Table of Contents
Advertisement
Quick Links
09-JUL-2007
05-JAN-2009 2009-0003 Notification:
Change in Registrant Address
TRIOPURE-25 CHLORINE GENERATOR CONTROLS BACTERIA AND
MAXIMUM OUTPUT OF HYPOCHLOROUS ACID EQUIVALENT TO 0.20 Kg
FOR SWIMMING POOLS, A MINIMUM OF 1 ppm OF FREE AVAILABLE
CHLORINE MUST BE MAINTAINED AND FOR SPAS A MINIMUM OF 3 ppm
Notification Change
WARNING: OPERATING THE TRIOPURE-25 WITHOUT WATER FLOW
THROUGH THE CELL CAN CAUSE A BUILD UP OF FLAMMABLE GASES
REPLACEMENT CELL FOR THE CHLORINE GENERATING DEVICE TRIOPURE-25
REGISTRATION NUMBER 28566, PEST CONTROL PRODUCTS ACT. THIS CELL MUST BE USED
READ THE LABEL, THE INSTALLATION MANUAL AND OPERATION MANUAL OF THE CHLORINE
LABEL FOR THE TRIOPURE-25
ALGAE IN DOMESTIC SWIMMING POOLS (SPA) WATERS
A MAXIMUM OF 57,000 L OF WATER CAN BE TREATED WITH ONE
OF FREE AVAILABLE CHLORINE PER DAY
OF FREE AVAILABLE CHLORINE MUST BE MAINTAINED
READ THE LABEL AND OPERATING MANUAL BEFORE USING
KEEP OUT OF REACH OF CHILDREN
REGISTRATION NUMBER 28566 PEST CONTROL PRODUCTS ACT
3580 Sueldo Street
DEL OZONE, 3428 BULLOCK LANE, SAN LUIS OBISPO, CA 93401
WHICH CAN RESULT IN FIRE OR EXPLOSION.
LABEL FOR THE TRIOPURE-25
REPLACEMENT CELLS
TRIOPURE-25 REPLACEMENT CELL
ON THIS MODEL OF CHLORINE GENERATING DEVICE
GENERATING DEVICE TRIOPURE-25 BEFORE USING
3580 Sueldo Street
DEL OZONE, 3428 BULLOCK LANE, SAN LUIS OBISPO, CA 93401
ENGLISH
TRIOPURE-25.
1-800-676-1335
ENGLISH
1-800-676-1335
Advertisement
Table of Contents
Related Manuals for Del ozone TrioPure 25
Summary of Contents for Del ozone TrioPure 25
- Page 1 Notification Change REGISTRATION NUMBER 28566 PEST CONTROL PRODUCTS ACT 3580 Sueldo Street DEL OZONE, 3428 BULLOCK LANE, SAN LUIS OBISPO, CA 93401 1-800-676-1335 WARNING: OPERATING THE TRIOPURE-25 WITHOUT WATER FLOW THROUGH THE CELL CAN CAUSE A BUILD UP OF FLAMMABLE GASES WHICH CAN RESULT IN FIRE OR EXPLOSION.
- Page 2 09-JUL-2007 TrioPure 25 Soft Water Sanitation System Installation and Operation Manual DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459 110105 / 4-0777 Rev E.
-
Page 3: The Triopure Tm
WARNING: To reduce the risk of injury, do not permit children to use this product. This device must not be used with any bromine- based pool or spa sanitizing products due to potential formation of by-products that may be of health concern. SAVE THESE INSTRUCTIONS! DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... - Page 4 TrioPure Sanitation System ADDENDUM FOR CANADIAN TRIOPURE INSTALLATIONS The following information is for Canadian installations of the TrioPure and takes precedence over other information in the manual. WARNING: Heavy pool (or spa) usage and higher temperatures may require higher chlorine output to maintain proper free available chlorine residuals.
-
Page 5: Table Of Contents
7D Limited Warranty .............. 24 3H When to Add Salt .............. 12 SECTION 4 The TrioPure is ETL Certified. Operation 4A Initial Start-Up Procedure ..........13 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459 022105 / 4-0777... -
Page 6: General Information
Water Flow Rate: 19 LPM Salinity: 3,000-5,000 ppm (3,500 Nominal) Illustration 1 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 7: Verify Contents
Contact your local pool equipment dealer or visit DEL Ozone’s tion dampening material to reduce vibration noise. website at www.delozone.com to find one near you. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 8: Mounting The Triopure Tm
Pool Spa Combo NOTE: The bypass manifold must be mounted horizontally to prevent bubbles from returning to the TrioPure pump and Solar - See Figure 9 tripping the flow switch. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 9: 2E-3 Plumbing Configuration Figures (1-9)
· Del recommends installing 2 cm (¾”) ball valves on the inlet and outlet of the Triopure to facilitate Salt Cell removal for cleaning and a ball valve after the Bypass Manifold to control water flow through the Salt Cell. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... - Page 10 · Del recommends installing 2 cm (¾”) ball valves on the inlet and outlet of the Triopure to facilitate Salt Cell removal for cleaning and a ball valve after the Bypass Manifold to control water flow through the Salt Cell. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
- Page 11 · Del recommends installing 2 cm (¾”) ball valves on the inlet and outlet of the Triopure to facilitate Salt Cell removal for cleaning and a ball valve after the Bypass Manifold to control water flow through the Salt Cell. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
- Page 12 · Del recommends installing 2 cm (¾”) ball valves on the inlet and outlet of the Triopure to facilitate Salt Cell removal for cleaning and a ball valve after the Bypass Manifold to control water flow through the Salt Cell. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
- Page 13 TrioPure must be plumbed after it. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
-
Page 14: Electrical
Control Knob and unscrewing four (4) Phillips head 6-32 the left side of the TrioPure screws. Locate the terminal block (TB-1). Figure - 10 Terminal Block 120 V Configurations Figure - 11 Terminal Block 240 V Configurations DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 15: Pool Preparation
It is easy to add more salt to your pool but difficult to remove excess salt through draining. CAUTION: Do not add salt to the skimmer box. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 16: Salt Sizing Table
112,500 121,875 131,250 140,625 150,000 159,375 168,750 178,125 187,500 1000 in PPM (mg/l) (30,000) (32,500) (35,000) (37,500) (40,000) (42,500) (45,000) (47,500) (50,000) 1250 1500 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459 1750... -
Page 17: When To Add Salt
Step 5 – Add salt directly to the pool [DO NOT add to the skim- mer box] by dispersing it around the outside edge of the pool. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 18: Initial Start-Up Procedure
3. Low Salt Indicator 8. On/Off Switch 4. High Salt Indicator 9. Fuse (right side) 5. Ozone Production Indicators 10. Serial Number # (left side) DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... - Page 19 All above LEDs should be green. If any LEDs are red, please see the Troubleshooting section, Chapter 6A for assistance. Step 7a - Observe that the Chlorine Production LED display reads ‘OF’. Figure 18 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
- Page 20 Step 11 - Check pool free chlorine levels every 24 hours, and adjust Chlorine Control knob as necessary to get between 1.0 and 3.0 ppm. Figure 21 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
-
Page 21: Monitoring & Maintenance
“too much chlorine”. green (water between 15 and 40°C (59-104˚F)). A red Water Temperature LED indicates water temperature is either too low or high. DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 22: 5B-3 Calcium Hardness And Total Alkalinity
(when the TrioPure is working correctly), have your water DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 23: Tm Maintenance
Note the order of disassembly and reverse for reassembly. Step 4 - Remove the Left Hand Side Attachment shaft by unscrewing the hand knob. Figure 23 - Acid Injection line DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 24: 5D-4 Air Filters
27). Once the cover is keeper. removed, visually check Air Exhaust the filter for debris. If the filter appears to require Figure 28 Figure 26 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... -
Page 25: Troubleshooting
Call for service. The ozone power supply. TrioPure will continue to work with the remaining ozone CD cells. Figure 31 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459... - Page 26 A) The salt chlorinator is Control display shows CL longer than twenty-four in Cleaning mode. (24) hours, contact our telephone support number, 800.676.1335 ext. 293, for service. Figure 34 DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
- Page 27 D) Main fuse is blown. above 5,000 ppm with the Chlorine Control knob Figure 37 set to full power (10). DEL Ozone · San Luis Obispo, CA 93401 · USA · 800-676-1335 · Fax: 805-541-8459...
-
Page 28: Contact, Ordering Information, Replace
Water flow & temp LED’s Authorization to return a unit or part to the plant of manufacture must be obtained from DEL Ozone Field Service. DEL Ozone will release a RETURN MATERIALS AUTHORIZATION (RMA) NUMBER. After receiving the RMA number, the product or part in question must be returned to Del Ozone, freight prepaid, with the RMA number clearly marked on the outside of the package. -
Page 29: Limited Warranty
The limited warranty set forth below applies to products manufactured by DEL Ozone – 3428 Bullock Lane, San Luis Obispo, Cali- fornia 93401, and sold by DEL Ozone or its authorized dealers. This limited warranty is given only to the first retail purchaser of such products and is not transferable to any subsequent owners or purchasers of such products. - Page 31 ****************************** This label transcript service is offered by the Pest Management Regulatory Agency to provide efficient searching for label information. This service and this information do not replace the official hard-copy label. The PMRA does not provide any guarantee or assurance that the information obtained through this service is accurate, current or correct, and is therefore not liable for any loss resulting, directly or indirectly, from reliance upon this service.