Related Manuals for ista Breeze i-700
Summary of Contents for ista Breeze i-700
- Page 1 TRANSLATION OF THE ORIGINAL INSTRUCTIONS - Keep handy at the place of use - Wind turbine system i-700, i-1000 SAVE ENERGY SAVE PLANET...
-
Page 2: Table Of Contents
Earth Safe - Contents - Contents ....................General....................About this translation of the original instructions ........2.1.1 Revision status of the original instructions ..........2.1.2 Conditions for installing and operating the wind turbine system ....2.1.3 Availability of the instructions............... Conventions used in this translation of the original instructions.... - Page 3 Earth Safe Requirements at the place of use ............... 7.2.1 Permissible wind class, footprint and minimum clearances ......12 7.2.2 Tower foundation ..................Unpacking the components ................ Assembling the wind turbine..............Electrical connections ................. Erecting the wind turbine ................Normal Operation .................. Switching on the wind turbine system............
-
Page 4: General
Earth Safe - General - About this translation of the original instructions 2.1.1 Revision status of the original instructions Revision date: ..................24.07.2018 Revision index: ..................2.1.2 Conditions for installing and operating the wind turbine system Please make sure that •... -
Page 5: Other Symbols Used
Earth Safe 2.2.1 Other symbols used The following symbols are used in this translation of the original instructions as well as on the wind turbine system itself: Warning signs General warning! Danger: High voltage! May start without warning! Environmental hazard! Table 1 Warning signs Mandatory signs Read manual before operating! -
Page 6: Warranty And Liability
• Operation outside the manufacturer’s specification • All modifications or changes to the wind turbine system without the manufacturer’s written approval! • Use of parts other than iSTA Breeze original parts. • Operation in non-approved SWTS classes. • Operation in strong winds or hurricanes. -
Page 7: Main Components
When pressed, the wind turbine must be short- Emergency Stop Button circuited. (optional) Generates electrical voltage (12 / 24 / 48 VDC). Charge controller The iSTA Breeze charge controller. (optional) Type : i/HCC 800 Battery (optional) Stores electrical energy (Acid, Gel) Solar panels... -
Page 8: Main Components Of The Wind Turbine
Earth Safe Main components of the wind turbine Main components of the wind turbine Fig. 2: Component Quantity Nose Rotor blade Hub for holding the blades Generator for producing electricity Boom for wind direction flag Tail vane for turning the blades into the wind Adapter stud ∅... -
Page 9: Technical Data
EarthSafe - Technical D ata - Designation i-700 i-1000 Generator Permanent magnet rotor, brushless, gearless, maintenance- Type free Weight [kg] 18,5 Max. power [12V] 0 - 40 Open circuit voltage [VAC] [24V] 0 - 110 [24V] 0 - 80 [48V] 0 - 190... -
Page 10: Charge Controller I/Hcc800 - İ/Hcc1000
Earth Safe - Charge Controller i/HCC 800 - i/HCC 100 0 - The Wind / Solar Hybrid Charge Controller from IstaBreeze® is an intelligent controller of the wind turbine and solar cells that controls you at the same time. The high-end device thus controls your island system. -
Page 11: Permissible Operating And Storage Conditions
Modifications or changes by the user The wind turbine system is in conformity with the European Machinery Directive 2006/42/EC provided only original iSTA Breeze components are used and subject to proper erection. The use of components from other manufacturers as well as... -
Page 12: Preparing To Use The System
EarthSafe - Preparing to use the S ystem - Shipping As-delivered condition 7.1.1 The wind turbine system is shipped disassembled. Scope of supply 7.1.2 Refer to the contract documentation for the scope of supply. Requirements at the place of use Permissible wind class, footprint and minimum clearances 7.2.1 WARNING! -
Page 13: Tower Foundation
Earth Safe Tower foundation 7.2.2 Design of the foundation for erecting the tower Fig. 4: The soil must have a sufficient load-bearing capacity. The size and structure of the foundation depend on the soil characteristics. Recommendation: Ask a qualified structural engineer for advice regarding the optimal design of the foundation. -
Page 14: Unpacking The Components
EarthSafe Unpacking the components Carefully open the packaging. Check the shipment for completeness (refer to the shipping documents). Separate the packaging material and dispose of it in an environmentally responsible way. Assembling the wind turbine WARNING! Danger due to rotor imbalance! ... -
Page 15: Electrical Connections
EarthSafe Balancing the rotor (Y position) Fig. 7: Move rotor to Y position (see Fig. 7) Carefully release rotor blade. Observe in which direction the rotor turns (the heavier rotor blade pushes downwards). Repeat the process for all three positions to determine which rotor blade is in imbalance. ... -
Page 16: Erecting The Wind Turbine
WARNING! Danger due to unsuitable tower constructions! Only use tested mast constructions or original iSTA Breeze masts. Attach the wind turbine to the tower. Be careful not to damage the cable. Bolt the wind turbine to the tower. -
Page 17: Normal Operation
Unlock the emergency stop button or release the brake button on the iSTA Breeze charge controller. The brake is released. The fast-blinking red LED on the iSTA Breeze charge controller goes out. The wind turbine system supplies power. Restart after an emergency ... -
Page 18: Maintenance
EarthSafe - Maintenance - Safety precautions during maintenance work 10.1 WARNING! Risk of injury when carrying out maintenance work! Shut down the wind turbine system prior to all maintenance work. Take steps to prevent the wind turbine system from being switched on again by unauthorised persons. -
Page 19: Troubleshooting And Diagnostics
Earth Safe - Troubleshooting and D iagnostics - 11.1 Errors with LED Error messages are displayed on the iSTA Breeze charge controller. Refer to the separate instructions. 11.2 Errors without LED Error Possible cause Possible actions Not enough wind ... -
Page 20: Removal From Service And Disposal
Earth Safe - Removal from S ervice and D isposal - 12.1 Final decommissioning of the wind turbine system WARNING! Risk of injury due to unqualified dismantling, e.g. • Persons without suitable training • Stored energy • Breakage during dismantling Important note on dismantling and disposal: ... -
Page 22: Declaration Of Conformity
Earth Safe - Index - Adapter stud ..........8 Place of use ........... 11, 12 Rotor blade ........8, 9, 14, 15, 18,19,21 Battery ..........7, 10, 19, 20 Strain relief ..........Cable cross-section ....... 15, 19 Charge controller ....7, 10, 15, 17, 19,20 Tail vane ............. -
Page 23: Notes
Earth Safe - Not es - 24 of 2 8 Translation of the original instructions iSTA wind turbine system 2 4 .0 7 .201 8 I00... -
Page 24: Performance Charts
EarthSafe - Performance Charts - Translation of the original instructions iSTA wind turbine system 2 4 .0 7 .201 8 I00 25 of 2 8... -
Page 25: Certificates
Earth Safe - Certificates - 26 of 2 8 Translation of the original instructions iSTA wind turbine system 2 4 .0 7 .201 8 I00... -
Page 26: Suitable Battery Capacities
Min. 150 Ah - Max. 200 Ah Air Speed 24V / i-500 24V / L-500 24V Min. 2x75 Ah - Max. 2x100 Ah i-700 12V Min. 200 Ah - Max. 300 Ah i-700 24V Min. 2x100 Ah - Max. 2x150 Ah i-700 48V Min. - Page 27 Ul.Stancıonna No. 64 Et.2 · BG-8500 Aytos / BULGARIA +359 87 7819900 www.istabreeze.com © ISTA Breeze – No part of this document may be copied or reproduced 24.07.2018 I00 Translation of the original instructions iSTA wind turbine system...
Need help?
Do you have a question about the i-700 and is the answer not in the manual?
Questions and answers