Ice-O-Matic ICE2100 Series Installation, Start-Up And Maintenance Manual

Hide thumbs Also See for ICE2100 Series:

Service and installation manual (164 pages)

Installation and maintenance manual (26 pages)

Service and installation manual (143 pages)

Table Of Contents

Installation, Start-Up and Maintenance Manual

ICE SERIES CUBERS

ICE0250 through ICE2100 Series*

ICEU150, ICEU220 and ICEU300 Undercounter Series*

ICE0320 and ICE0520 22 Inch Series*

*INCLUDES 230/50/1 VOLT UNITS

Ice-O-Matic

11100 East 45th Ave

Denver, Colorado 80239

Part Number 9081264-01

Date 11/08

Table of Contents

Summary of Contents for Ice-O-Matic ICE2100 Series

Page 1 Installation, Start-Up and Maintenance Manual ICE SERIES CUBERS ICE0250 through ICE2100 Series* ICEU150, ICEU220 and ICEU300 Undercounter Series* ICE0320 and ICE0520 22 Inch Series* *INCLUDES 230/50/1 VOLT UNITS Ice-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081264-01 Date 11/08...
Page 3 Series (electro-mechanical) cube ice machines. Do not attempt to perform installation, start-up or maintenance unless you have read and fully understand this manual. If at any time you encounter conditions that are not addressed in this manual, call, E-mail or write the Ice-O-Matic Service Department: Ice-O-Matic 11100 E.
Page 4: Table Of Contents
ICE Series Table of Contents Introduction Page i Table of Contents Page ii Freight Claim Procedure Page iii Warranty Page iv Model Number and Serial Number Format Page 1 Installation Guidelines Page 2 Remote Condenser Guidelines Page 4 Electrical and Plumbing Requirements Page 6 How the Machine Works Page 13...
Page 5 If loss or damage does not appear until merchandise has been unpacked, make a written request for inspection by the carrier within 15 days of the delivery date. Then file a claim on a form from the carrier. File Claim Without Delay Do Not Return Damaged Merchandise to Ice-O-Matic Page iii...
Page 6: Warranty
Company-authorized distributor, without cost to the Customer, that part of any such machine that becomes defective. In the event that the Warranty Registration Card indicating the installation date has not been returned to Ice-O-Matic, the warranty period will begin on the date of shipment from the Company.
Page 7: Model Number And Serial Number Format
Series: Environmental Cuber (Uses HFC Refrigerant) This format is 14 characters long and begins with a date code followed by the Ice-O-Matic identifier, and then a sequential number. This is an entirely numerical serial number. The serial number will look like the example.
Page 8: Installation Guidelines
Self-contained air cooled ice machines must have a minimum of 6 inches (15cm) of clearance at the rear, top, and sides of the ice machine for proper air circulation. Stacking If the ice machines are to be stacked, refer to the instructions in the stacking kit. Ice-O-Matic does not endorse stacking air-cooled ice machines. Dispenser Application A thermostatic bin control kit should be installed if the ICE Series ice machine is placed on a dispenser.
Page 9 If the ice machine is too far forward on the bin, the opened door may not be stable, resulting in an unexpected closing of the bin door. If the ice machine is to be mounted on a bin or dispenser other than an Ice-O-Matic, refer to the manufacturers instructions for machine mounting.
Page 10: Remote Condenser Guidelines
Remote Condenser Guidelines Remote Condenser Installation For proper operation of the Ice-O-Matic ice machine, the following installation guidelines must be followed. Failure to do so may result in loss of production capacity, premature part failure, and may void all warranties.
Page 11 Mixing Valve (Head Master). Only one valve is required per system. Kits are available to modify the condenser for compatibility. For more information contact your Ice-O-Matic Distributor. 34 ft. horizontal 10 ft. drop 10 ft.
Page 12: Electrical And Plumbing Requirements
ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICEU150, 220, 225 and 226 31.00 Note: The ICEU150, 220, 225 and 226 do not have a splash curtain. These models utilize a thermostatic bin control in place of a mechanical bin switch.
Page 13 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICEU300 and 305 Note: The ICEU300 and 305 do not have a splash curtain. These models utilize a thermostatic bin control in place of a mechanical bin switch. ON-OFF-WASH Switch is located in the control box.
Page 14 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICE0250, ICE0400, ICE0500 and ICE0600 Page 8...
Page 15 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICE0800 and ICE1000 Page 9...
Page 16 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICE1400, ICE1800 and ICE2100 Page 10...
Page 17 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICE0320 and ICE0520 Page 11...
Page 18 ICE Series Electrical and Plumbing Requirements Electrical and Plumbing Requirements: ICE1506 Remote Page 12...
Page 19: How The Machine Works
ICE Series How the ICE Machine Works How the ICE Machine Works A general description of how the ICE Series cubers works is given below. With the ICE/OFF/WASH switch in the ICE position, the compressor, water pump and condenser fan motor (when applicable) will energize starting the freeze cycle.
Page 20: Start-Up Procedure
ICE Series Start-Up Procedure Start-Up Procedure Before starting the machine, make sure the machine is level within 1/8 inch in all directions, the bin or dispenser leg height can be adjusted by rotating the leg foot. Check the water level in the water trough. It should be approximately ½ inch above the top of the water pump impeller housing.
Page 21 ICE Series Start-Up Procedure Bin Control Operation The bin control is used to shut the machine off when the bin fills with ice. The bin control must be checked upon installation or initial start-up and when performing maintenance. Adjustments are not covered under warranty. There is one bin switch for each evaporator.
Page 22: General Maintenance
ICE Series General Maintenance Electrical shock and/or injury from moving parts inside this machine can cause serious injury. Disconnect electrical supply to machine prior to performing any adjustments or repairs. Failure to perform the required maintenance at the frequency specified will void warranty coverage in the event of a related failure.
Page 23: Cleaning Procedure
ICE Series Cleaning Procedure ICE Machine Cleaning and Sanitizing Instructions It is the USER’S RESPONSIBILITY to see that the unit is properly maintained. It is always preferable and less costly in the long run, to avoid possible down time by keeping it clean and adjusted as needed; and by replacing worn components before they can cause failure.
Page 24: Cabinet Care
ICE Series Cabinet Care Cleaning stainless steel Commercial grades of stainless steel are susceptible to rusting if not properly maintained. It is important that you properly care for the stainless steel surfaces of your ice machine and bin to avoid the possibility of rust or corrosion. Use the following recommended guidelines for keeping your stainless steel looking like new: 1.
Page 25: Winterizing Procedure
ICE Series Winterizing Procedure Winterizing Procedures Important! Whenever the ice machine is taken out of operation during the winter months, the procedure below must be performed. Failure to do so may cause serious damage and will void all warranties. 1. Turn off water to machine. 2.
Page 26: Maintenance Record
ICE Series Service History Service History Model Number__________________Serial Number__________________Date Installed__________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________...

Ice-O-Matic ICE2100 Series Installation, Start-Up And Maintenance Manual

Table of Contents

Related Manuals for Ice-O-Matic ICE2100 Series

Summary of Contents for Ice-O-Matic ICE2100 Series

This manual is also suitable for:

Table of Contents