Maintenance - UTICA BOILERS MACF-150 User's Information Manual

WARNING
!
Asphyxiation hazard. Contact qualified agency if
condensate trap is not filled with water.
Perform general housekeeping and maintenance as
specified below.
4.1 Continuous
• Keep boiler area free from combustible materials,
gasoline and other flammable vapors and liquids.
• Keep combustion air and vent terminations (outside
building) free from trash, vegetation and other items
capable of blocking flow.
CHECK LIST
If a fault develops, or is suspected, call your Service
Technician as soon as possible. Go through the following
check list before you contact Service Agency.
• Is electricity supply on?
• Is symbol displayed?
• Is display ON and symbols
• Is gas supply on?
• Is main water supply turned on?
• Is system pressure correct?
• Are boiler temperature controls set high enough?
• Is room thermostat (if fitted) set high enough?
• Are radiator valves open?
4.2 Monthly
• Inspect combustion air, vent, and condensate drain
piping for deterioration, leaks or sagging. Contact
qualified agency, as necessary.
• Inspect system piping for leaks. Contact qualified
agency, as necessary.
• Inspect condensate drain trap for sediment or
blockage. Contact qualified agency if cleaning
required.
• Check air vent(s) for leakage.
• Follow OPERATING INSTRUCTIONS to return to normal
operation.

4 - MAINTENANCE

Burn and scald hazard. Verify Safety Relief Valve
discharge piping run to safe discharge location before
conducting maintenance procedure. Contact qualified
agency to correct improper piping.
4.3 Check According to Manufacturer's
Instructions
Safety Relief Valve - Refer to manufacturer's instructions.
4.4 Annually or Beginning Each Heating Season
displayed?
4.5 End of Heating Season, if boiler not used for
domestic hot water
• Follow instructions to TURN OFF GAS TO APPLIANCE.
• Contact qualified agency to drain heating system (if
7
WARNING
!
• Contact qualified agency to perform maintenance and
cleaning per Installation, Operation and Maintenance
manual. Inspection will include examining all flue
product carrying areas, vent system, burner and heat
exchanger.
• Will also include filling boiler with water if drained as
part of End of Heating Season procedure.
• Condensate trap may require cleaning and refilling.
See section 2.
system does not use antifreeze) and condensate trap
if heating system is exposed to freezing temperatures
while out of service.
PN 240011945 Rev. B [01/31/19]