Advertisement
Quick Links
BUILT-IN ROUND WELL WARMERS WITH
THERMOSTAT CONTROL
(Insulated & Non-Insulated)
MODELS:
SM-50-4ULS, SM-50-4DULS, SM-50-7DS, SM-50-7ULS,
SM-50-7DULS, SM-50-11S, SM-50-11DS, SM-50 11DULS
OWNERS MANUAL
2M-Z24236 REV A (03-22)
This manual includes material related to installation, use , cleaning, and care. Exploded view[s], as well as any available
parts list[s] and wiring diagram[s] pertaining to the unit[s] covered by this manual are also included.
This manual must be read and understood by all persons using or installing this appliance. Contact your APW Wyott
dealer if you have any questions concerning installation, use, or maintenance of this equipment.
DO NOT DISCARD THIS MANUAL.
is a registered trademark of APW Wyott®, A Middleby Company. All rights reserved.
Advertisement
Related Manuals for APW Wyott SM-50-4ULS
Summary of Contents for APW Wyott SM-50-4ULS
- Page 1 This manual must be read and understood by all persons using or installing this appliance. Contact your APW Wyott dealer if you have any questions concerning installation, use, or maintenance of this equipment.
- Page 2 LIMITED EQUIPMENT WARRANTY WARRANTY EXCLUSIONS APW warrants to the original purchaser of new APW's products to be THE FOLLOWING WILL NOT BE COVERED UNDER WARRANTY. free from defects in material or workmanship, under normal and proper APWs’ sole obligation under this warranty is limited to either repair use and maintenance service as specified by APW and upon proper or replacement parts, subject to the additional limitations installation and start-up in accordance with the instructions...
- Page 3 14-15 CUSTOMER SERVICE DATA INTRODUCTION Thank You for purchasing this APW Wyott appliance. Proper installation, professional operation and consistent maintenance of this appliance will ensure that it gives you the very best performance and a long, economical service life. This manual contains the information needed to properly install this appliance, and to use and care for the appliance in a manner which will ensure its optimum performance.
- Page 4 FEATURES & OPERATING CONTROLS A. THERMOSTAT On THERMOSTATICALLY CONTROLLED warmers, power is applied to the heating element according to the control knob position and the actual temperature at the temperature sensing thermobulb. INDICATOR LIGHT The desired temperature is controlled by rotating the TEMPERATURE CONTROL KNOB.
- Page 5 Do not operate this appliance if the control panel is damaged. Call read and followed. Damage your Authorized APW Wyott Service Agent for service. to the appliance may result The technical content of this manual, including any wiring diagrams,...
- Page 6 INSTALLATION NOTE: DO NOT discard UNPACKING & INSPECTION the carton or other packing Carefully remove the appliance from the carton. Remove all materials until you have protective plastic film, packing materials and accessories from the inspected the appliance for Appliance before connecting electrical power or otherwise performing hidden damage and tested it any installation procedure.
- Page 7 INSTALLATION continued 4. For “top-mounted” warmers (i.e. warmers mounted from above the counter top): a. Verify that provided sealants are applied to the underside of the warmer top flange prior to setting the unit into the cutout. b. After installation, verify that the tabs on the E-Z Lock are turned out to lock the warmer into the counter c.
- Page 8 These units will contain water with AUTOFILL units require a drain valve (not supplied by APW Wyott) to temperatures in excess of be installed in order to operate correctly.
- Page 9 SHOCK HAZARD APW Wyott Manufacturing recommends operating WET for consistent food heating. DO NOT splash or pour water If your wet-operation warmer is allowed to run dry, turn it OFF and onto control panel or wiring.
- Page 10 OPERATION continued CAUTION: AUTOFILL WARMERS HOT SURFACE Autofill warmers sense water level by a sensor placed at the proper level. For manifolded autofill warmers, the water level sensor / fill tube is in one pan only. Exposed surfaces can be hot Water fills the pan through an inlet tube.
- Page 11 MAINTENANCE INSTRUCTIONS CARE OF STAINLESS STEEL Stainless steel is a marvelous material: strong, lustrous and low maintenance. With a minimum of care, it will normally retain its beauty and durability for the life of the equipment. In some applications, however, special care is required in order to maintain stainless steel’s special properties.
- Page 12 Contact your Authorized APW Wyott Service Agency to inspect warmer if water or grease contamination is suspected. Close drain valve. Add proper amount of warm water. Turn control...
- Page 13 CLEANING INSTRUCTIONS CAUTION: WEEKLY CLEANING INSTRUCTIONS CHEMICAL BURN PREPARATIONS: Remove any insets, pans and/or adapter tops. HAZARD Drain or remove water from well if used for wet Delimng chemicals may be operation. caustic. Wear appropriate personal protective equipment. FREQUENCY: Weekly, or whenever lime or scale is seen Follow cleaner manufacturer’s accumulating on the sides of the warmer pans.
- Page 14 One or more pans of an Blocked drain manifold Clean drain manifold auto-fill unit do not fill There are no user-serviceable components in this appliance. In all instances of damage or malfunction, contact your Authorized APW Wyott Service Agency for repairs.
- Page 15 WIRING DIAGRAM...
- Page 16 EXPLODED VIEW & PARTS LIST SM-50-7S and SM-50-11S with & without Drain Model: SM-50-4S, SM-50-7S & SM-50-11S (w & w/o Drain) IL1904 Rev. F 4/08/15 SM-50-4ULS, SM-50-7ULS & SM-50-11ULS (w & w/o Drain)
- Page 17 PARTS LIST SM-50-4S, SM-50-7S & SM-50-11S units with & without drain 05/12 REV - Model: SM-50-4S, SM-50-7S, SM-50-11S (Insulated & non-insulated) with & without Drian Fig No Part No. Description Application 2V-Z17446 Drain Screen Drain Units WS-63527 SM-50-4S WS-50391 Pot Assembly SM-50-7S WS-51232 SM-50-11S...
- Page 18 20822 or to order factory authorized ADAPTER TOP, convert SM-50-11 to hold 7 qt. inset 20175 replacement parts, contact your APW Wyott authorized service 4 QT. ROUND INSET w/ lid 20774 agency, or call: 7 QT. ROUND INSET w/ lid 20587 11 QT.
- Page 19 NOTES...
- Page 20 Printed in the U.S.A. • 2M-Z24236 • REV A (03-22) Specifications are subject to change without notice. 265 Hobson St. • Smithville, TN 37166 Telephone: (800) 527-2100 is a registered trademark of APW Wyott®, A Middleby Company. All rights reserved.