Page 2
All manuals and user guides at all-guides.com VERSION VARIATION Type /Versions: DCM3100 Service policy Board in used: (EUROPE) MAIN BOARD CD BOARD SMPS BOARD TUNER BOARD CD DOOR BOARD DISPLAY BOARD AUX BOARD IPOD BOARD USB BOARD Type /Versions: DCM3100...
Page 3
INTERCONNECTION POSSIBILITIES Pos. Connection/Function Connector type Electrical data (input or R.O.P) ACCESSORIES : (1) REMOTE CONTROL (2) SPEAKER BOX (X2PCS) (3) LINE IN CABLE REMARKS : Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2011-08-15 Tot.Sh.: SHEET 1 Check: Date:...
Page 4
Tested according to General Test Instruction UAN-D1591 Measured According to UAN-L1059 unless otherwise stated All not mentioned data, please refer to PQR XUW-0010-JUNE 2001 DERIVED VERSION APPROBATION REMARKS GENERAL SPECIFICATION Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2010-08-15 Tot.Sh.: SHEET 2 Check: Date:...
Page 5
15±3 5±3 ±3 ±2 3 2(MAX) ±3 Frequency(Hz) Response(dB) Flat 3±2 Jazz 1±1 0±3 8±3 1±2 Pops 4±1 8±2 Rock 2±1 5±2 3±2 Classic 1±1 0±1 Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2010-08-15 Tot.Sh.: SHEET 3 Check: Date:...
Page 6
(*2) Electronical Parameters are to be measured at speaker terminal across ohm load with input singal in cd mode setting in DBB Off unless specified otherwise. Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2010-08-15 Tot.Sh.: SHEET 4 Check: Date:...
Page 7
FM Channel Seperantion 1K Image IF Rejection Large Signal Selectivity Wave Range SENS Rejection Handling S9/300kHz Nom. 116 dBf Lim. 108 dBf μV/m Units. mV/m REMARKS Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2010-08-15 Tot.Sh.: SHEET 5 Check: Date:...
Page 8
Limit:3mV Max.volume noise(Bass off) Limit:1mV ipod&iphone Compatibility: iPod 5G, iPod nano 1G/2G/3G, iPodClassic, iPod Touch, iPhone&3G ipod&iphone charging : 1000mA ipad charging : 2100mA DVD PART Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2010-08-15 Tot.Sh.: SHEET 6 Check: Date:...
Page 9
Volume at Wakeup No of Timer Settings Clock Accuracy Lim. +/- 2 sec / day RC operating distance INDICATORS Display Type REMARKS VERSION OVERVIEW Tape PART SPECIFICATION Revise SET SPECIFICATION CD MICRO SYSTEM DCM3100 Name: Date:2011-08-15 Tot.Sh.: SHEET 7 Check: Date:...
Page 10
All manuals and user guides at all-guides.com MEASUREMENT SETUP Tuner FM Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Tuner AM (MW,LW) Bandpass LF Voltmeter...
All manuals and user guides at all-guides.com SERVICE AIDS WARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance.
All manuals and user guides at all-guides.com 2 - 1 INSTRUCTIONS ON CD PLAYABILITY Customer complaint "CD related problem" Set remains closed! check playability playability ok ? For flap loaders (= access to CD drive possible) "fast" lens cleaning cleaning method is recommended check playability playability...
Page 13
All manuals and user guides at all-guides.com 2 - 2 INSTRUCTIONS ON CD PLAYABILITY PLAYABILITY CHECK LIQUID LENS CLEANING Before touching the lens it is advised to clean the surface of the lens by blowing clean air over it. For sets which are compatible with CD-RW discs This to avoid that little particles make scratches on use CD-RW Printed Audio Disc ....7104 099 96611 the lens.
All manuals and user guides at all-guides.com 6 -1 6 - 1 LAYOUT DIAGRAM-MAIN BOARD...
Page 24
All manuals and user guides at all-guides.com 6 -2 6 - 2 LAYOUT DIAGRAM-CD/DISPLAY/USB/AUX BOARD TOP SIDE VIEW...
Page 25
All manuals and user guides at all-guides.com 6 -3 6 - 3 LAYOUT DIAGRAM-CD/DISPLAY/USB/AUX BOARD BOTTOM SIDE VIEW...
Page 26
All manuals and user guides at all-guides.com 6 -4 6 - 4 LAYOUT DIAGRAM-SMPS BOARD TOP SIDE VIEW...
Page 27
All manuals and user guides at all-guides.com 6 -5 6 - 5 LAYOUT DIAGRAM-SMPS BOARD BOTTOM SIDE VIEW...
Page 28
All manuals and user guides at all-guides.com 6 -6 6 -6 LAYOUT DIAGRAM-IPOD BOARD BOTTOM SIDE VIEW TOP SIDE VIEW...
Page 29
All manuals and user guides at all-guides.com 6 -7 6 -7 LAYOUT DIAGRAM-CD DOOR BOARD TOP SIDE VIEW BOTTOM SIDE VIEW...
Page 30
All manuals and user guides at all-guides.com 7 -1 7 - 1 EXPLODED VIEW...
Page 31
All manuals and user guides at all-guides.com Revision List Revision List Version 1.0 * Initial Release 14-1...
Page 32
All manuals and user guides at all-guides.com PARTLIST OF DCM3100/12 V1.0 The part list is for reference only, it might not be up to date. Please always refer to the system for latest spare part info. DCM3100 Level Item No. Alternativ...
Page 33
All manuals and user guides at all-guides.com DCM3100 Level Item No. Alternativ 12NC Description Safety PCM Code Main Unit - TUNER BOARD IC101 996510040734 SMT IC.RDS SI4705 20P 310-004705-120 √ Main Unit - MAIN BOARD CN104 996510052186 HEADER 2 PINS JST 2.0MM V 233-020200-020 √...
Page 34
All manuals and user guides at all-guides.com DCM3100 Level Item No. Alternativ 12NC Description Safety PCM Code IC903 996510038885 SMT IC AIC1526 310-001526-100 √ IC910 996510045008 SMT IC EN25P20 SOP 8PIN 310-002520-000 √ IC920 996510038889 SMD IC M5673 128PINS 310-005673-100 √...
Page 35
996510040648 ZENER 8.2V 1/2W 206-200082-102 √ ZD1104 996510040625 ZENER 12V 1/2W 206-200121-102 √ Note : Only the parts with Philips 12NCs are normal Service spare parts. 'V' means existing spare parts; "--" means non existing spare parts. Revsion List: V1.0 DCM3100/12 Partlist 11-1-2012...