (5) fused to meet the requirements of the National Electrical Code, ANSI/NFPA 24" Model: COS-640STX-E 30" Model: COS-850SLTX-E 24" Model: COS-640STX-E 30" Model: COS-850SLTX-E No. 70— Latest Edition. You can get a copy by writing: National Fire Pro-... -
Page 5: Installation Options
Use cabinets no more than 13” deep. Maintain 30” minimum clearance between cooktop and unprotected cabinets or exhaust hood directly above the COS-640STX-E; maintain 34" for the COS-850SLTX-E cooktop. If clearance is less than 30”, protect cabinet bottoms with flame-retardant millboard at least 1/4”thick, or gypsum board at least 3/16”... -
Page 6: Power Supply Locations
POWER SUPPLY LOCATIONS Install a manual shut-off valve in the gas line in an easily accessible location outside the cooktop. Be sure you know how and where to shut off the gas supply to the cooktop. Install the electrical outlet 12” below the countertop. Gas supply: These cooktops are shipped from the factory set for either natu- ral gas or LP gas. -
Page 7: Installation Instructions
2- INSTALL PRESSURE REGULATOR INSTALLATION INSTRUCTIONS A. Screw the regulator onto the burner box bottom pipe connection. Make 1- INSTALLING THE COOKTOP sure the top of the regulator is facing toward the cabinet front and the arrow on the back of the regulator points to the cooktop. A. -
Page 8: Assemble Burners, Check Ignition
3- CONNECT ELECTRICAL The gas inlet is located on the bottom of the burner box at the rear and center. Make gas connection through rear wall, or on cabinet floor at rear, as illustrated. A. Check to be sure the receptacle is properly grounded. 1. -
Page 9: Adjust Burner Flames
D ) Check igniters. ADJUST BURNER FLAMES · Operation of the electric igniters should be tested after the cooktop and supply line have been carefully checked for leaks and the cooktop has been connected to the electrical power. A. Turn all burners on highest setting and check the flames. They should be ·... - Page 10 2. Remove the retainer pin that is currently positioned for use with Natural Gas. CONVERT COOKTOP TO LP GAS 3. Turn the retainer pin upside down and replace it into the regulator cap. It is WARNING now positioned for use with LP gas. This conversion kit shall be installed by a qualified service agency in accordance with the manufacturer's instructions and all applicable codes and requirements of the authority having...
- Page 11 IMPORTANT: Carefully read and observe each orifice label for correct location. 1. Remove the burner grates, burner caps and burner heads. See the Burner Chart in this section. 2. Using a 7 mm nut driver, remove the burner orifices. 24" Model: COS-640STX-E Orifice Orifice Size (091 - Denotes 0.91mm) 30"...
-
Page 12: Care And Cleaning
CARE AND CLEANING CARE AND MAINTENANCE CLEANING COOKTOP IMPORTANT Removing Burner Grates: 1. The burner grates are located in the recessed area of the cooktop. To avoid possible burns use care when cleaning the cooktop. DO NOT 2. They can be removed for cleaning by carefully lifting them from the attempt to clean the cooktop whenever the cooktop or burner heads are cooktop. -
Page 13: Warranty And Service
REQUIRED FOR WARRANTY SERVICE IMPORTANT Ne pas Réexpédier ce Produit au Magasin WARRANTY AND SERVICE Pour tout problème concernant ce produit, veuillez contacter le service des consommateurs Cosmo Customer Support au For full warranty details on this product please 1-888-784-3108. visit: http://www.cosmoappliances.com/warranty UNE PREUVE D’... - Page 14 Cosmo is constantly making efforts to improve the quality and performance of our products, so we may make changes to our appliances without updating this manual. Electronic version of this manual is available at: www.cosmoappliances.com...
Need help?
Do you have a question about the COS-640STX-E and is the answer not in the manual?
Questions and answers