Eight channel remote terminal loop start/ground start unit (16 pages)
Summary of Contents for PairGain HiGain HDU-217
Page 1
ECHNOLOGIES ® OUBLERS Model List Number Part Number CLEI Code HDU-217 150-1506-01 T1R5AS0EAA HDU-219 150-1501-01 T1R5AR0EAA HCC-239 150-1550-01 ECHNOLOGIES NGINEERING ERVICES ECHNICAL RACTICE 150-219-100-02 ECTION Revision History of this practice. Revision 02—December 22, 1997 A) Added references to new HCC-239 List 1 B) Added reference to AT&T 809 cabinet...
December 22, 1997 Section 150-219-100-02 TABLE OF CONTENTS PRODUCT OVERVIEW______________________________1 Description and Features ...........1 About the Mini Doubler..........2 Compatibility ............3 Specifications ............4 INSTALLING THE MINI DOUBLER __________________6 Inspecting Your Shipment .........6 Installing the Mini Doubler........6 Installing and Removing the Cut-Through Card..13 Locating Doubler Unit Enclosures ......
Page 4
Section 150-219-100-02 December 22, 1997 USING THIS TECHNICAL PRACTICE Two types of messages, identified by icons, appear in the text: A note informs you of special circumstances. Cautions indicate the possibility of damage to equipment or the possibility of personal injury. Page iv HDU-217/219 and HCC-239 List 1...
Proper electrostatic discharge procedures must be followed. ® ® The PairGain HiGain Models HDU-217 List 1 and HDU-219 List 1 are low power single-pair doubler units in mini-repeater packages. Each extends the range of a HiGain repeaterless fractional T1 transmission system.
Generic Equipment requirements TR-TSY-000063 and Transport System Generic Requirements TSGR TR-TSY-000499. About the Mini Doubler HiGain uses PairGain’s Two-Binary, One-Quaternary (2B1Q) High- bit-rate Digital Subscriber Line (HDSL) transceiver systems to establish a full-duplex, 784 kbps data channel between the line units and the remote units.
December 22, 1997 Section 150-219-100-02 Figure 2. Mini Doubler Block Diagram Compatibility These HiGain mini doublers operate with any number of other T1, POTS (Plain Old Telephone Service), Digital Data Service (DDS), or other HiGain systems sharing the same cable binder group. A list of HDSL signal cable losses for various cable gauges at 196 kHz and 135 Ohms is shown in Table 1.
Section 150-219-100-02 December 22, 1997 Specifications HDSL Line Code........... 784 kbps, 2B1Q full duplex Output ............+13 dBm Line Impedance .......... 135 Ohms Line Input DC Resistive Signature....25 Ohms Line Output DC Resistive Signature ... 25 Ohms Startup Time (per span) ......15 seconds (typical), 30 seconds (maximum) Line Clock Rate Internal Stratum 4 clock...
Page 9
December 22, 1997 Section 150-219-100-02 Environmental Operating Temperature ....... –40° to +149° F (–40° to +65° C) Operating Humidity (non-condensing) ..5% to 95% Operating Temperature in Outside Enclosures ......Complies with Section 10.2.1.3 of TA-NWT-001210 Operating Elevation........200 feet (60.96 m) below sea level to 13,000 feet (3.96 km) above sea level Dimensions...
Inspecting Your Shipment When you receive the equipment, inspect it for signs of damage. If the equipment has been damaged in transit, immediately report the extent of damage to the transportation company and to PairGain. Your shipment should consist of: •...
Page 11
Section 150-219-100-02 You must observe these constraints for reliable service under worst- case conditions. Consult PairGain when using the enclosures in environments that are more hostile than those allowed by the constraints or when using unlisted enclosures. Deployment rules for determining the the best location for the enclosures are provided in "Locating Doubler Unit Enclosures"...
Page 12
Section 150-219-100-02 December 22, 1997 For example, if the solar load is removed from the SPC 7430-8 T1 slot enclosure, whose capacity is two doubler units with solar load, capacity is increased to three doubler units. But this would necessitate placing two doublers side by side, with no empty slot between them.
Page 13
December 22, 1997 Section 150-219-100-02 Table 2. Indoor Enclosure Capacities for the HDU-219 without Solar Load Vendor Description Model HDU-219 239 T1 Recommended Number Doubler Repeater Slot Capacity Capacity Assignment for Maximum Capacity Charles Indoor wall CiAC2300* 1, 3, 5 mount CiAC2002* Indoor...
Page 14
Section 150-219-100-02 December 22, 1997 Table 3. Outdoor Enclosure Capacities for the with Full Solar Load HDU-219 Vendor Description Model HDU-219 239 T1 Recommended Number Doubler Repeater Slot Capacity Capacity Assignment for Maximum Capacity AT&T Outdoor dual 4 per 1, 5,11, 14, 15, chamber chamber/8 18, 22, 25...
Page 15
December 22, 1997 Section 150-219-100-02 Table 3. Outdoor Enclosure Capacities for the with Full Solar Load (continued) HDU-219 Vendor Description Model HDU- 239 T1 Recommended Number Repeater Slot Doubler Capacity Assignment Capacity for Maximum Capacity Sierra Outdoor 3011 3, 6 canister, Sunrise pole/wall...
Page 16
Section 150-219-100-02 December 22, 1997 Table 4. Outdoor Enclosure Capacities for the HDU-217 with Full Solar Load Vendor Description Model HDU- Recommended Number Repeater Slot Doubler Capacity Assignment Capacity for Maximum Capacity Outdoor 7130-0656 1, 6 or 3, 4 canister, pole/wall mount 7130-0856...
List 1 doubler units shipped with the HDU-219 Revision 02 practice. A block diagram of the HCC-239 is shown in Figure 3. A special insertion tool (Figure 4), the HCT-239 (PairGain part number 150-1595-01), that simplifies the HCC-239 installation may be purchased from PairGain.
Page 18
Section 150-219-100-02 December 22, 1997 To remove the HCC-239 card from the slot, proceed as follows: Grip the end of the tool and insert the tool into the slot cavity containing the HCC-239 card. Carefully insert the tool hook into the removal hole in the card. Align the hook along the open side of the card edge connnector.
December 22, 1997 Section 150-219-100-02 Figure 4. HCT-239 Insertion Tool Locating Doubler Unit Enclosures The physical location of the doubler units is determined by the following three deployment rules: Place the enclosures at the electrical limits, 35 dB, of each span. This would place the first doubler at the 35 dB location and the second at 70 dB.
Section 150-219-100-02 December 22, 1997 TESTING THE UNIT Using Alarms front panel contains one tri-color HDU-217 HDU-219 STATUS LED. The light color and whether it is steady or flashing provides you with the information listed in Table 5. Table 5. Front Panel Status Indicator STATUS LED Description Flashing green...
December 22, 1997 Section 150-219-100-02 Loopback Operation The complete family of loopbacks that a HiGain system can execute is shown in Figure 5. Four of these loopbacks, NDU1, NDU2, CDU1, and CDU2, occur in the doubler. The loopbacks can be initiated from the HLU RS-232 Craft port, the HLU front-panel buttons, or from a family of Special Loopback (SPLP) in-band loopback commands.
Page 22
Section 150-219-100-02 December 22, 1997 Figure 5. HiGain Loopbacks Page 18 HDU-217/219 and HCC-239 List 1...
December 22, 1997 Section 150-219-100-02 SYSTEM ADMINISTRATION Fault Isolation Solutions for common problems are listed in Table 7. For additional help, refer to Figure 5. Table 7. Fault Isolation Guide Problem Solution LED does not light 1 Verify that the HLU is installed and operational in the central office (CO).
Customer service provides after-sale support, including warranty administration, spare parts, repair parts, equipment repair and modification, technical service, engineering, and installation. PairGain Technical Assistance is available 24 hours a day, 7 days a week by contacting PairGain’s Customer Service Engineering group Telephone: 800.638.0031 or 714.832.9922...
This unit should not be field repaired. If it fails, replace it with another unit and return the faulty unit to PairGain for repair. Any modifications of the unit by anyone other than an authorized PairGain representative will void the warranty.
Section 150-219-100-02 December 22, 1997 Abbreviations American Wire Gauge HDU to Customer loopback Cyclic Redundancy Check Carrier Serving Area/Customer Service Area Dataphone Digital Service or Digital Data System HiGain Cut-Through Card HCDS High Capacity Digital Service HDSL High bit-rate Digital Subscriber Line HiGain Doubler Unit HiGain Line Unit HiGain Remote Unit...
Page 27
December 22, 1997 Section 150-219-100-02 HDU-217/219 and HCC-239 List 1 Page 23...