Page 1
OPERATION AND PARTS MANUAL EC-92S EC-92P ESSICK SERIES CONCRETE MIXERS Revision #7 (12/22/06)
Page 2
We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mikasa, Essick, Whiteman, Mayco, Toro Stone, Diamond Products, Generac Magnum, Airman, Haulotte, Barreto,...
Page 3
Engine exhaust some its constituents, and some dust created by power sanding, sawing, grinding, drillingandotherconstructionactivities contains chemicals known to the State of California to cause cancer, birth defects and other reproductive harm. Some examples of these chemicals are: Leadfromlead-basedpaints. Crystallinesilicafrombricks. Cementandothermasonryproducts.
EC-92P/S CONCRETE MIXER — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS Safety precautions should be followed at all times when Rotating Parts operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.
EC-92P/S CONCRETE MIXER — RULES FOR SAFE OPERATION ■ NEVER touch the hot exhaust manifold, DANGER: muffler or cylinder. Allow these parts to Failure to follow instructions in this manual may cool before servicing engine or mixer. lead to serious injury or even death! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only.
Page 10
EC-92P/S CONCRETE MIXER — RULES FOR SAFE OPERATION ■ NEVER run engine without air cleaner. Severe engine damage ■ NEVER disconnect any "emergency or safety devices" . may occur. These devices are intended for operator safety. Disconnection of these devices can cause severe injury, bodily harm or even ■...
EC-92P/S CONCRETE MIXER — OPERATION AND SAFETY DECALS Machine Safety Decals The MQ Eccick EC-92P and EC-92S mixers are equipped with a number of safety decals (Figure 1A). These decals are provided for operator safety and maintenance information. The illustration below and on the next page shows these decals as they appear on the machine.
Page 12
EC-92P/S CONCRETE MIXER — GENERAL INFORMATION Ensure that the extension cable is carefully laid out avoid- Application ing wet areas , sharp edges and locations where vehicles This mixer is only intended for the production of concrete . might run over it. Avoid allowing the extension cable to be The mixer must be used for its intended purpose and is not trapped underneath the mixer.
EC-92P/S CONCRETE MIXER — MIXER BASIC COMPONENTS Figure 2. Mixer Major Components Steel Mixing Drum — The EC-92S uses a 9 cu. ft steel Safety Chain — This mixer uses a 3/16-inch thick, 72- mixing drum. This drum is to be used for mixing of concrete. inches long zinc-plated saftey chain.
EC-92P/S CONCRETE MIXER — BASIC ENGINE COMPONENTS Honda GX Series Engine Shown Figure 3. Engine Controls and Components INITIAL SERVICING Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop the flow of fuel. The engine (Figure 3) must be checked for proper lubrication and Choke Lever –...
EC-92P/S CONCRETE MIXER — HANDWHEEL ASSEMBLY Assembly The EC-92P and EC-92S concrete mixers are shipped with the handwheel detached. Attach the handwheel to the mixer as shown in Figure 4. Figure 4. Handwheel Assembly EC-92P/S CONCRETE MIXER — PARTS & OPERATION MANUAL — REV. #7 (12/22/06) — PAGE 15...
EC-92P/S CONCRETE MIXER — SAFETY CHAIN CONNECTION CAUTION: CAUTION: CAUTION: CAUTION: CAUTION: 2. Route the safety chain through the holes just above the tow bar, located on each side of the mixer stand. NEVER ! tow the mixer with the safety chain Loop the chain together and place under the tow bar.
EC-92P/S CONCRETE MIXER — ELECTRIC MOTOR Electric Motor Electric Motor Voltage Change Switch For maintenance care and operation of the electric motor, refer ALWAYS make certain the electric motor's ON/OFF switch is in the "OFF" position and the power cord has been to your electric motor instruction booklet furnished with the electric disconnected from the power source.
Page 19
EC-92P/S CONCRETE MIXER — ELECTRIC MOTOR Figure 7. Single Phase Electric Motor with 12 inch Pigtail Cable EC-92P/S CONCRETE MIXER — PARTS & OPERATION MANUAL — REV. #7 (12/22/06) — PAGE 19...
Page 20
EC-92P/S CONCRETE MIXER — PRE-INSPECTION (GAS ENGINE) Before Starting 1. Read safety instructions at the beginning of manual. 2. Clean the mixer , removing dirt and dust, particularly the C ° engine cooling air inlet, carburetor and air cleaner. i r p l l a C °...
Page 21
EC-92P/S CONCRETE MIXER — INITIAL START-UP (GAS ENGINE) Starting the Engine (Gasoline Only) Turn the engine switch (Figure 13) to the ON position. The following steps outline the procedure for starting the engine. Depending on the type of engine employed in the mixer the steps may vary slightly.
EC-92P/S CONCRETE MIXER — INITIAL START-UP (ELECTRIC MOTOR) 5. Place the voltage selector switch (Figure 17) in the position Initial Start-up Instructions (Electric Motor) that is in accordance with voltage listed on the electric motor's Starting nameplate. The electric motor's are shipped from the factory CAUTION: CAUTION: CAUTION:...
EC-92P/S CONCRETE MIXER — OPERATION Operation 3. Placing the shovel all the way inside the drum (Figure 21) will cause the shovel to strike the blades. This condition will make 1. To position the tub, make sure the mixer is placed on firm level the shovel rotate, and could cause injury to personnel.
Page 24
EC-92P/S CONCRETE MIXER — MAINTENANCE (ENGINE) Use Table 8 as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. t n i ) 3 ( l i O r i A ) 1 (...
EC-92P/S CONCRETE MIXER — MAINTENANCE (ENGINE) Maintenance DANGER : Perform the scheduled maintenance procedures as defined by DO NOT use gasoline as a cleaning solvent, Table 6 and below: because that would create a risk of fire or DAILY explosion. ■...
EC-92P/S CONCRETE MIXER — MAINTENANCE (MIXER) Use Poleyrex EM (Exxon Mobil) or equalivant lubricant. Ball Socket and Clamp Face Maintenance Clean grease fitting, apply grease gun to fitting (1/2 shot). If the towing vechicle is equipped with a ball socket, smear Remember too much grease or injecting grease too quickly socket periodically with multi-purpose grease.
Page 27
EC-92P/S CONCRETE MIXER — MAINTENANCE (MIXER) Tires/Wheels/Lug Nuts Tires and wheels are a very important and critical compo- nents of the trailer. When specifying or replacing the trailer wheels it is important the wheels, tires, and axle are prop- erly matched. CAUTION: CAUTION: CAUTION:...
Page 28
EC-92P/S CONCRETE MIXER — MAINTENANCE (MIXER) Lug Nut Torque Requirements It is extremely important to apply and maintain proper wheel mounting torque on the trailer. Be sure to use only the fas- teners matched to the cone angle of the wheel. Proper pro- cedure for attachment of the wheels is as follows: 1.
EC-92P/S CONCRETE MIXER — TROUBLESHOOTING (ENGINE) diagnosis based on the Troubleshooting (Tables 10 and 11) Practically all breakdowns can be prevented by proper information shown below and on the next page. If the problem handling and maintenance inspections, but in the event of a cannot be remedied, please leave the unit just as it is and breakdown, please take a remedial action following the consult our company's business office or service plant.
Multiquip. A blank entry generally indicates that the item is not sold separately or is not sold by Multiquip. Other entries will be clarified in the “Remarks” Column. PAGE 32 —EC-92P/S CONCRETE MIXERS — PARTS & OPERATION MANUAL — REV. #7 (12/22/06)
EC-92P/S CONCRETE MIXER — SUGGESTED SPARE PARTS EC-92P/S CONCRETE MIXERS 1 TO 4 UNITS WITH HONDA GX240K1HA2 AND ROBIN EH25-2YR000 Part numbers on this Suggested Qty. Description Spare Parts List may supercede/ NOTE 2 ..503859 ....V-BELT w/GAS ENGINE, HONDA replace the P/N's shown in the 2 ..
Page 46
EC-92P/S — CABINET ASSEMBLY CABINET ASSY. PART NO PART NAME QTY. REMARKS 490202 RUBBER PROTECTOR 503598 CABINET, ENGINE ASSY. 492363 BOLT 5/16" NC X 3/4" G5 EM923023 WASHER, FLAT 5/16" 13287 LOCK NUT 8-32 ........... 6 ....REPLACEMENT PART ONLY 2203 WASHER, FLAT #10 ..........
Page 47
EC-92P/S — GAS ENGINE MOUNTING PLATE ASSEMBLY GAS ENGINE MOUNTING PLATE ASSY. PAGE 46 —EC-92P/S CONCRETE MIXERS — PARTS & OPERATION MANUAL — REV. #7 (12/22/06)
Page 48
EC-92P/S — GAS ENGINE MOUNTING PLATE ASSEMBLY GAS ENGINE MOUNTING PLATE ASSY. PART NO PART NAME QTY. REMARKS GX240K1HA2 ENGINE, HONDA 8.0 HP EH252YR000 ENGINE, ROBIN 8.5 HP 490956 RING, RETAINING 500275 SQUARE KEY 492468 SET SCREW 5/16" NC X 3/4" 492078 UPPER PULLEY 501019...
Page 49
EC-92P/S — ELECTRIC MOTOR MOUNTING PLATE ASSEMBLY ELECTRIC MOTOR MOUNTING PLATE ASSY. PAGE 48 —EC-92P/S CONCRETE MIXERS — PARTS & OPERATION MANUAL — REV. #7 (12/22/06)
Page 50
EC-92P/S — ELECTRIC MOTOR MOUNTING PLATE ASSEMBLY ELECTRIC MOTOR MOUNTING PLATE ASSY. PART NO PART NAME QTY. REMARKS P145K17DB45A MOTOR, ELECTRIC 1.5 HP 490956 RING, RETAINING 500275 SQUARE KEY 492468 SET SCREW 5/16" NC X 3/4" 502210 UPPER PULLEY 501019 SQUARE KEY 3/16"...
HONDA GX240K1HA2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PAGE 50 —EC-92P/S CONCRETE MIXERS — PARTS & OPERATION MANUAL — REV. #7 (12/22/06)
Page 52
HONDA GX240K1HA2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PART NO. PART NAME QTY. REMARKS 16271ZE2000 GASKET, ELBOW ........1 ..... INCLUDES ITEM W/ 17210ZE2515 ELEMENT, AIR CLEANER, DUAL 17218ZE2505 FILTER, OUTER 17231ZH9820 COVER, AIR CLEANER 17232891000 GROMMET, AIR CLEANER 17238ZE2310 COLLAR, AIR CLEANER 17239ZE1000...
HONDA GX240K1HA2 ENGINE — CONTROL ASSY. CONTROL ASSY. PART NO. PART NAME QTY. REMARKS 16551ZE2000 ARM, GOVERNOR 16555ZE2000 ROD, GOVERNOR 16561ZE2000 SPRING, GOVERNOR 16571ZE2000 SPRING, THROTTLE RETURN 16570ZE2W00 CONTROL ASSEMBLY ........ 1 ..INCLUDES ITEMS W/ 16571ZE2W00 LEVER, CONTROL 16574ZE1000 SPRING, LEVER 16575ZE2W00 WASHER, CONTROL LEVER...
Page 73
HONDA GX240K1HA2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PAGE 72 —EC-92P/S CONCRETE MIXERS — PARTS & OPERATION MANUAL — REV. #7 (12/22/06)
Page 74
HONDA GX240K1HA2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PART NO. PART NAME QTY. REMARKS 16854ZH8000 RUBBER SUPPORTER 107MM 16955ZE1000 JOINT, FUEL TANK 17510ZE2010ZD TANK COMP., FUEL *NH1*, BLACK 17620ZH7023 CAP COMP., FUEL FILLER ........1 ..INCLUDES ITEMS W/ 17631ZH7003 GASKET, FUEL FILLER CAP 17672ZE2W01...
Page 78
HONDA GX240K1HA2 ENGINE — PISTON ASSY. PISTON ASSY. PART NO. PART NAME QTY. REMARKS 13010ZE2013 RING SET, PISTON, STD. 13011ZE2013 RING SET, PISTON, OS 0.25, OPTIONAL 13012ZE2013 RING SET, PISTON, OS 0.50, OPTIONAL 13013ZE2013 RING SET, PISTON, 0.75, OPTIONAL 13101ZE2W00 PISTON, STANDARD 13102ZE2W00 PISTON, OS 0.25, OPTIONAL...
Need help?
Do you have a question about the Essick Series and is the answer not in the manual?
Questions and answers